Kohler K1191-LC - Manual - manualsarea.com

Page 2 - Important Information; WARNING: Risk of injury or property damage.; Important Product Information; Product Notices; NOTICE: Provide unrestricted service access to the pump.

Important Information WARNING: When using electrical products, basic precautions should always be followed, includingthe following: DANGER: Risk of electric shock. Connect only to a circuit protected by a Ground-Fault Circuit-Interrupter (GFCI). WARNING: Risk of electric shock. A licensed electricia...

Page 3 - Electrical Requirements; Table of Contents

Important Product Information (cont.) Electrical Requirements The installation must have a Class A Ground-Fault Circuit-Interrupter (GFCI). The GFCI protects againstline-to-ground shock hazard. Use a 240V, 15A, 60 Hz dedicated service. An equipment grounding terminal is provided in the field wiring ...

Page 4 - Solder

Thank You For Choosing Kohler Company We appreciate your commitment to Kohler quality. Please take a few minutes to review this manual beforeyou start installation. If you encounter any installation or performance problems, please don’t hesitate tocontact us. Our phone numbers and website are listed...

Page 5 - Chromatherapy lights-; Plastic suction cover-

1. List of New Terms Bathing well- The deep portion on the bath used by the bather. Bathing well rim- The high rim between the bathing well and the overflow channel. Water will cascade over the bathing well rim and into the overflow channel when entering the bath. Cavitation- When air is drawn into ...

Page 6 - Roughing In Information

2. Roughing In Information NOTICE: Unless otherwise specified, floor support under the bath must provide for a minimum of 80 lbs./square foot (390 Kg./square meter) loading. Consult local and national codes for a minimum air gap requirements when installing a spout on thefaucet deck. Unit requires t...

Page 7 - Construct the Stud Framing; Install the Rough Plumbing; Deck

3. Construct the Stud Framing NOTICE: Provide unrestricted service access to the pump, in-line heater and control box. You must construct an access panel to provide sufficient clearance for servicing the pump, in-line heater, and controlbox. Construct stud framing designed for your particular instal...

Page 8 - Install the Plumbing

6. Position the Unit CAUTION: Risk of product damage. Do not lift or support the unit by the pump or piping. With help, carefully lift the unit into place. Cut and discard the banding straps from the pump. Insert the drain tailpiece into the trap. 7. Install the Plumbing CAUTION: Risk of property da...

Page 9 - Make the Electrical Connections; Check the Connections and Fill the Unit

8. Make the Electrical Connections NOTE: The product model number is printed on a label on the pump side of the unit. This label also identifies the electrical rating of the product. WARNING: Risk of electrical shock. Make sure the power has been disconnected before performing the following procedur...

Page 11 - Complete the Finished Wall or Deck; Install the Faucet Trim; Access Panel

10. Complete the Finished Wall or Deck NOTICE: Provide unrestricted service access to the pump, in-line heater, and control box. You must construct an access panel to provide sufficient clearance for servicing the pump, in-line heater, and controlbox. Protect the product surface. Cover the framing w...

Page 12 - Fill the Bath; Operating Sequence

13. Using Your Bath Fill the Bath NOTE: Please read these steps carefully before you operate your bath. NOTE: The water temperature in the bath should not exceed 104° F (40° C) or the heater will not operate. IMPORTANT! Like any other bath, prevent flooding the area around the unit by entering the f...

Page 13 - Chromatherapy Light Operation

14. Chromatherapy Light Operation The submerged chromatherapy lights automatically turn on in the stationary setting when you start thebath. Press the “Lights” control switch (located on the opposite side of the pump control) once and thesubmerged chromatherapy lights will slowly cycle through the c...

Kohler K1191-LC - Manual

Table of Contents:

Summary

Other Kohler Models