Page 2 - Page ii
Page 3 - Page iii; Notice; CE Compliance; UL
Page iii Notice The material contained in this manual consists of information that is proprietary to JAI, Inc., and may only be used by the pur-chasers of the product. JAI, Inc. makes no warranty for the use of its product and assumes no responsibility for any errors which may appear or for damages ...
Page 4 - Page iv; WARNING
Page iv WARNING Changes or modifications to this unit not expressly approved by the party responsible for FCC compliance could void the user’s authority to operate the equipment. TM-2016-8/8CL Operation Manual JAI, Inc. 625 River Oaks ParkwaySan Jose, CA 95134Tel:(408) 383-0300 Tel:(800) 445-5444Fax...
Page 5 - Page v; Table of Contents; Introduction; Product Description
Page v Table of Contents Table of Contents Table of Contents . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . vList of Figures. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . viiList of Tables. . . . . . . . . . . . . . . . . ...
Page 6 - Page vi; External Sync and Pixel Locking; Troubleshooting
Page vi Table of Contents 3.7.1 Programmable Look-Up Table (LUT) and Knee Control . . . . . . . . . . . . . . 22 3.8 Scan Modes . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 23 3.8.1 Full Progressive Scan . . . . . . . . . . . . . . . . . . . . . . . . . . . ....
Page 7 - Page vii; List of Figures; Camera Link System Configuration
Page vii List of Figures List of Figures FIGURE 1. TM-2016-8 System Configuration . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4 FIGURE 2. Camera Link System Configuration . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4 FIGURE 3. Rear Panel View of Digital Connector ...
Page 8 - Page viii
Page 9 - Page ix; List of Tables; Shutter Speed Control Dial
Page ix List of Tables List of Tables TABLE 1. 12-Pin Connector (TM-2016-8) . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 6 TABLE 2. 12-Pin Connector (TM-2016-8CL) . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 7 TABLE 3. 31-Pin Connector (MP211-031-113-4300) . . . ....
Page 10 - Page x
Page 11 - Operation Manual; Introduction
May 31, 2007 TM-2016-8 and TM-2016-8CL Progressive Scan Shutter Camera TM-2016-8 and TM-2016-8CL Progressive Scan Shutter Camera Operation Manual 1 Introduction 1.1 Product Description The JAI, Inc. TM-2016-8 * is a high-resolution, high-speed monochrome progressive scan CCD camera. The interline-tr...
Page 12 - Miniaturized and lightweight
Page 2TM-2016-8 and TM-2016-8CL Progressive Scan Shutter Camera Introduction 1.2 Features • Miniaturized and lightweight The printed circuit boards in the TM-2016-8 have been arranged based on a new design philosophy that creates modular electronics for the camera, giving it flexibility. In addition...
Page 13 - Functional Options; Pixel clock locking
Page 3 TM-2016-8 and TM-2016-8CL Progressive Scan Shutter Camera Introduction The TM-2016-8 captures async reset images and provides single-shot video output with single FDV. This makes it simpler for an ordinary frame grabber to capture the async reset images. • Read Out Inhibit (ROI) When Asynchro...
Page 14 - System Configuration
Page 4TM-2016-8 and TM-2016-8CL Progressive Scan Shutter Camera Introduction 1.4 System Configuration FIGURE 1. TM-2016-8 System Configuration Figure 1 below presents a typical system configuration for the TM-2016-8 camera. FIGURE 2. Camera Link System Configuration Figure 2 below presents a typical...
Page 15 - Installation; Serial Communication Kit CS-232E
Page 5 TM-2016-8 and TM-2016-8CL Progressive Scan Shutter Camera Installation 2 Installation The following instructions are provided to help you to set up your camera quickly and easily. We suggest that you read through these instructions before you unpack and set up your camera system. 2.1 Getting ...
Page 20 - no shutter
Page 10TM-2016-8 and TM-2016-8CL Progressive Scan Shutter Camera Installation 2.2.3 Shutter Speed Control Dial (TM-2016-8 only) 2.2.4 RS-232 Communication Cable (TM-2016-8 only) FIGURE 4. Serial Communication Cable RS-232B-12 The RS-232 controller set CS-232E includes the RS-232B-12 interface cable,...
Page 22 - Power Supplies and Power Cable Setup; A universal voltage power supply with
Page 12TM-2016-8 and TM-2016-8CL Progressive Scan Shutter Camera Installation 2.2.6 Camera Link Cable (TM-2016-8CL only) The Camera Link cable assembly (26CL-02-26) has a 26-pin MDR26 connector on both ends. This is a straight-through cable. The pin-out configuration is shown in Table 4 on page 9. N...
Page 24 - Press the connector into place until firmly seated.
Page 14TM-2016-8 and TM-2016-8CL Progressive Scan Shutter Camera Installation 1. Rotate the connector while applying slight pressure until the keyways line up. 2. Press the connector into place until firmly seated. 3. Plug the power cord into the 100V AC socket. This will power the camera up. 2.2.8 ...
Page 25 - Operation; Digital Output connector
Page 15 TM-2016-8 and TM-2016-8CL Progressive Scan Shutter Camera Operation 3 Operation 3.1 Camera Rear Panel (TM-2016-8) 3.1.1 Up/Down Switch The Mode Selection switch works in conjunction with the Up/Down switch. Refer to Table 6 above for information on the Up/Down switch. 3.1.2 Digital Output Co...
Page 28 - Progressive Scanning; Progressive Scanning digital and analog output; Electronic Shutter
Page 18TM-2016-8 and TM-2016-8CL Progressive Scan Shutter Camera Operation 3.3 Progressive Scanning Standard TV-system scanning is 525 lines interlace scanning as specified in the RS-170 protocol. Every other horizontal line (odd lines and even lines) is scanned at a 60Hz rate per field, and the sca...
Page 29 - Asynchronous Reset; External VINIT with Pulse Width
Page 19 TM-2016-8 and TM-2016-8CL Progressive Scan Shutter Camera Operation 3.5 Integration The CCD imager of the TM-2016-8 can be exposed for longer than the normal scan timing of 1/8 sec. This integration feature provides extra sensitivity for dark-environment applications. The progressive scan im...
Page 32 - Dynamic Range Control
Page 22TM-2016-8 and TM-2016-8CL Progressive Scan Shutter Camera Operation 3.7 Dynamic Range Control The typical interline transfer CCD has fixed noise levels based on dark current (thermal or KT noise), pattern noise, and the operating clock speed. In general, the total noise level of the 20 MHz pi...
Page 34 - Camera Timing Charts; Pixel Clock and Digital Data; Horizontal Signals
Page 24TM-2016-8 and TM-2016-8CL Progressive Scan Shutter Camera Operation 3.10 Camera Timing Charts Model: TM-2016-8 Operation Mode: 8 frame / sec Master Clock: 40.00 MHz, M= 25 nsecPixel Clock: 20.00 MHz, P= 50 nsec 1. Pixel Clock and Digital Data Tcd Tdc Thd Tcd: Clock to Data ReadyTdc: Data Read...
Page 35 - External Reset Timing
Page 25 TM-2016-8 and TM-2016-8CL Progressive Scan Shutter Camera Operation Model: TM-2016-8 Operation Mode: 8 Frames/Second Master Clock: 40.0 MHz, M= 25.0 nsec Pixel Clock: 20.0 MHz, P= 50.0 nsec 3. External Reset Timing 4. Async Reset Timing External VD Internal VD FDV Digital Data Analog Video V...
Page 37 - Troubleshooting; Problems and Solutions
Page 27 TM-2016-8 and TM-2016-8CL Progressive Scan Shutter Camera Troubleshooting 4 Troubleshooting 4.1 Problems and Solutions Following are troubleshooting tips for common problems. In general, problems can easily be solved by following these instructions. If the following remedies fail to offer a ...
Page 38 - Information and Support Resources; For further information and support:
Page 28TM-2016-8 and TM-2016-8CL Progressive Scan Shutter Camera Troubleshooting 4.2 Information and Support Resources For further information and support: Phone: (408) 383-0300 (800) 445-5444 (24-hour message access) Fax: (408) 383-0301 E-mail: [email protected] Mail: JAI, Inc.Sales Department625 Riv...
Page 39 - Appendix; Model; MUST BE ORDERED SEPARATELY
Page 29 TM-2016-8 and TM-2016-8CL Progressive Scan Shutter Camera Appendix 5 Appendix 5.1 Specifications TABLE 7. TM-2016-8 and TM-2016-8CL Product Specifications Table Model TM-2016-8 and TM-2016-8CL Imager 1”, 7.4µm x 7.4µm progressive scan interline transfer CCD Active Pixels 1920 (H) x 1080 (V) ...
