Page 2 - WARNING
2 Part No. 1123839 WARNING DO NOT OPERATE THIS EQUIPMENT WITHOUT FIRST READING AND UNDERSTANDING THIS MANUAL. IF YOU ARE UNABLE TO UNDERSTAND THE WARNINGS, CAUTIONS, AND INSTRUCTIONS, CONTACT A HEALTHCARE PROFESSIONAL, DEALER OR TECHNICAL PERSONNEL IF APPLICABLE BEFORE ATTEMPTING TO USE THIS EQUIPME...
Page 3 - TABLE OF CONTENTS
TABLE OF CONTENTS Part No. 1123839 3 TABLE OF CONTENTS SPECIAL NOTES ................................................................................ 6TYPICAL PRODUCT PARAMETERS .................................................... 8LABEL LOCATIONS .......................................................
Page 6 - SPECIAL NOTES; NOTICE
6 Part No. 1123839 SPECIAL NOTES SPECIAL NOTES Signal words are used in this manual and apply to hazards or unsafe practices which could result in personal injury or property damage. Refer to the table below for definitions of the signal words. NOTICE THE INFORMATION CONTAINED IN THIS DOCUMENT IS SU...
Page 8 - TYPICAL PRODUCT PARAMETERS
8 Part No. 1123839 TYPICAL PRODUCT PARAMETERS TYPICAL PRODUCT PARAMETERS *NOTE: Values for range are calculated for maximum chair weight rating using largest batteries applicable (U1), per test procedures described in ANSI/RESNA WC/VOL2-1998 Section 4 and meet federal reimbursement requirements for ...
Page 9 - LABEL LOCATIONS; CAUTION
LABEL LOCATIONS Part No. 1123839 9 LABEL LOCATIONS Crossmember Lower Frame Tube WARNING DO NOT OPERATE WITHOUT THE ANTI-TIP TUBES INSTALLED. REV. 5/98 P/N 60106X144 Refer to Owner's Manualfor proper anti-tippersetting. 1085379 WARNING IMPORTANT NOTICE The wheel locks on this wheelchair have been p r...
Page 10 - SECTION 1—GENERAL GUIDELINES; Controller Settings/Repair or Service; Operating Information
10 Part No. 1123839 SECTION 1—GENERAL GUIDELINES SECTION 1—GENERAL GUIDELINES WARNING This section contains important information for the safe operation and use of this product. DO NOT use this product or any available optional equipment without first completely reading and understanding these instr...
Page 12 - Tire Pressure
12 Part No. 1123839 SECTION 1—GENERAL GUIDELINES DO NOT stand on the front riggings, otherwise damage may occur. When getting in or out of the wheelchair, make sure that the footplates on the front riggings are in the upward position or moved out of the way.ALWAYS wear your seat positioning strap. T...
Page 13 - Charging Batteries
SECTION 1—GENERAL GUIDELINES Part No. 1123839 13 If wet cell batteries are used, follow all manufacturer guidelines and instructions for installation and maintenance. Regardless of battery type, proper battery footprint and use of battery terminal caps as defined in Batteries on page 46 must be foll...
Page 14 - Grounding Instructions; DANGER; Rain Test
14 Part No. 1123839 SECTION 1—GENERAL GUIDELINES Grounding Instructions DANGER When using an extension cord having at least 16 AWG (American Wire Gauge) wire and the same or higher electrical rating as the device being connected. Use of improper extension cord could result in a risk of fire and elec...
Page 15 - Weight Training
SECTION 1—GENERAL GUIDELINES Part No. 1123839 15 Weight Training ProBasics DOES NOT recommend the use of its wheelchairs as a weight training apparatus. ProBasics wheelchairs have not been designed or tested as a seat for any kind of weight training. If occupant uses said wheelchair as a weight trai...
Page 16 - SECTION 2—EMI INFORMATION
16 Part No. 1123839 SECTION 2—EMI INFORMATION SECTION 2—EMI INFORMATION WARNING CAUTION: IT IS VERY IMPORTANT THAT YOU READ THIS INFORMATION REGARDING THE POSSIBLE EFFECTS OF ELECTROMAGNETIC INTERFERENCE ON YOUR POWERED WHEELCHAIR.Electromagnetic Interference (EMI) From Radio Wave Sources Powered wh...
Page 18 - SECTION 3—SAFETY/HANDLING OF; Stability and Balance; Coping With Everyday Obstacles
18 Part No. 1123839 SECTION 3—SAFETY/HANDLING OF WHEELCHAIRS SECTION 3—SAFETY/HANDLING OF WHEELCHAIRS “Safety and Handling” of the wheelchair requires the close attention of the wheelchair user as well as the assistant. This manual points out the most common procedures and techniques involved in the...
Page 19 - A Note to Wheelchair Assistants
SECTION 3—SAFETY/HANDLING OF WHEELCHAIRS Part No. 1123839 19 DO NOT go down ramp at full speed. Some seat/back positions will cause wheelchair to feel unstable. CAUTION Be aware of condition of ramp. Traction will be diminished/nonexistent on a slippery surface. Proceed with caution. A Note to Wheel...
Page 21 - ESCALATORS WARNING; Transferring to and From Other Seats
SECTION 3—SAFETY/HANDLING OF WHEELCHAIRS Part No. 1123839 21 5. Using non-removable (non-detachable) parts of the wheelchair, lift the wheelchair off the ground and transfer the wheelchair up or down the stairs. 6. The wheelchair should not be lowered until the last stair has been negotiated and the...
Page 22 - Percentage of Weight Distribution; Reaching, Leaning and
22 Part No. 1123839 SECTION 3—SAFETY/HANDLING OF WHEELCHAIRS Percentage of Weight Distribution WARNING DO NOT attempt to reach objects if you have to move forward in the seat or pick them up from the floor by reaching down between your knees.Proper positioning is essential for your safety. When reac...
Page 23 - Reaching and Bending - Backward
SECTION 3—SAFETY/HANDLING OF WHEELCHAIRS Part No. 1123839 23 FIGURE 3.2 Reaching, Leaning and Bending - Forward Reaching and Bending - Backward WARNING DO NOT lean over the top of the back upholstery. This will change your center of gravity and may cause you to tip over. NOTE: For this procedure, re...
Page 24 - SECTION 4—SAFETY; Safety Inspection Checklists; Inspect/Adjust Initially
24 Part No. 1123839 SECTION 4—SAFETY INSPECTION/TROUBLESHOOTING SECTION 4—SAFETY INSPECTION/TROUBLESHOOTING NOTE: Every six months or as necessary take your wheelchair to a qualified dealer for a thorough inspection and servicing. Regular cleaning will reveal loose or worn parts and enhance the smoo...
Page 25 - Inspect/Adjust Weekly
SECTION 4—SAFETY INSPECTION/TROUBLESHOOTING Part No. 1123839 25 ❑ Inspect tires for flat spots and wear. If tires are pneumatic, check for proper inflation. ❑ Seat and/or back upholstery have no rips and do not sag. Replace if necessary. Inspect/Adjust Weekly ❑ Seat is secured to wheelchair frame. ❑...
Page 26 - Troubleshooting - Mechanical
26 Part No. 1123839 SECTION 4—SAFETY INSPECTION/TROUBLESHOOTING ❑ Ensure seat and/or back upholstery have no rips and do not sag. Replace if necessary. ❑ Ensure seat release latch is not worn. Replace if necessary. ❑ Seat and/or back upholstery have no rips and do not sag. Replace if necessary. ❑ Cl...
Page 27 - Checking Battery Charge Level
SECTION 4—SAFETY INSPECTION/TROUBLESHOOTING Part No. 1123839 27 NOTE: For additional troubleshooting information and explanation of error codes, refer to the Electronics Manual (P/N 1123804) supplied with each wheelchair. Checking Battery Charge Level Wheelchair does not respond to commands. Power o...
Page 28 - SECTION 5—WHEELCHAIR; Joystick Switches and Indicators; Multi Function Charger Port; Speed Control switch
28 Part No. 1123839 SECTION 5—WHEELCHAIR OPERATION SECTION 5—WHEELCHAIR OPERATION WARNING After ANY adjustments, repair or service and before use, make sure that all attaching hardware is tightened securely - otherwise injury or damage may result.Set-up of Electronics Control Unit is to be performed...
Page 29 - Information Gauge Display
SECTION 5—WHEELCHAIR OPERATION Part No. 1123839 29 FIGURE 5.1 Joystick Switches and Indicators Information Gauge Display The Information Gauge Display is located on the front of the joystick housing. It provides the following information to the user on the status of the wheelchair -1. Power is on.2....
Page 31 - Operating the Wheelchair; Turning the Power On/Off; Using the Horn
SECTION 5—WHEELCHAIR OPERATION Part No. 1123839 31 Operating the Wheelchair NOTE: For this procedure, refer to FIGURE 5.2 on page 32. Turning the Power On/Off 1. To turn the power On, press the On/Off button. NOTE: After turning power On, all indicators will light briefly and the display gauge will ...
Page 33 - SECTION 6—FRONT RIGGINGS; Installing
SECTION 6—FRONT RIGGINGS Part No. 1123839 33 SECTION 6—FRONT RIGGINGS WARNING After ANY adjustments, repair or service and before use, make sure that all attaching hardware is tightened securely - otherwise injury or damage may result.Before performing any maintenance, adjustment or service verify t...
Page 34 - Removing; Adjusting the Footrest Height
34 Part No. 1123839 SECTION 6—FRONT RIGGINGS Removing 1. Push the footrest release lever inward.2. Rotate swingaway footrest assembly outward.3. Lift the swingaway footrest assembly off of the hinge pins. Using 1. To move the footrest out of the way without removing, push the footrest release lever ...
Page 35 - Replacing the Heel Loop; Raising/Lowering the Legrest Assembly
SECTION 6—FRONT RIGGINGS Part No. 1123839 35 Replacing the Heel Loop NOTE: For this procedure, refer to FIGURE 6.3. 1. Pull the cam lock lever up to the unlocked position.2. Push in the release buttons and remove the lower footrest assembly.3. Remove the mounting screw, spacer and locknut that secur...
Page 37 - SECTION 7—ARMS; Adjusting Armrest Height
SECTION 7—ARMS Part No. 1123839 37 SECTION 7—ARMS WARNING After ANY adjustments, repair or service and before use, make sure that all attaching hardware is tightened securely - otherwise injury or damage may result.Before performing any maintenance, adjustment or service verify that On/Off switch on...
Page 39 - SECTION 8—SEAT AND BACK; Replacing the Seat Upholstery
SECTION 8—SEAT AND BACK Part No. 1123839 39 SECTION 8—SEAT AND BACK WARNING After ANY adjustments, repair or service and before use, make sure that all attaching hardware is tightened securely - otherwise injury or damage may result.Before performing any maintenance, adjustment or service verify tha...
Page 40 - Replacing the Back Upholstery
40 Part No. 1123839 SECTION 8—SEAT AND BACK Replacing the Back Upholstery NOTE: For the following procedure, refer to FIGURE 8.2. 1. Flip swing back arms up and out of the way. Refer to Swing-Back Arms on page 38.2. Remove the six mounting screws and washers that secure the existing back upholstery ...
Page 41 - Adjusting the Back Height
SECTION 8—SEAT AND BACK Part No. 1123839 41 Adjusting the Back Height NOTE: For this procedure, refer to FIGURE 8.3.NOTE: Back canes must be adjusted to the same height. 1. Remove the two mounting screws and locknuts that secure the two back canes to the wheelchair frame. 2. Reposition the back cane...
Page 42 - Replacing Seat Positioning Strap
42 Part No. 1123839 SECTION 8—SEAT AND BACK Replacing Seat Positioning Strap NOTE: For this procedure, refer to FIGURE 8.4. 1. If necessary, remove the seat cushion from the seat upholstery.2. Remove the two rear phillips screws and washers that secure the seat upholstery and seat positioning strap ...
Page 43 - SECTION 9—JOYSTICK; Preparing the Joystick for Use
SECTION 9—JOYSTICK Part No. 1123839 43 SECTION 9—JOYSTICK WARNING After ANY adjustments, repair or service and before use, make sure that all attaching hardware is tightened securely - otherwise injury or damage may result.Before performing any maintenance, adjustment or service verify that On/Off s...
Page 44 - Repositioning the Joystick
44 Part No. 1123839 SECTION 9—JOYSTICK Repositioning the Joystick NOTE: For this procedure, refer to FIGURE 9.2.NOTE: Before starting this procedure, it may be necessary to snip the tie-wraps (not shown in FIGURE 9.2) securing the joystick control cord to the wheelchair. Before snipping the tie-wrap...
Page 45 - SECTION 10—CASTERS; Adjusting Forks
SECTION 10—CASTERS Part No. 1123839 45 SECTION 10—CASTERS WARNING After ANY adjustments, repair or service and before use, make sure that all attaching hardware is tightened securely - otherwise injury or damage may result.Before performing any maintenance, adjustment or service verify that On/Off s...
Page 46 - SECTION 11—BATTERIES; When to Charge Batteries
46 Part No. 1123839 SECTION 11—BATTERIES SECTION 11—BATTERIES WARNING After ANY adjustments, repair or service and before use, make sure that all attaching hardware is tightened securely - otherwise injury or damage may result.The use of rubber gloves is recommended when working with batteries.Befor...
Page 47 - Description and Use of Battery Chargers
SECTION 11—BATTERIES Part No. 1123839 47 Charging Batteries WARNING Never attempt to recharge the batteries by attaching cables directly to the battery terminals or clamps. Use the recharging plug located on the front of the joystick.DO NOT attempt to recharge the batteries and operate the power whe...
Page 48 - Connecting the Battery Charger; Replacing the Batteries
48 Part No. 1123839 SECTION 11—BATTERIES Connecting the Battery Charger NOTE: For this procedure, refer to FIGURE 11.2. 1. Attach the battery charger connector to the charger port on the joystick. 2. Plug the charger’s AC power cord, or extension, into the grounded 120 VAC wall outlet. 3. Wait until...
Page 49 - Cleaning Battery Terminals; Removing/Installing the Battery Boxes
SECTION 11—BATTERIES Part No. 1123839 49 2. Remove the existing batteries from the battery boxes. Refer to Installing/Removing Batteries Into/From Battery Boxes on page 51. 3. Clean the new battery terminals.4. Install the new batteries into the battery boxes. Refer to Installing/Removing Batteries ...
Page 51 - Installing/Removing Batteries Into/From Battery Boxes
SECTION 11—BATTERIES Part No. 1123839 51 Installing/Removing Batteries Into/From Battery Boxes WARNING Make sure power to the wheelchair is Off before performing this procedure.The use of rubber gloves is recommended when working with batteries.ProBasics strongly recommends that battery installation...
Page 52 - Connecting Battery Cables
52 Part No. 1123839 SECTION 11—BATTERIES CAUTION Some battery manufacturers mold a carrying strap and/or hold down flanges directly into the battery case. Batteries which interfere with the battery box cannot be used for these applications. Attempting to “wedge” a battery into a battery box may dama...
Page 54 - Replacing Battery Box Retaining Strap
54 Part No. 1123839 SECTION 11—BATTERIES FIGURE 11.7 Connecting Battery Cables Replacing Battery Box Retaining Strap WARNING The battery box retaining strap MUST be fastened securely and adjusted properly to hold battery boxes in place before using the wheelchair. NOTE: For this procedure, refer to ...
Page 56 - SECTION 12—CLUTCH/MOTOR; Engaging/Disengaging the Clutches
56 Part No. 1123839 SECTION 12—CLUTCH/MOTOR LOCK SECTION 12—CLUTCH/MOTOR LOCK WARNING After ANY adjustments, repair or service and before use, make sure all attaching hardware is tightened securely - otherwise injury or damage may result. Engaging/Disengaging the Clutches WARNING DO NOT engage or di...
Page 57 - SECTION 13—WHEEL LOCKS; Installing/Adjusting/Using the Wheel Locks
SECTION 13—WHEEL LOCKS Part No. 1123839 57 SECTION 13—WHEEL LOCKS WARNING After ANY adjustments, repair or service and before use, make sure all attaching hardware is tightened securely - otherwise injury or damage may result. Installing/Adjusting/Using the Wheel Locks NOTE: For this procedure, refe...
Page 58 - Using
58 Part No. 1123839 SECTION 13—WHEEL LOCKS FIGURE 13.1 Installing/Adjusting/Using the Wheel Locks Using The wheelchair is equipped with a pair of independently operated wheel locks located just in front of the rear wheels.1. To engage the wheel locks, grip the handle and push forward to the lock pos...
Page 59 - SECTION 14—ANTI-TIPPERS
SECTION 14—ANTI-TIPPERS Part No. 1123839 59 SECTION 14—ANTI-TIPPERS WARNING After ANY adjustments, repair or service and before use, make sure all attaching hardware is tightened securely - otherwise injury or damage may result. Installing/Removing/Adjusting Anti-Tippers NOTE: For this procedure, re...
Page 61 - SECTION 15—TRANSPORTING; Transporting the Wheelchair
SECTION 15—TRANSPORTING Part No. 1123839 61 SECTION 15—TRANSPORTING WARNING After ANY adjustments, repair or service and before use, make sure all attaching hardware is tightened securely - otherwise injury or damage may result. Transporting the Wheelchair WARNING The weight of the wheelchair withou...
Page 63 - LIMITED WARRANTY
LIMITED WARRANTY Part No. 1123839 63 LIMITED WARRANTY PLEASE NOTE: THE WARRANTY BELOW HAS BEEN DRAFTED TO COMPLY WITH FEDERAL LAW APPLICABLE TO PRODUCTS MANUFACTURED AFTER JULY 4, 1975.This warranty is extended only to the original purchaser/user of our products.This warranty gives you specific lega...
