Page 2 - WARNING
Electric Portable Patient Lift 2 Part No. 1145810 WARNING DO NOT OPERATE THIS EQUIPMENT WITHOUT FIRST READING AND UNDERSTANDING THIS MANUAL. IF YOU ARE UNABLE TO UNDERSTAND THE WARNINGS, CAUTIONS AND INSTRUCTIONS CONTACT A QUALIFIED DEALER OR INVACARE TECHNICAL SUPPORT BEFORE ATTEMPTING TO USE THIS ...
Page 3 - TABLE OF CONTENTS
TABLE OF CONTENTS Part No. 1145810 3 Electric Portable Patient Lift TABLE OF CONTENTS SPECIAL NOTES ................................................................................ 9LABEL LOCATION .......................................................................... 10SPECIFICATIONS ..............
Page 6 - REGISTER YOUR PRODUCT; Complete and mail the form on the next page
Electric Portable Patient Lift 6 Part No. 1145810 REGISTER YOUR PRODUCT The benefits of registering:1. Safeguard your investment.2. Ensure long term maintenance and servicing of your purchase.3. Receive updates with product information, maintenance tips, and industry news.4. Invacare can contact you...
Page 7 - PRODUCT REGISTRATION FORM
Name _______________________________________________________________ Address _____________________________________________________________ City ___________________ State/Province __________ Zip/Postal Code ________ Email ___________________________________ Phone No. _________________ Invacare Model ...
Page 9 - SPECIAL NOTES; NOTICE; THE INFORMATION CONTAINED IN THIS DOCUMENT IS SUBJECT TO
SPECIAL NOTES Part No. 1145810 9 Electric Portable Patient Lift SPECIAL NOTES Signal words are used in this manual and apply to hazards or unsafe practices which could result in personal injury or property damage. Refer to the table below for ...
Page 10 - LABEL LOCATION
LABEL LOCATION Electric Portable Patient Lift 10 Part No. 1145810 LABEL LOCATION WARNING Mast pivot under rubberb o o t m u s t b e t i g h t t oensure safe use of yourpatient lift. Bolt must bechecked at least every six(6) months in conjunctionwith periodic maintenance.See Owner's Manual. P/N 11302...
Page 11 - SPECIFICATIONS; Patient Lift
SPECIFICATIONS Part No. 1145810 11 Electric Portable Patient Lift SPECIFICATIONS Patient Lift *NOTE: Varies depending upon load and stroke. 450 lb. 600 lb. Low Profile RPL450-2 Low Profile RPL600-2 Height at Sling Hook-up - MAX. 74 inches 68 inches Height at Sling Hook-up - MIN. 24 inche...
Page 12 - Full Body, Divided Leg and Toileting Slings; Automatic Power Down:
SPECIFICATIONS Electric Portable Patient Lift 12 Part No. 1145810 Full Body, Divided Leg and Toileting Slings *NOTE: Slings made of a mesh material. NOTE: All dimensions are in inches except where noted. Reliant Scale RLS6 Full Body Full Body w/Commode Divided Leg Toileti...
Page 13 - SECTION 1—GENERAL GUIDELINES; operation and use of this product.; Assembling the Patient Lift
SECTION 1—GENERAL GUIDELINES Part No. 1145810 13 Electric Portable Patient Lift SECTION 1—GENERAL GUIDELINES WARNING SECTION 1 - GENERAL GUIDELINES contains important information for the safe operation and use of this product. DO NOT use this product or any available optional equipment without first...
Page 14 - Using the Sling
SECTION 1—GENERAL GUIDELINES Electric Portable Patient Lift 14 Part No. 1145810 Make sure there is an audible click when mounting battery on the battery charger to confirm proper mounting. Otherwise, injury or damage may occur. DO NOT exceed maximu...
Page 15 - Transferring the Patient
SECTION 1—GENERAL GUIDELINES Part No. 1145810 15 Electric Portable Patient Lift Invacare slings are made specifically for use with Invacare patient lifts. For the safety of the patient, DO NOT intermix slings and patient lifts of different manufact...
Page 16 - Electrical - Grounding Instructions
SECTION 1—GENERAL GUIDELINES Electric Portable Patient Lift 16 Part No. 1145810 Regular maintenance of patient lifts and accessories is necessary to assure proper operation. DO NOT overtighten mounting hardware. This will damage mounting brackets. After th...
Page 17 - SECTION 2— INSTALLATION; Introduction; correct alignment of all parts for safe functional operation.; Assembling the Mast to the Base
INSTALLATION Part No. 1145810 17 Electric Portable Patient Lift SECTION 2— INSTALLATION Introduction WARNING Use only Invacare parts in the assembly of this patient lift. The base legs, mast, and boom assembly and the swivel bar are manufactured to specifications that assure correct alignment of all...
Page 18 - Assembling the Boom Actuator
INSTALLATION Electric Portable Patient Lift 18 Part No. 1145810 FIGURE 2.2 Assembling Mast to Base Assembling the Boom Actuator NOTE: For this procedure, refer to FIGURE 2.3. 1. Remove the shoulder bolt, washer and nut from the mounting bracket on the boom ass...
Page 19 - CAUTION; Installing the Leg Actuator to the Base
INSTALLATION Part No. 1145810 19 Electric Portable Patient Lift 7. Align the holes of the boom assembly mounting bracket with those of the boom actuator and insert the bolt. Secure with nut. NOTE: Be sure that the bolt is completely through ...
Page 22 - Using the Pendant Buttons
OPERATING THE PATIENT LIFT Electric Portable Patient Lift 22 Part No. 1145810 SECTION 3—OPERATING THE PATIENT LIFT Introduction WARNING DO NOT attempt any transfer of a patient without approval of the patient's physician, nurse, or medical assistant. Thoroughly read the instructions in this owner's ...
Page 23 - Opening/Closing the Legs; Activating a Mechanical Emergency Release; Primary Emergency Release
OPERATING THE PATIENT LIFT Part No. 1145810 23 Electric Portable Patient Lift Opening/Closing the Legs To open the legs, press the legs open button. To close the legs, press the legs closed button. FIGURE 3.1 Pendant Buttons Activating a Mechanical Emergency Release P...
Page 24 - Performing an Emergency Stop; Charging the Battery
OPERATING THE PATIENT LIFT Electric Portable Patient Lift 24 Part No. 1145810 Secondary Emergency Release NOTE: For this procedure, refer to FIGURE 3.3. NOTE: Use the primary emergency release first. The secondary emergency release is only a back ‐ up to t...
Page 26 - SECTION 4—LIFTING THE PATIENT
LIFTING THE PATIENT Electric Portable Patient Lift 26 Part No. 1145810 SECTION 4—LIFTING THE PATIENT Introduction NOTE: Invacare recommends that two assistants be used for all lifting preparation and transferring to/from procedures; however, our equipment will ...
Page 27 - Attaching a Sling; Lifting/Moving the Patient
LIFTING THE PATIENT Part No. 1145810 27 Electric Portable Patient Lift Attaching a Sling NOTE: For this procedure, refer to FIGURE 4.2. 1. Place the straps of the sling over the hooks of the swivel bar. 2. Match the corresponding colors on each side ...
Page 31 - Transferring to a Commode Chair; Transferring to a Standard Commode
TRANSFERRING THE PATIENT Part No. 1145810 31 Electric Portable Patient Lift Transferring to a Commode Chair NOTE: For this procedure, refer to FIGURE 5.1. 1. Lift the patient from the bed. Refer to Lifting the Patient on page 26. 2. Press the boom up butto...
Page 32 - Transferring to a Bathing Unit
TRANSFERRING THE PATIENT Electric Portable Patient Lift 32 Part No. 1145810 4. Press the boom up/down buttons to elevate the patient high enough to clear the commode. Their weight will be supported by the patient lift. 5. Guide the patient onto t...
Page 33 - into the wheelchair for transport. Otherwise, injury may result.
TRANSFERRING THE PATIENT Part No. 1145810 33 Electric Portable Patient Lift WARNING DO NOT place the patient in the wheelchair if the locks are not engaged. The wheelchair wheel locks MUST be in a locked position before lowering the patient into the wheelchair for transport. Otherwise, injury may re...
Page 34 - SECTION 6— TROUBLESHOOTING
TROUBLESHOOTING Electric Portable Patient Lift 34 Part No. 1145810 SECTION 6— TROUBLESHOOTING NOTE: If problems are not remedied by the suggested means, please contact your dealer or Invacare . SYMPTOMS FAULTS SOLUTION Patient lift feels loose. Mast/base joint loose.Tie...
Page 35 - SECTION 7— MAINTENANCE; Maintenance Safety Inspection Checklist
MAINTENANCE Part No. 1145810 35 Electric Portable Patient Lift SECTION 7— MAINTENANCE Maintenance Safety Inspection Checklist For individual home use, a full inspection is required prior to each new user. Regular cleaning will reveal loose or worn parts, enh...
Page 36 - Lubricating the Lift; Detecting Wear and Damage
MAINTENANCE Electric Portable Patient Lift 36 Part No. 1145810 The Invacare Patient Lift is designed to provide a maximum of safe, efficient and satisfactory service with minimum care and maintenance. All parts of the patient lift are made of ...
Page 37 - Cleaning the Sling and the Lift
MAINTENANCE Part No. 1145810 37 Electric Portable Patient Lift Cleaning the Sling and the Lift The sling should be washed regularly in water temperature of 180°F (82°C) and a biological solution. A soft cloth, dampened with water and a small amount ...
Page 38 - Checking and Tightening Mast Pivot Bolt; Replacing the Swivel Bar; these parts become worn, replacement must be made.
MAINTENANCE Electric Portable Patient Lift 38 Part No. 1145810 Checking and Tightening Mast Pivot Bolt NOTE: For this procedure, refer to FIGURE 7.3. 1. Lift up the back of the rubber boot and slide it off the mast along the boom. 2. Check that the b...
Page 39 - Maintaining the Base Adjustment
MAINTENANCE Part No. 1145810 39 Electric Portable Patient Lift FIGURE 7.4 Replacing the Swivel Bar Maintaining the Base Adjustment NOTE: For this procedure, refer to FIGURE 7.5. The base adjustment should not require any attention other than: 1. Check that the leg...
Page 40 - Replacing Casters/Forks; Replacing Front Casters
MAINTENANCE Electric Portable Patient Lift 40 Part No. 1145810 Replacing Casters/Forks Replacing Rear Casters NOTE: For this procedure, refer to FIGURE 7.6 1. Place the lift on its side. 2. Remove the bolt and locknut that secure the existing rear caster t...
Page 41 - Replacing Forks
MAINTENANCE Part No. 1145810 41 Electric Portable Patient Lift Replacing Forks WARNING Ensure that there is sufficient room to turn patient lift on its side and that floor area is clear of debris. Otherwise, injury to personnel or damage to patient lift may occur. 1. Place the patient lift o...
Page 42 - SECTION 8— ACCESSORIES; Reliant Scale RLS6
ACCESSORIES Electric Portable Patient Lift 42 Part No. 1145810 SECTION 8— ACCESSORIES Reliant Scale RLS6 The Reliant Scale is a compact precision scale system designed specifically for the Invacare Patient Lift System. WARNING DO NOT install or use this equipment with...
Page 44 - Operating the Scale; Keypad Functions; Reliant Scale
ACCESSORIES Electric Portable Patient Lift 44 Part No. 1145810 Operating the Scale Keypad Functions NOTE: For this procedure, refer to FIGURE 8.3. FIGURE 8.3 Operating the Scale - Keypad Functions KEY INDICATOR DISPLAYED INDICATOR LOCATION DEFINITION ON OFF OFF Center of Display Window P...
Page 45 - Weighing the Patient; exceed the lowest rated capacity of any component.
ACCESSORIES Part No. 1145810 45 Electric Portable Patient Lift Weighing the Patient WARNING The weight capacity is limited to the lowest rated capacity of any one of the compo- nents in use (e.g. Patient Lift, Sling or Scale). The patient's weight MUST not exceed the lowest rated capacity of any com...
Page 46 - Calibrating the Reliant Scale
ACCESSORIES Electric Portable Patient Lift 46 Part No. 1145810 NOTE: Stable being defined as the weight fluctuating two tenths of a pound. For example, a patient weighing one hundred pounds, the scale will fluctuate between 99.8 and 100.2 unt...
Page 47 - Troubleshooting; SYMPTON
ACCESSORIES Part No. 1145810 47 Electric Portable Patient Lift 2. With the Reliant Scale on, remove the four screws on the back of the enclosure and remove the front cover to expose the PC board. 3. Press the CAL button located on the PC ...
Page 48 - Display Codes; CAL
ACCESSORIES Electric Portable Patient Lift 48 Part No. 1145810 Display Codes CALIBRATION REQUIRED ‐ Indicates improper stored calibration data, calibration is necessary. OVER CAPACITY ‐ Indicates a weight exceeding the capacity has been loaded on the scale...
Page 49 - NOTES
ACCESSORIES Part No. 1145810 49 Electric Portable Patient Lift NOTES
Page 51 - LIMITED WARRANTY
LIMITED WARRANTY Part No. 1145810 51 Electric Portable Patient Lift LIMITED WARRANTY PLEASE NOTE: THE WARRANTY BELOW HAS BEEN DRAFTED TO COMPLY WITH FEDERAL LAW APPLICABLE TO PRODUCTS MANUFACTURED AFTER JULY 4, 1975.This warranty is extended only to the original purchaser/user of our products.This w...
