Page 2 - SPECIAL NOTES; WA R N I N G
2 SPECIAL NOTES SPECIAL NOTES WA R N I N G DO NOT install, maintain or operate this equipmentwithout first reading and understanding this manual.If you are unable to understand the WARNINGS andINSTRUCTIONS, contact your Home Healthcare Dealerbefore attempting to use this equipment - otherwiseinjury ...
Page 3 - TABLE OF CONTENTS
3 TABLE OF CONTENTS TABLE OF CONTENTS SPECIAL NOTES .............................................................................................. 2 TABLE OF CONTENTS ................................................................................... 3 SAFETY SUMMARY ...................................
Page 4 - SAVE THESE INSTRUCTIONS.; SAFETY SUMMARY
4 READ ALL INSTRUCTIONS BEFORE USING. When using electrical products, especially when children are present, basic safetyprecautions should always be followed, including the following: D A N G E R TO REDUCE THE RISK OF ELECTROCUTION:Always unplug this product IMMEDIATELY after using. DO NOT use while...
Page 5 - Battery Pack Dimensions:; MODEL IRC 1195 SPECIFICATIONS; SPECIFICATIONS
5 Electrical Requirements: 90-240 VAC, 50-60Hz, or 12 -14 VDC Running Current: 2A @ 10 psig @ 12 volts (approximately) Ambient Temperature Range: 10 o C - 40 o C (50 o F - 104 o F) NOTE: Operating at temperature extremes mayincrease treatment times. Power Wattage: 24 Watts, 60VA ~ Thermal Protector:...
Page 6 - FREEWAY LITE; C A U T I O N; FEATURES
6 FREEWAY LITE When you unpack your Freeway Lite, you will notice that the battery pack, nebulizer kit, 12 volt DC lead, AC/DC power pack and power cord are separated from the main unit. The 12 volt DC lead, AC/DC power pack and power cord may be stored in the detach-able accessory bag. The batter...
Page 7 - LOW Power; FIGURE 2 - FRONT CONTROL PANEL
7 Battery Pack Filter ON/OFF Switch Nebulizer Air Tubing Connection Power ON LOW Power Charging Battery Connectors Located Behind the Battery Pack NOTE: Rubber covers are installed on the battery connectors. Remove them beforeinstalling the battery pack. Battery Connectors Located Behind the Battery...
Page 8 - THE FREEWAY LITE AC/DC POWER PACK; THE SIDESTREAM NEBULIZER KIT
8 FEATURES THE FREEWAY LITE AC/DC POWER PACK The Freeway Lite Power Pack is required for running the Freeway Lite from AC walloutlets and to recharge the batteries when not in use. Your AC/DC Power Pack andcord are designed to operate from U.S. and North American outlet voltages and plugconfiguratio...
Page 9 - INTRODUCTION; BATTERIES in the OPERATION Section of this manual).; OPERATION; CHARGING THE BATTERIES; Initial Battery Charging
9 INTRODUCTION Freeway Lite is different than other aerosol compressors because it is smaller, lighter andquieter. It has the added benefit of having batteries for complete portability. 1. Carefully unpack your Freeway Lite (keep the box as this may be required when returning it for servicing). 2. A...
Page 10 - OPERATING YOUR FREEWAY LITE; Power Supply Options; Freeway Lite may be operated from three (3) different sources:
1 0 Normal Battery Charging Procedures 1. Turn the ON/OFF switch to the OFF position (position O). 2. If not already installed, attach the battery pack to the Freeway Lite. Connect the power pack or 12 volt DC lead to the DC power inlet on the Freeway Lite andconnect the other end to a suitable powe...
Page 11 - OPERATING FROM THE FREEWAY LITE BATTERY PACK; Operating From a Car or a Boat
1 1 OPERATION 2. Plug the power cord into the wall and the power pack outlet lead into the Freeway Lite DC inlet and the GREEN Charging indicator light will come ON. 3. Switch Freeway Lite ON at the ON/OFF switch and the Freeway Lite will operate. C A U T I O N DO NOT plug the 12 volt lead into the ...
Page 12 - ING Section of this manual.; Traveling With The Freeway Lite; PREPARING FOR TREATMENT
1 2 OPERATION C A U T I O N If the unit does NOT operate, IMMEDIATELY disconnect the powersupply from the DC inlet and check for correct polarity (Refer toSPECIFICATIONS in this manual). NOTE: Battery alligator clips can be purchased from an electronics retail supply com-pany. These connect the ciga...
Page 13 - TAKING THE TREATMENT; AFTER THE TREATMENT
1 3 OPERATION 3. Connect the long hose end of the coiled Duratube to the inlet on the bottom of the Sidestream. 4. Connect either the mouthpiece (supplied) or face mask (optional) to the Sidestream nebulizer. NOTE: Freeway Lite is designed to nebulize 2.5 - 5cc of medication, 3 to 4 times each day. ...
Page 14 - MAINTENANCE; PROLONGING THE LIFE OF YOUR BATTERY; such as radiators or fires.
1 4 MAINTENANCE PROLONGING THE LIFE OF YOUR BATTERY The Freeway Lite’s battery is fully sealed and requires no maintenance. It should lastfor approximately 2000 treatments with normal use, but will last even longer ifyou follow these rules: 1. Fully discharge the battery at least once a month and fu...
Page 15 - CLEANING THE OUTER CASE; CARE OF YOUR FREEWAY LITE; CLEANING THE SIDESTREAM NEBULIZER (FIGURE 1)
1 5 MAINTENANCE CLEANING THE OUTER CASE WA R N I N G UNPLUG unit before cleaning. DO NOT submerge in water to clean.C l e a n o u t e r c a s e w i t h d a m p c l o t h . CARE OF YOUR FREEWAY LITE Your Freeway Lite, battery pack and power pack can be cleaned by wiping with a dampcloth. The storage ...
Page 17 - REPLACING THE INTAKE FILTER; FUSE REPLACEMENT; DESCRIPTION; ACCESSORIES AND SPARE PARTS
1 7 REPLACING THE INTAKE FILTER NOTE: Change the filter as soon as it appears visibly dirty, this will be approximately everythree (3) months. The time between filter changes varies according to the environmentalconditions where the unit is used. For example, it will need to be changed more often in...
Page 18 - SERVICING / TROUBLESHOOTING; TROUBLESHOOTING; PROBLEM; SERVICING
1 8 SERVICING / TROUBLESHOOTING TROUBLESHOOTING PROBLEM POSSIBLE SOLUTIONS Unit does not run from battery. 1. Assure battery is installed properly.2. Remove rubber bumpers.3. Check all leads are removed from DC inlet.4. Charge battery for 16 hours. Unit does not charge and 1. Confirm power pack is p...
Page 19 - LIMITED WARRANTY
1 9 PLEASE NOTE: THE WARRANTY BELOW HAS BEEN DRAFTED TO COMPLY WITH FEDERAL LAWAPPLICABLE TO PRODUCTS MANUFACTURED AFTER JULY 4, 1975. This warranty is extended only to the original purchaser/user of our products. This warranty gives you specific legal rights and you may also have other legal rights...
