Page 2 - WARNING; ACCESSORIES WARNING
Supine Bath Tub 2 Part No 1096926 WARNING DO NOT USE THIS PRODUCT OR ANY AVAILABLE OPTIONAL EQUIPMENT WITHOUT FIRST COMPLETELY READING AND UNDERSTANDING THESE INSTRUCTIONS AND ANY ADDITIONAL INSTRUCTIONAL MATERIAL SUCH AS OWNER’S MANUALS, SERVICE MANUALS OR INSTRUCTION SHEETS SUPPLIED WITH THIS PROD...
Page 3 - TABLE OF CONTENTS
TABLE OF CONTENTS Part No 1096926 3 Supine Bath Tub TABLE OF CONTENTS SPECIAL NOTES ................................................................................ 5LABEL LOCATION ............................................................................ 6TYPICAL PRODUCT PARAMETERS .................
Page 5 - SPECIAL NOTES; NOTICE; THE INFORMATION CONTAINED IN THIS DOCUMENT IS SUBJECT TO
SPECIAL NOTES Part No 1096926 5 Supine Bath Tub SPECIAL NOTES Signal words are used in this manual and apply to hazards or unsafe practices which could result in personal injury or property damage. Refer to the table below for definitions o...
Page 6 - LABEL LOCATION
LABEL LOCATION Supine Bath Tub 6 Part No 1096926 LABEL LOCATION ! WARNING ELECTRICAL SHOCK HAZARD. All disassembly and maintenance of the Supine Tub MUST be done by a qualified technician, certified electrician or plumber. Disconnect electrical supply or turn OFF circuit breaker before performing an...
Page 7 - TYPICAL PRODUCT PARAMETERS
TYPICAL PRODUCT PARAMETERS Part No 1096926 7 Supine Bath Tub TYPICAL PRODUCT PARAMETERS IH6300 FIXED HEIGHT IH6300ADH ADJUSTABLE HEIGHT Height Tub Rim 32 inches (813 mm) Raised N/A 41 inches (1041 mm) Lowered N/A 27 inches (686 mm) Overall Tub Height 56 inches (1422 mm) Raised N/A 65 inches (1651 mm...
Page 8 - FEATURES
FEATURES Supine Bath Tub 8 Part No 1096926 FEATURES CONTROL PANEL TUB INTERIOR Model IH6300ADH Adjustable Height Tub Tub Fill ON/OFF Disinfectant Flow Mete r Disinfectant Wand Disinfectant Cabinet Water Temperature Thermometer Shower ON/OFF Tub Fill Spout Disinfectant On/Off Whirlpool ON/OFF Model I...
Page 9 - SECTION 1—GENERAL GUIDELINES; operation and use of this product.; Installation; Grounding Instructions; Plumbing
SECTION 1—GENERAL GUIDELINES Part No 1096926 9 Supine Bath Tub SECTION 1—GENERAL GUIDELINES WARNING SECTION 1 - GENERAL GUIDELINES contains important information for the safe operation and use of this product. Check all parts for shipping damage before using. In case of damage,...
Page 10 - Maintenance and Inspection; Electrical Shock Hazard; Disinfecting; Keep hair and body away from suction guard when pump is running.
SECTION 1—GENERAL GUIDELINES Supine Bath Tub 10 Part No 1096926 When operating water pressure exceeds 55 p.s.i., pressure regulators (similar to the ¾ ‐ inch Watts U5) MUST be installed. Maintenance and Inspection If any part of the system is NOT fun...
Page 12 - SECTION 2—DISINFECTING THE TUB
SECTION 2—DISINFECTING THE TUB Supine Bath Tub 12 Part No 1096926 SECTION 2—DISINFECTING THE TUB WARNING Disinfect the tub after EACH use to avoid resident infection and contamination of the tub. DO NOT disinfect the tub when it is occupied otherwise injury may occur. Read and understand all informa...
Page 13 - SECTION 3—OPERATION; Overview
SECTION 3—OPERATION Part No 1096926 13 Supine Bath Tub SECTION 3—OPERATION Overview The tub is designed to improve the efficiency and environmental safety of your facility ʹ s operation. However, if the tub is not operated or maintained properly, the...
Page 14 - Operating the Tub
SECTION 3—OPERATION Supine Bath Tub 14 Part No 1096926 Operating the Tub WARNING DO NOT stand in tub. Tub surfaces are slippery when wet. Serious injury may occur.DO NOT stand on tub frame. Frame is slippery when wet.BEFORE immersing the resident or operating the shower/massage wand, check that the ...
Page 15 - Operating Shower/Massage Wand; otherwise damage to the motor/pump will result.
SECTION 3—OPERATION Part No 1096926 15 Supine Bath Tub Operating Shower/Massage Wand NOTE: STEPS 1 ‐ 3 are to be performed while holding the shower/massage wand over the tub. Refer to Features on page 8 for additional illustrations. 1. Turn shower/mass...
Page 16 - Adjusting Tub Height - Model IH6300ADH ONLY; when adjusting tub height.; period. Damage to the actuator may result.; Raising the Supine Tub
SECTION 3—OPERATION Supine Bath Tub 16 Part No 1096926 Adjusting Tub Height - Model IH6300ADH ONLY WARNING DO NOT stand on tub frame. Frame is slippery when wet. Foot injury is possible when adjusting tub height. CAUTION DO NOT adjust height more than three cycles (up and down) within a ten minute p...
Page 17 - SECTION 4—INSTALLATION; Preparing the Work Area
SECTION 4—INSTALLATION Part No 1096926 17 Supine Bath Tub SECTION 4—INSTALLATION Preparing the Work Area NOTE: For this procedure, refer to FIGURE 4.1. 1. Determine location for the supine bath tub installation. NOTE: Follow recommended floor plan when installin...
Page 18 - from leg mounting pad and serious injury may occur.
SECTION 4—INSTALLATION Supine Bath Tub 18 Part No 1096926 Securing the Tub NOTE: For this procedure, refer to FIGURE 4.1 on page 17 and FIGURE 4.2. 1. Set the tub in place. 2. Mark location of anchor holes, using pre ‐ drilled holes in leg mounting p...
Page 19 - source is SHUT OFF to avoid electrical shock.
SECTION 4—INSTALLATION Part No 1096926 19 Supine Bath Tub Electrical Hook-up WARNING Be certain ALL electrical work is performed by a qualified electrician and is in compliance with local electrical codes.Before installing and connecting the tub, make certain that the electric power source is SHUT O...
Page 21 - is shut off to avoid electrical shock.; ard. Use only with hospital grade GFCI
SECTION 4—INSTALLATION Part No 1096926 21 Supine Bath Tub Electrical Installation DANGER The National Electric Code requires the use of a ground fault circuit interrupter on all therapeutic pools and tubs (hydrotherapeutic tanks). Failure to follow this requirement could result in serious or fatal i...
Page 22 - compliance with local codes.
SECTION 4—INSTALLATION Supine Bath Tub 22 Part No 1096926 Plumbing Hook-Up WARNING Be certain ALL plumbing work is performed by a qualified plumber and is in compliance with local codes. NOTE: For this procedure, refer to Refer to FIGURE 4.5. NOTE: For installation details re...
Page 23 - Plumbing Installation
SECTION 4—INSTALLATION Part No 1096926 23 Supine Bath Tub Plumbing Installation WARNING Be certain ALL plumbing work is performed by a qualified plumber.Some state and local plumbing codes require the installation of a “reduced pressure zone” (RPZ) assembly on both the incoming hot and cold supply l...
Page 25 - SECTION 5—MAINTENANCE; maintenance to the tub.; Parts Information; Initially
SECTION 5—MAINTENANCE Part No 1096926 25 Supine Bath Tub SECTION 5—MAINTENANCE WARNING Before performing any maintenance to the tub, make certain that the electric power source is shut off to avoid electrical shock.Be certain ALL electrical work is performed by a qualified electrician and is in comp...
Page 26 - Every Six Months; Removing Soap Film and Hard Water Deposits
SECTION 5—MAINTENANCE Supine Bath Tub 26 Part No 1096926 Every Six Months ❑ Verify the water flow temperature with a separate thermometer. ❑ Visually inspect plumbing for leaks. ❑ Check that all labels are present and legible. Replace if necessary. ❑ IH630...
Page 27 - Heavy Duty Cleaning Procedure
SECTION 5—MAINTENANCE Part No 1096926 27 Supine Bath Tub Heavy Duty Cleaning Procedure WARNING DO NOT use this product or any available optional equipment without first completely reading and understanding these instructions and any additional instructional material such as owner’s manuals, service ...
Page 28 - Calibrating the Disinfectant Flowmeter
SECTION 5—MAINTENANCE Supine Bath Tub 28 Part No 1096926 Calibrating the Disinfectant Flowmeter WARNING DO NOT use this product or any available optional equipment without first completely reading and understanding these instructions and any additional instructional material such as owner’s manuals,...
Page 30 - Maintenance Record
SECTION 5—MAINTENANCE Supine Bath Tub 30 Part No 1096926 Maintenance Record DATE MAINTENANCE PERSON TYPE OF MAINTENANCE PERFORMED NOTES
Page 31 - SECTION 6—TROUBLESHOOTING
SECTION 6—TROUBLESHOOTING Part No 1096926 31 Supine Bath Tub SECTION 6—TROUBLESHOOTING NOTE: If problems are not remedied by the suggested means above, contact an Invacare Dealer. SYSTEM/OPERATION SYMPTOMS FAULTS SOLUTION Adjustable Height Model IH6300ADH Tub will not rai...
Page 32 - LIMITED WARRANTY
LIMITED WARRANTY PLEASE NOTE: THE WARRANTY BELOW HAS BEEN DRAFTED TO COMPLY WITH FEDERAL LAW APPLICABLE TO PRODUCTS MANUFACTURED AFTER JULY 4, 1975.This warranty is extended only to the original purchaser/user of our products.This warranty gives you specific legal rights and you may also have other ...
