Page 2 - WARNING
Invacare Mobile Recliners 2 Part No. 1141494 WARNING DO NOT USE THIS PRODUCT OR ANY AVAILABLE OPTIONAL EQUIPMENT WITHOUT FIRST COMPLETELY READING AND UNDERSTANDING THESE INSTRUCTIONS AND ANY ADDITIONAL INSTRUCTIONAL MATERIAL SUCH AS OWNER’S MANUALS, SERVICE MANUALS OR INSTRUCTION SHEETS SUPPLIED WIT...
Page 3 - TABLE OF CONTENTS
TABLE OF CONTENTS Part No. 1141494 3 Invacare Mobile Recliners TABLE OF CONTENTS REGISTER YOUR PRODUCT ............................................................... 4LABEL LOCATION ............................................................................ 5 Models IH6074A, IH6065 series, and IH6...
Page 5 - LABEL LOCATION
LABEL LOCATION Part No. 1141494 5 Invacare Mobile Recliners LABEL LOCATION Models IH6074A, IH6065 series, and IH6077A DO NOT allow children to play on or operate the recliner. The legrest falls down upon closing so that a child could possibly be injured. When unoccupied ensure the legrest is down. K...
Page 6 - SPECIAL NOTES; NOTICE; THE INFORMATION CONTAINED IN THIS DOCUMENT IS SUBJECT TO
SPECIAL NOTES Invacare Mobile Recliners 6 Part No. 1141494 SPECIAL NOTES Signal words are used in this manual and apply to hazards or unsafe practices which could result in personal injury or property damage. Refer to the following table for ...
Page 7 - TYPICAL PRODUCT PARAMETERS
TYPICAL PRODUCT PARAMETERS Part No. 1141494 7 Invacare Mobile Recliners TYPICAL PRODUCT PARAMETERS PHYSICAL DIMENSIONS MODEL NO. IH6074A MODEL NO. IH6065 SERIES MODEL NO. IH8077A OVERALL HEIGHT: 47 inches 46 inches 49 inches OVERALL WIDTH: 24 inches 27½ inches 30¾ inches OVERALL DEPTH UPRIGHT: 40 in...
Page 8 - SECTION 1—GENERAL GUIDELINES; operation and use of this product.; Service Information
SECTION 1—GENERAL GUIDELINES Invacare Mobile Recliners 8 Part No. 1141494 SECTION 1—GENERAL GUIDELINES WARNING SECTION 1 - GENERAL GUIDELINES contains important information for the safe operation and use of this product. Service Information After the first six months of operation, insp...
Page 9 - Weight Limitation
SECTION 1—GENERAL GUIDELINES Part No. 1141494 9 Invacare Mobile Recliners Operation of recliner with missing or broken footrest or recline mechanism guards may result in bodily injury. Periodic inspection of the footrest guard and recline mechanism ...
Page 10 - SECTION 2—SAFETY INSPECTION; Safety Inspection Checklists; CAUTION; wear and should be replaced as necessary.
SECTION 2—SAFETY INSPECTION Invacare Mobile Recliners 10 Part No. 1141494 SECTION 2—SAFETY INSPECTION NOTE: Every six months or as necessary take your recliner to a qualified dealer for a thorough inspection and servicing. Regular cleaning will reveal ...
Page 11 - Inspect/Adjust Monthly
SECTION 2—SAFETY INSPECTION Part No. 1141494 11 Invacare Mobile Recliners ❑ FOR IH6077A ONLY ‐ Ensure that the trigger release cables completely release and the handles return when released. Inspect/Adjust Monthly ❑ Ensure that the recliner rolls straight ...
Page 12 - SECTION 3—ASSEMBLY; Assembling the Recliner; damage to the recliner.
SECTION 3—ASSEMBLY Invacare Mobile Recliners 12 Part No. 1141494 SECTION 3—ASSEMBLY WARNING After ANY adjustments, repair or service and before use, make sure that all attach- ing hardware is tightened securely - otherwise injury or damage may result. Assembling the Recliner WARNING Tighten mounting...
Page 15 - SECTION 4—OPERATION; Reclining the Chair; User Recline
SECTION 4—OPERATION Part No. 1141494 15 Invacare Mobile Recliners SECTION 4—OPERATION WARNING After ANY adjustments, repair or service and BEFORE use, make sure that all attaching hardware is tightened securely - otherwise injury or damage may result. CAUTION Ensure that there is adequate room to op...
Page 16 - Assisted Recline
SECTION 4—OPERATION Invacare Mobile Recliners 16 Part No. 1141494 Assisted Recline NOTE: For this procedure, refer to FIGURE 4.2. 1. Swing recline lock bar up to chair back and lock into position. 2. Grasp the armrest with one hand and the push bar...
Page 18 - Installing/Storing the Tray
SECTION 4—OPERATION Invacare Mobile Recliners 18 Part No. 1141494 Locking/Unlocking the Rear Wheels NOTE: For this procedure, refer to FIGURE 4.6. 1. Push down on the wheel lock mechanism to engage the wheel locks. 2. Release the wheel locks by pushing ...
Page 19 - The tray has a weight limitation of 40
SECTION 4—OPERATION Part No. 1141494 19 Invacare Mobile Recliners Model IH6065A NOTE: For this procedure, refer to FIGURE 4.8. NOTE: Reverse this procedure to remove the tray. 1. Pull down on the plunger release knobs on both arms and twist them ¼ ...
Page 20 - To Set the Tray to a Locked Position
SECTION 4—OPERATION Invacare Mobile Recliners 20 Part No. 1141494 Adjusting the Tray Position NOTE: For this procedure, refer to FIGURE 4.10. NOTE: This procedure applies to models IH6074A and IH6065A only. NOTE: There are seven tray positions on the Inv...
Page 21 - SECTION 5— MAINTENANCE; Replacing the Back Cushion; Removing
SECTION 5—MAINTENANCE Part No. 1141494 21 Invacare Mobile Recliners SECTION 5— MAINTENANCE WARNING After ANY adjustments, repair or service and BEFORE use, make sure that all attaching hardware is tightened securely - otherwise injury or damage may result. Replacing the Back Cushion Model IH6074A an...
Page 22 - Replacing the Footrest Cushion; recliner will tip and bodily injury may occur.
SECTION 5—MAINTENANCE Invacare Mobile Recliners 22 Part No. 1141494 Model IH6077A NOTE: For this procedure, refer to FIGURE 5.2. Removing 1. Remove the pan head mounting screw that secures the recline cable to the existing back cushion. 2. Remove the fou...
Page 23 - Replacing the Recline Mechanism Guard
SECTION 5—MAINTENANCE Part No. 1141494 23 Invacare Mobile Recliners 1. Recline the recliner to raise the footrest assembly. Refer to Reclining the Chair on page 15. 2. Remove the four hex screws that secure the existing footrest cushion to the re...
Page 24 - Replacing the Elbow Pads - Model IH6077A Only
SECTION 5—MAINTENANCE Invacare Mobile Recliners 24 Part No. 1141494 FIGURE 5.4 Replacing the Recline Mechanism Guard Replacing the Elbow Pads - Model IH6077A Only NOTE: For this procedure, refer to FIGURE 5.5. 1. Remove two hex head screws that secure the existing elbow...
Page 26 - Removing Position Lock Lever
SECTION 5—MAINTENANCE Invacare Mobile Recliners 26 Part No. 1141494 6. Insert new cable assembly into ʺ V ʺ notch of the mounting bracket (Detail ʺ B ʺ ). 7. Squeeze release lever up toward the mounting bracket and insert anchor end of new cable ass...
Page 27 - Replacing Caster Assembly
SECTION 5—MAINTENANCE Part No. 1141494 27 Invacare Mobile Recliners Replacing Casters Replacing Caster Assembly NOTE: For this procedure, refer to Detail “A” of FIGURE 5.9. 1. Place the recliner on its side to gain access to the existing caster assemblies....
Page 28 - Replacing Plunger Release Knob; Removing/Installing the Side Panel; Installing Side Panel
SECTION 5—MAINTENANCE Invacare Mobile Recliners 28 Part No. 1141494 Replacing Plunger Release Knob NOTE: For this procedure, refer to FIGURE 5.10 1. Remove glide from end of frame. 2. Remove retaining ring from end of plunger pin. 3. Slide plunger release kn...
Page 29 - Replacing the Armrest Cushion; Removing Armrest Cushion; Cleaning the Upholstery; fire and flame and use only in a well ventilated area.
SECTION 5—MAINTENANCE Part No. 1141494 29 Invacare Mobile Recliners Replacing the Armrest Cushion NOTE: For this procedure, refer to FIGURE 5.12. Removing Armrest Cushion 1. Remove four screws securing the armrest cushion to the recliner frame. 2. Remove the arm...
Page 30 - NOTES
SECTION 5—MAINTENANCE Invacare Mobile Recliners 30 Part No. 1141494 NOTES
Page 32 - LIMITED WARRANTY
LIMITED WARRANTY PLEASE NOTE: THE WARRANTY BELOW HAS BEEN DRAFTED TO COMPLY WITH FEDERAL LAW APPLICABLE TO PRODUCTS MANUFACTURED AFTER JULY 4, 1975.This warranty is extended only to the original purchaser/user of our products.This warranty gives you specific legal rights and you may also have other ...
