Page 4 - General; Symbols; information below for definitions of the signal words.; DANGER
1 GENERAL Invacare ® TheraPure™Supine Whirlpool Tubs 4 Part No. 1167456 1 General 1.1 Symbols Warnings Signal words are used in this manual and apply to hazards or unsafe practices which could result in personal injury or property damage. See the information below for definitions of the signal words...
Page 5 - Limited Warranty; limited to such repair and/or replacement.
1 GENERAL Part No. 1167456 5 Invacare ® TheraPure™Supine Whirlpool Tubs 1.2 Limited Warranty This warranty is extended only to the original purchaser/user of our products. This warranty gives you specific legal rights and you may also have other legal rights which vary from state to state. Invacare ...
Page 6 - Safety; General Guidelines; WARNING; Grounding is required.; DANGER - RISK OF SCALDING
2 SAFETY Invacare ® TheraPure™Supine Whirlpool Tubs 6 Part No. 1167456 2 Safety The Safety section contains important information for the safe operation and use of this product. 2.1 General Guidelines 2.2 Important Safety Information WARNING DO NOT use this product or any available optional equipm...
Page 7 - WARNING - FLOOR LOAD CAPACITY; Use this unit only for its intended use as described in this manual.
2 SAFETY Part No. 1167456 7 Invacare ® TheraPure™Supine Whirlpool Tubs WARNING - PLUMBING Be certain all plumbing work is performed by a qualified plumber and is in compliance with local codes. WARNING - FLOOR LOAD CAPACITY The installation area MUST be able to support 66 pounds per square inch ...
Page 8 - Overview; Features
3 OVERVIEW Invacare ® TheraPure™Supine Whirlpool Tubs 8 Part No. 1167456 3 Overview 3.1 Features Whirlpool ON/OFF Button Fill Button (Push-in once to auto-fill, push-in and hold to add additional water to tub) Water Temperature Thermometer Water Temperature Control Tub Raise and Lower Buttons (Model...
Page 10 - Product Labeling; Labels located inside the Service Access Door
3 OVERVIEW Invacare ® TheraPure™Supine Whirlpool Tubs 10 Part No. 1167456 3.2 Product Labeling Labels located inside the Service Access Door Label located on Interior Hardware
Page 11 - Typical Product Parameters
3 OVERVIEW Part No. 1167456 11 Invacare ® TheraPure™Supine Whirlpool Tubs 3.3 Typical Product Parameters 6302G 6302GADH FIXED HEIGHT ADJUSTABLE HEIGHT Weight Tub (shipping weight)Tub (empty)Tub w/103 gallons of water (max water capacity)Floor Load Capacity 820 pounds (371 kg)795 pounds (360 kg) 1,69...
Page 12 - FIXED HEIGHT
3 OVERVIEW Invacare ® TheraPure™Supine Whirlpool Tubs 12 Part No. 1167456 Water Pressure 65 PSI maximum (448 kPa) Water Drain Rate 25 gallons per minute (95 liters per minute) Number of Jets 4 Electrical ClassificationPowerCurrent Rating Class I, Type B 115 VAC, 60 Hz 7 Amps Tub Material: Double-wal...
Page 13 - Minimum Floor Space and Clearance Requirements
3 OVERVIEW Part No. 1167456 13 Invacare ® TheraPure™Supine Whirlpool Tubs 3.4 Minimum Floor Space and Clearance Requirements
Page 14 - Installation; Preparing the Work Area; WARNINGS
4 INSTALLATION Invacare ® TheraPure™Supine Whirlpool Tubs 14 Part No. 1167456 4 Installation 4.1 Preparing the Work Area 1. Carefully remove the tub from the carton and inspect for shipping damage. If damage is found, contact the carrier. 2. Remove the tub from the shipping pallet by removing the sc...
Page 15 - Tub Dimensions and Connection Details; Connection
4 INSTALLATION Part No. 1167456 15 Invacare ® TheraPure™Supine Whirlpool Tubs 4.2 Tub Dimensions and Connection Details 94” 38” 30” 25” D E H C 5.5” Connection Location Type C 10” (254 mm) from centerline, 5.5” (140 mm) up from floor 3/4” Cold water stub (with recommended shut off valve) D 5” (127 m...
Page 16 - Securing the Tub; SECURING LEGS TO FLOOR
4 INSTALLATION Invacare ® TheraPure™Supine Whirlpool Tubs 16 Part No. 1167456 4.3 Securing the Tub 1. Set the tub in place. 2. Ensure the plumbing and electrical hook-ups have been installed. 3. Mark the locations of the anchor holes, using pre-drilled holes in leg mounting pads as a template. 4. Mo...
Page 17 - Electrical Installation; DANGERS - ELECTRICAL SHOCK HAZARD; Use a 15 AMP GFCI breaker only.
4 INSTALLATION Part No. 1167456 17 Invacare ® TheraPure™Supine Whirlpool Tubs 4.5 Electrical Installation Ensure a 15 AMP GFCI breaker is installed to protect the unit. Insert the plug into a pre-installed GFCI protected hospital grade receptacle. DANGERS - ELECTRICAL SHOCK HAZARD Grounding is req...
Page 18 - FIGURE; Plumbing Connection Details; Plumbing Installation
4 INSTALLATION Invacare ® TheraPure™Supine Whirlpool Tubs 18 Part No. 1167456 4.6 Plumbing Connection Details FIGURE 4.1 Plumbing Connection Details 4.7 Plumbing Installation DANGER Be certain all plumbing work is performed by a qualified plumber and is in compliance with local codes. Check loca...
Page 19 - Connect 2-inch drains in accordance with local plumbing codes.; CAUTIONS; HOT; Optional
4 INSTALLATION Part No. 1167456 19 Invacare ® TheraPure™Supine Whirlpool Tubs 1. Refer to Tub Dimensions and Connection Details on page 15 for the location of the hot water stub and cold water stub. 2. Measure the location of the drain on the unit. Install the drain in the floor. 3. Purge water line...
Page 20 - Post Installation Checklist; Before putting the tub into service, check the following:
4 INSTALLATION Invacare ® TheraPure™Supine Whirlpool Tubs 20 Part No. 1167456 4.8 Post Installation Checklist Before putting the tub into service, check the following: ❑ Water lines have been purged of any foreign matter. ❑ Both hot and cold water lines are properly connected to the tub. ❑ All water...
Page 21 - Operation; Overview
5 OPERATION Part No. 1167456 21 Invacare ® TheraPure™Supine Whirlpool Tubs 5 Operation 5.1 Overview WARNINGS Read and understand ALL information in this manual BEFORE use.Clean and disinfect the tub after EACH use to avoid resident infection and contamination of the tub.DO NOT clean or disinfect t...
Page 23 - Use the stretcher lift to transfer the resident to the tub.; Cleaning and Disinfecting; Use the drain plug to close the drain.
5 OPERATION Part No. 1167456 23 Invacare ® TheraPure™Supine Whirlpool Tubs Perform these procedures in the following order:1. Make sure that the tub has been cleaned, disinfected and rinsed BEFORE each use. Refer to Cleaning and Disinfecting on page 23. 2. Use the stretcher lift to transfer the resi...
Page 24 - Remove each impeller cap by rotating it clockwise (Detail “B”).; Detail “A”; Jet Casing
5 OPERATION Invacare ® TheraPure™Supine Whirlpool Tubs 24 Part No. 1167456 2. Remove and disassemble all jet assemblies. A. Rotate each jet assembly counterclockwise and pull away from the jet casing. (Detail “A”).B. Remove each impeller cap by rotating it clockwise (Detail “B”). C. Remove each impe...
Page 25 - Replace the impeller and impeller cap on each jet assembly by; Removing Soap Film and Hard Water Deposits; according to the manufacturer's instructions.; CAUTION
5 OPERATION Part No. 1167456 25 Invacare ® TheraPure™Supine Whirlpool Tubs 8. Replace the impeller and impeller cap on each jet assembly by rotating them counterclockwise. 9. Assemble each jet assembly to the jet casings.A. Position the Sanijet® logo and red indicator at the 11 o’clock position. B. ...
Page 26 - Water Temperature Setting
5 OPERATION Invacare ® TheraPure™Supine Whirlpool Tubs 26 Part No. 1167456 5.3 Water Temperature Setting WARNING The causes, symptoms and effects of hyperthermia may be described as follows: Hyperthermia occurs when the internal temperature of the body reaches a level several degrees above the nor...
Page 27 - Filling the Tub
5 OPERATION Part No. 1167456 27 Invacare ® TheraPure™Supine Whirlpool Tubs 5.4 Filling the Tub 1. Use the drain plug to close the drain. 2. Position the resident (on the stretcher lift) in the tub. 3. Push the tub fill button once to start auto-fill. 4. Use the water temperature control valve to adj...
Page 28 - Using the Whirlpool Function; bottle for directions.; Adjusting the Tub Height - 6302GADH Only; The tub stops automatically when the maximum; UP Button
5 OPERATION Invacare ® TheraPure™Supine Whirlpool Tubs 28 Part No. 1167456 5.6 Using the Whirlpool Function 1. If the water level does not cover the whirlpool jets, push the tub fill button to auto-fill the tub. 2. After the water level covers the whirlpool jets and after bathing the resident, add I...
Page 29 - Inspection, Maintenance and Troubleshooting; Safety Inspection Checklists
6 INSPECTION, MAINTENANCE AND TROUBLESHOOTING Part No. 1167456 29 Invacare ® TheraPure™Supine Whirlpool Tubs 6 Inspection, Maintenance and Troubleshooting If any part of the system is not functioning properly, DO NOT use the system. For parts and technical service information please contact ICC Tech...
Page 30 - Troubleshooting; SYMPTOMS; Hydromassage System
6 INSPECTION, MAINTENANCE AND TROUBLESHOOTING Invacare ® TheraPure™Supine Whirlpool Tubs 30 Part No. 1167456 6.2 Maintenance for 6302GADH Adjustable Height Rub Panels and Glide Pads 1. Remove the side panel to access the rub panels and glide pads. 2. Generously apply white lithium grease to the stai...
Page 31 - Maintenance Record; DATE
6 INSPECTION, MAINTENANCE AND TROUBLESHOOTING Part No. 1167456 31 Invacare ® TheraPure™Supine Whirlpool Tubs Maintenance Record Height Adjustment (Model 6302GADH Only) Tub will not raise or lower Glide pads and rub panels not greased Apply grease to glide pads and rub panels. Refer to Maintenance fo...
Page 32 - USA and Canada
Invacare Corporation www.invacare-cc.com USA and Canada One Invacare Way Elyria, Ohio USA 44036-2125 Customer Service 1-800-668-2337 Technical Support 1-800-668-2337, Extension 2 Manufacturing Location 899 Cleveland Street Elyria, Ohio 44036 © 2011 Invacare Corporation. All rights reserved. Republic...
