Ingersoll Rand 65662 - Manual
Ingersoll Rand 65662 – Manual, read for free online in PDF format. We hope this helps you resolve any issues you may have. If you have further questions, please contact us through the contact form.
Table of Contents:
- Page 2 – AIR MOTOR PARTS LIST; DISASSEMBLY OF AIR MOTOR
- Page 3 – AIR MOTOR HEAD
- Page 5 – AIR MOTOR PISTON ROD AND BASE
- Page 6 – REASSEMBLY OF AIR MOTOR
- Page 7 – TROUBLE SHOOTING
- Page 8 – ITEM 52 PISTON ROD END VARIETY
2001
PRINTED IN U.S.A.
(419) 636-4242
FAX (419) 633-1674
INGERSOLL-RAND COMPANY
P.O. BOX 151
ONE ARO CENTER
BRYAN, OHIO 43506Ć0151
OPERATOR’S MANUAL
INCLUDING: OPERATION, INSTALLATION & MAINTENANCE
6564X-X
6566X-X
66620
RELEASED:
8-28-91
REVISED:
10-11-01
(REV. K)
6” AIR MOTORS
READ THIS MANUAL CAREFULLY BEFORE INSTALLING,
OPERATING OR SERVICING THIS EQUIPMENT.
6564X-X and 66620
4” STROKE
6566X-X
6” STROKE
THIS MANUAL COVERS THE FOLLOWING MODELS
MODEL
65643
65662
65665Ć2B
66620
65645
65665ĆB
65666
SERVICE KITS
61355 for general repair of all 6" air motors.
GENERAL DESCRIPTION
The 6" air motor is a general purpose power unit and is used with many
2Ćball, 4Ćball and chop check pumps. It utilizes tie rod type construction
for easy breakdown and it connects to the various lower ends via tie rods
for easy operation. Consult pump model operator's manual for specific
instructions. It is recommended that a muffler be connected to the exĆ
haust port to reduce noise to acceptable OSHA standards.
Filtered and oiled air will allow the air motor to operate more efficiently
and yield a longer life to operating parts and mechanisms. A filter capaĆ
ble of filtering particles larger than 50 microns should be used with an
oiler. Keep the oiler supplied with a good grade of S.A.E. no. 90W nonĆ
detergent gear oil, set at a rate not to exceed 1 or 2 drops per minute.
NOTICE
DO NOT OPERATE AIR MOTOR ABOVE RECOMMENDED
AIR PRESSURE OF 150 P.S.I. (10.3 BAR) OR 75 CYCLES PER
MINUTE.
Air motor may be rated differently in the next assembly.
Check model plate.
"Loading the manual" means you need to wait until the file loads and becomes available for online reading. Some manuals are very large, and the time they take to appear depends on your internet speed.
Summary
PAGE 2 OF 8 6564XĆX AIR MOTOR PARTS LIST PARTS SO MARKED ARE INCLUDED IN 61355 SERVICE KIT. REF. DESCRIPTION (SIZE IN INCHES) QTY PART NO. REF. DESCRIPTION (SIZE IN INCHES) QTY PART NO. 1 Machine Screw (#8 Ć 32 x 7/8") 4 Y136Ć90ĆS 2 Deflector 1 90409 Deflector (model 65665Ć2B) 1 90409Ć1 3 Screw ...
31 8 9 10 11 12 13 14 15 16 17 18 19 23 21 22 24 32 33 34 35 36 38 42 43 44 40 3 1 2 6 7 FIGURE 2 NOTE: LUBRICATE WITH PARKER‘‘O” RING LUBE (ARO P/N 36460). FIGURE 3 5 4 25 37 39 45 20 41 31 42 PAGE 3 OF 8 6564XĆX AIR MOTOR HEAD PART NUMBERS LISTED BELOW AND ON PARTS LIST (OPPOSITE PAGE) ARE TYPICAL...
FIGURE 4 NOTE: LUBRICATE WITH PARKER‘‘O” RING LUBE (ARO P/N 36460). 46 26 27 28 17 30 29 47 20 50 51 52 48 49 PAGE 5 OF 8 6564XĆX AIR MOTOR PISTON ROD AND BASE SEE CHART ON OPPOSITE PAGE FOR EACH MODEL. DISASSEMBLY OF AIR MOTOR (CONTINUED) 16. Remove the (37) upper gland. 17. Remove the (38) seal an...
