Ice-O-Matic CD20030 CD20530 - Manual

Page 3 - Introduction; Table of Contents; Kits

CD10022 CD20030 CD10522 CD20530 Introduction To the owner or user. This product is a source of information about the installation, start up,cleaning, maintenance and repair of the product. The CD10022, CD10522, CD20030 and CD20530 are Ice-O-Matics brandhotel/motel ice dispenser. The CD10022 is desig...

Page 4 - Specifications; minimum; Must; only; Must

CD10022 CD20030 CD10522 CD20530 Specifications Limitations:• Must meet the same limitations as the cuber installed on top of it: • 50 o F air minimum • 100 o F air maximum • Must be installed indoors • Must allow space to the right for air intake when using air cooled machine.• The CD10022 and CD105...

Page 5 - Installation: General; rigid

CD10022 CD20030 CD10522 CD20530 Installation: General After the carton has been removed from thedispenser, the legs may be installed. Place flat portions of the carton on the floorbehind the dispenser and lay the dispenserdown on its back. Thread the legs into the base of the dispenser.Be sure that ...

Page 6 - Installation: Ice Machine; Carefully

CD10022 CD20030 CD10522 CD20530 Installation: Ice Machine Check that gasket tape has been placed at theoutside edge of the dispenser top. Place corner posts from the carton on top of thedispenser, at the left and right corners. Place the ice machine onto the dispenser. Theice machine is heavy, use o...

Page 9 - Key Kit Installation

CD10022 CD20030 CD10522 CD20530 Key Kit Installation This kit has been designed for use with theCD10022, CD10522, CD20030 and CD20530 ice dis-penser. When this kit is installed, ice cannot be dis-pensed unless a specific type of key is inserted intothe lock cylinder. The kit contains a universal mou...

Page 11 - Key Card Kit Installation

CD10022 CD20030 CD10522 CD20530 Key Card Kit Installation This kit has been designed for use with theCD10022, CD10522, CD20030 and CD20530ice dispenser. When this kit is installed, ice cannot be dispensed unless a key card is inserted into the key card slot.The kit contains a universal mounting and ...

Page 13 - Final Check List/Initial Start Up

CD10022 CD20030 CD10522 CD20530 Final Check List/Initial Start Up 11 1. Check that electrical power has been supplied. 2. Check that a drain, separate from the icemachine, insulated and made of rigid tubing, has been connected to the dispenser. 3. Check that the ice machine has been properlyinstalle...

Page 14 - Operational Schematic

CD10022 CD20030 CD10522 CD20530 Operational Schematic 12

Page 15 - Cleaning; General Care and Ceaning:

CD10022 CD20030 CD10522 CD20530 Cleaning General Care and Ceaning: Periodically inspect and clean the ice dispenserto keep it operating at peak performance. Wash the outside of the dispenser with warmwater and soap. Rinse off and dry. Cleaning and Sanitizing of the IceStorage Bin: The minerals, chlo...

Page 17 - Service Diagnosis; PROBLEM; POSSIBLE CAUSE; PROBABLE FIX

CD10022 CD20030 CD10522 CD20530 Service Diagnosis Leaks water Bin drain leaks Check bin drain connections and fittingsCheck for clogged bin drain tubing Coin Mechanism Does not vend, no ice Check the above, plus coin switch 15 PROBLEM Does not vend POSSIBLE CAUSE No ice PROBABLE FIX Check ice machin...

Page 18 - Removal and Replacement

CD10022 CD20030 CD10522 CD20530 Removal and Replacement Gear Motor: 1. Disconnect electrical power. 2. Locate key and remove front panel. 3. Remove dispenser wheel. 4. Disconnect wires at gearmotor. 5. Remove 4 bolts securing gearmotor bracket tocabinet. 6. Pull gearmotor out of cabinet. 7. Remove g...

Page 19 - Standard With Room Key Kit or Card Kit Electrical Schematic

CD10022 CD20030 CD10522 CD20530 Standard With Room Key Kit or Card Kit Electrical Schematic 17

Page 21 - With Coin Mechanism Electrical Schematic

CD10022 CD20030 CD10522 CD20530 With Coin Mechanism Electrical Schematic 19

Page 22 - SERVICE HISTORY

SERVICE HISTORY MODEL NUMBER: ______________ SERIAL NUMBER: _____________ __________________________________________________________________________________________________________________________________________________________________________________________________________________________________...

Ice-O-Matic CD20030 CD20530 - Manual

Table of Contents:

Summary

Other Ice-O-Matic Models