Page 2 - Safe Operation Practices for Walk-Behind Mowers; SAFETY RULES; IV. SAFE HANDLING OF GASOLINE
2 WARNING: Battery posts, terminals and related ac cessories contain lead and lead compounds, chemicals known to the State of Cal ifornia to cause can cer and birth defects or oth er re productive harm. Wash hands after handling. WARNING: Engine exhaust, some of its constituents, and certain vehicle...
Page 3 - CUSTOMER RESPONSIBILITIES; TABLE OF CONTENTS; PRODUCT SPECIFICATIONS
3 SAFETY RULES ......................................................... 2-3PRODUCT SPECIFICATIONS ....................................... 3CUSTOMER RESPONSIBILITIES................................. 3ASSEMBLY ................................................................. 4-5OPERATION ...............
Page 4 - ASSEMBLY; TO RE MOVE MOW ER FROM CAR TON; HOW TO SET UP YOUR MOW ER
4 ASSEMBLY FIG. 2 HANDLE BRACKET HANDLE PIN SQUEEZE FIG. 1 OPERATOR PRESENCECONTROL BAR HANDLE KNOB LIFTUP LIFT UP LOWER HANDLE MOWING POSITION UPPER HANDLE Read these instructions and this man ual in its entirety before you attempt to assemble or operate your new lawn mower. IMPORTANT : THIS LAWN M...
Page 5 - TO INSTALL ATTACHMENTS
5 TO ASSEMBLE GRASS CATCHER(See Fig. 3) 1. Put grass catcher frame into grass bag with rigid part of bag on the bottom. Make sure the frame handle is outside of the bag top. 2. Slip vinyl bindings over frame. NOTE : If vinyl bindings are too stiff, hold them in warm water for a few minutes. If bag g...
Page 6 - KNOW YOUR LAWN MOWER; MEETS CPSC SAFETY REQUIREMENTS; OPERATION
6 KNOW YOUR LAWN MOWER READ THIS OWNER'S MANUAL AND SAFETY RULES BEFORE OPERATING YOUR LAWN MOWER. Compare the illustrations with your lawn mower to familiarize yourself with the location of various controls and adjustments. Save this manual for future reference. MEETS CPSC SAFETY REQUIREMENTS Our r...
Page 7 - HOW TO USE YOUR LAWN MOWER; ENGINE SPEED
7 DRIVE CONTROL ADJUSTMENT (See Fig. 5B) Over time, the drive control system may become “loose”, resulting in decreased speed. There is a turnbuckle on the underside of the drive control housing to increase tension on the drive cable. Pro ceed as follows: 1. Turn unit off and disconnect spark plug w...
Page 8 - TO CONVERT MOWER
8 SIDE DIS CHARGING (See Fig. 10) • Mulcher plug must be installed into rear discharge opening of mower. • Open mulcher door and install discharge defl ector under door as shown. • Mower is now ready for discharging operation. • To convert to mulching or bagging operation, dis charge defl ector must b...
Page 9 - BEFORE STARTING ENGINE
9 OPERATION BEFORE STARTING ENGINE ADD OIL (See Fig. 11) Your lawnmower is shipped without oil in the engine. For type and grade of oil to use, see “EN GINE” in the Mainte-nance section of this manual. CAUTION: DO NOT overfi ll engine with oil, or it will smoke on startup. 1. Be sure lawnmower is lev...
Page 10 - MOWING TIPS; MULCHING MOWING TIPS
10 ADD GASOLINE (See Fig. 11) • Fill fuel tank to bottom of tank fi ller neck. Do not over- fi ll. Use fresh, clean, regular unleaded gasoline with a minimum of 87 octane. Do not mix oil with gasoline. Purchase fuel in quan tities that can be used within 30 days to assure fuel freshness. CAUTION: Wipe...
Page 11 - BEFORE EACH USE; MAINTENANCE
11 ➁ ENGINE OIL ➀ HANDLE BRACK ET MOUNT ING PINS ➀ REAR DOOR HINGE ➀ MULCHER DOOR HINGE PIN LUBRICATION CHART GENERAL RECOMMENDATIONS The warranty on this lawn mower does not cover items that have been subjected to operator abuse or negligence. To receive full value from the warranty, operator must ...
Page 12 - LAWN MOWER; TIRES; GRASS CATCHER
12 LAWN MOWER Always observe safety rules when performing any main-tenance. TIRES • Keep tires free of gasoline, oil, or insect control chem- icals which can harm rubber. • Avoid stumps, stones, deep ruts, sharp objects and other hazards that may cause tire damage. DRIVE WHEELS Check rear drive whee...
Page 13 - ENGINE; LUBRICATION; MUFFLER; CLEANING; CLEAN UNDER DRIVE COVER
13 MAINTENANCE TO CLEAN AIR FILTER1. Loosen screws and re move cover. 2. Carefully remove cartridge. 3. Clean by gently tapping on a fl at surface. If very dirty, replace car tridge. CAUTION: Pe troleum solvents, such as kerosene, are not to be used to clean cartridge. They may cause de terioration o...
Page 14 - TO ADJUST CUTTING HEIGHT; SERVICE AND ADJUSTMENTS
14 LAWN MOWER TO ADJUST CUTTING HEIGHT See “TO ADJUST CUTTING HEIGHT” in the Operation section of this manual. REAR DEFLECTOR The rear defl ector, attached between the rear wheels of your mower, is provided to minimize the possibility that objects will be thrown out of the rear of the mower into the ...
Page 15 - STORAGE
15 FIG. 18 HIGH MED. LOW HANDLEBRACKET HANDLE PIN SQUEEZE TO ADJUST HANDLE (See Fig. 18) The handle on your lawn mower has three (3) height posi-tions - adjust to height that suits you. • Squeeze the bottom ends of lower handle towards each other until the pin in handle can be inserted into one of t...
Page 16 - FUEL SYSTEM; ENGINE OIL; OTHER
16 STORAGE HANDLE PIN SQUEEZE HANDLEBRACKET FIG. 20 ENGINE FUEL SYSTEM IMPORTANT : IT IS IMPORTANT TO PREVENT GUM DEPOSITS FROM FORMING IN ESSENTIAL FUEL SYSTEM PARTS SUCH AS CARBURETOR, FUEL FILTER, FUEL HOSE, OR TANK DURING STORAGE. ALCOHOL BLENDED FUELS (CALLED GASOHOL OR USING ETHANOL OR METHANO...
Page 17 - TROUBLESHOOTING POINTS
17 TROUBLESHOOTING POINTS Does not start 1. Dirty air fi lter. 1. Clean/replace air fi lter. 2. Out of fuel. 2. Fill fuel tank. 3. Stale fuel. 3. Empty fuel tank and refi ll tank with fresh, clean gasoline. 4. Water in fuel. 4. Empty fuel tank and refi ll tank with fresh, clean gasoline. 5. Spark plug w...
Page 22 - WARRANTY STATEMENT
22 SECTION 1: LIMITED WARRANTY Husqvarna Forest & Garden Company (“Husqvarna”) warrants Husqvarna product to the original pur-chaser to be free from defects in material and workmanship from the date of purchase for the “WarrantyPeriod” of the product as set forth below: Lifetime Warranty: All ti...
