Heatiator NDI35 - Manual

Heatiator NDI35

Heatiator NDI35 – Manual, read for free online in PDF format. We hope this helps you resolve any issues you may have. If you have further questions, please contact us through the contact form.

1 Page 1
2 Page 2
3 Page 3
4 Page 4
5 Page 5
6 Page 6
7 Page 7
8 Page 8
9 Page 9
10 Page 10
11 Page 11
12 Page 12
13 Page 13
14 Page 14
15 Page 15
16 Page 16
17 Page 17
18 Page 18
19 Page 19
20 Page 20
21 Page 21
22 Page 22
23 Page 23
24 Page 24
25 Page 25
26 Page 26
27 Page 27
28 Page 28
29 Page 29
30 Page 30
31 Page 31
32 Page 32
33 Page 33
34 Page 34
35 Page 35
36 Page 36
37 Page 37
38 Page 38
39 Page 39
40 Page 40
41 Page 41
42 Page 42
Page: / 42

Table of Contents:

  • Page 2 – Listing Label Information/Location; The Heatilator gas; We recommend that you record the following pertinent; Homeowner Reference Information; NATURAL GAS; XXXXXXXX; Read this manual before installing or operating this appliance.
  • Page 3 – Safety Alert Key:; Used to address practices not related to personal injury.; Table of Contents; User Guide
  • Page 4 – B. Limited Lifetime Warranty; LIMITED LIFETIME WARRANTY; glass
  • Page 5 – This warranty is void if:
  • Page 6 – Models; NOT INTENDED FOR USE AS A PRIMARY HEAT SOURCE.; This appliance is tested and approved as either supplemen-; ori; Listing and Code Approvals; Standard Test Method for Behavior of Materials in a; shall be; National Electric Code ANSI/NFPA
  • Page 7 – Operating Instructions; WARNING! DO NOT operate fi; A. Gas Fireplace Safety; WARNING; This appliance has been supplied with an integral barrier; HOT SURFACES; ammable
  • Page 8 – E. Fixed Glass Assembly; barrier to prevent direct contact with the; F. Remote Controls, Wall Controls and Wall; G. Before Lighting Fireplace; have a; RED OR BLACK IGNITOR BUTTON
  • Page 9 – life, remove them when using the transformer.; LIGHTING; NOT FOR USE; GAS; on the; WHAT TO DO IF YOU SMELL GAS; DO NOT CONNECT LINE VOLT-; Hot; Also Certifi ed for Installation in a; Final inspection by
  • Page 10 – DO NOT CONNECT 110 VAC TO
  • Page 11 – J. After Appliance is Lit; ISSUE; ames
  • Page 12 – Glass Cleaning; Tools Needed; CAUTION! Handle fi xed glass assembly with care.; Note; Maintenance and Service; The appliance should be; Tools needed; Remote Control; Any safety screen or guard removed for servicing must be
  • Page 13 – Venting; ashing remains; Gasket Seal and Glass Assembly Inspection
  • Page 14 – Burner Ignition and Operation; DO NOT; ame sense
  • Page 15 – A. Typical Appliance System; Illustrations and photos re; Getting Started; Installer Guide
  • Page 16 – Read all of the instructions before starting the instal-; C. Tools and Supplies Needed; Hearth & Home Technologies disclaims any responsibility for,; Any such action may cause a fi re hazard.; DO NOT use this appliance if any part has been under; Improper installation, adjustment, alteration, service or
  • Page 17 – Fireplace Size Requirements; A. Minimum Fireplace Opening; Provide adequate
  • Page 18 – B. Mantel and Wall Projections; • Use leveling legs to raise insert minimum 1/4 inch (6 mm); Alternate Unit Width; TOP VIEW
  • Page 19 – A. Vent Termination Minimum Clearances; Termination Locations; pack air space with insulation or
  • Page 20 – Installation Preparation; A. Inspection and Cleaning
  • Page 21 – B. Venting Components; Installing Vent Pipe and Appliance; C. Connecting Vent Pipe; • May impair safe operation of this appliance or other; Description; Minimum Vertical Run Length 10 ft.; CAUTION! ALL vent specifi cations MUST be followed.
  • Page 22 – ance; the
  • Page 23 – F. Installing Adaptor and Termination Cap; For installation of termination cap see minimum vent; Masonry; Wear protective gloves and safety glasses during instal-; Damper Flashing Kit; : Damper may have to be removed to use this kit.; system REQUIRES this insulation.; OR
  • Page 24 – Gas Information; • If substituting for these components, please consult; D. High Altitude Installations; Gas Pressure
  • Page 25 – B. Standing Pilot Ignition System Wiring; DOES NOT; built; A. Wiring Requirements; National Electric Code; Electrical Information; C. IntelliFire Ignition System Wiring; WARNING! Risk of Shock or Explosion! DO NOT
  • Page 27 – D. Optional Accessories Requirements; Label all wires prior to dis-
  • Page 29 – Finishing; A. Mantel and Wall Projections
  • Page 30 – WARNING! Risk of Fire and Electric Shock!; E. Place the Lava Rock; Appliance Setup; DO NOT place lava rock on
  • Page 31 – G. Install the Log Assembly; #2 forward until it comes into contact with the grate tine.; TINES
  • Page 32 – log set properly installed.; POSITIONED ON; end of Log #3 forward until it comes into contact with the grate tine.
  • Page 33 – Position Log #1 as shown in Figure 3. Note additional
  • Page 35 – I. Air Shutter Setting; H. Fixed Glass Assembly; DO NOT operate; Removing Fixed Glass Assembly; Air Shutter Settings; NG
  • Page 36 – A. Standing Pilot Ignition System; Troubleshooting; arrange a service call by a qualifi ed technician.; Symptom; there is no burner
  • Page 38 – B. IntelliFire Ignition System; there is no noise or
  • Page 39 – ame
  • Page 40 – Reference Materials; A. Appliance Dimension Diagram
  • Page 41 – B. Vent Kits Components; feet and 4 feet respectively. Includes: two liners, termination; GK to connect collinear fl ex vent to SL-D vent pipe to
  • Page 42 – D. Contact Information; For the location of your nearest Heatilator dealer,; DO NOT DISCARD THIS MANUAL; NOTICE
Loading the manual

1

Heatilator • NDI30, NDI30-SP, NDI35, NDI35-SP, NDI30-SPFK, NDI35-SPFK • 2226-900 Rev. G • 4/11

Models:
NDI30

NDI30-SP

NDI35

NDI35-SP

NDI30-SPFK

NDI35-SPFK

•

DO NOT

store or use gasoline or other

fl am-

mable vapors and liquids in the vicinity of this

or any other appliance.

• What to do if you smell gas

-

DO NOT

try to light any appliance.

-

DO NOT

touch any electrical switch.

DO

NOT

use any phone in your building.

- Immediately call your gas supplier from a

neighbor’s phone. Follow the gas suppli-

er’s instructions.

- If you cannot reach your gas supplier, call

the

fi re department.

• Installation and service must be performed

by a qualifi ed installer, service agency, or the

gas supplier.

WARNING: If the information in these

instructions is not followed exactly, a fi re

or explosion may result causing property

damage, personal injury, or death.

Owner’s Manual

Installation and Operation

DO NOT DISCARD THIS MANUAL

NOTICE

This appliance may be installed as an OEM installation in

manufactured home (USA only) or mobile home and must be

installed in accordance with the manufacturer’s instructions

and the manufactured home construction and safety standard,

Title 24 CFR, Part 3280

or

Standard for Installation in Mobile

Homes, CAN/CSA Z240MH, in Canada.
This appliance is only for use with the type(s) of gas indicated

on the rating plate.

Installation and service of this appliance should be

performed by qualifi ed personnel. Hearth & Home

Technologies suggests NFI certifi ed or factory trained

professionals, or technicians supervised by an NFI

certifi ed professional.

• Leave this manual with

party responsible for use

and operation.

DO NOT

DISCARD

WARNING

• Important operating

a n d m a i n t e n a n c e

instructions included.

• Read, understand and follow

these instructions for safe

installation and operation.

In the Commonwealth of Massachusetts installation must be

performed by a licensed plumber or gas fi tter.
A CO detector shall be installed in the room where the appliance

in installed.

This appliance has been supplied with an integral barrier

to prevent direct contact with the

fi

xed glass panel. DO

NOT operate the appliance with the barrier removed.

Contact your dealer or Hearth & Home Technologies if the

barrier is not present or help is needed to properly install one.

HOT SURFACES

!

Glass and other surfaces are hot during

operation AND cool down.

Hot glass will cause burns.

•

DO NOT

touch glass until it is cooled

• NEVER allow children to touch glass

• Keep children away

• CAREFULLY SUPERVISE children in same room as

fi replace.

• Alert children and adults to hazards of high temperatures.

High temperatures may ignite clothing or other fl ammable

materials.

• Keep clothing, furniture, draperies and other fl

ammable

materials away.

"Loading the manual" means you need to wait until the file loads and becomes available for online reading. Some manuals are very large, and the time they take to appear depends on your internet speed.

Summary

Page 2 - Listing Label Information/Location; The Heatilator gas; We recommend that you record the following pertinent; Homeowner Reference Information; NATURAL GAS; XXXXXXXX; Read this manual before installing or operating this appliance.

Heatilator • NDI30, NDI30-SP, NDI35, NDI35-SP, NDI30-SPFK, NDI35-SPFK • 2226-900 Rev. G • 4/11 2 Listing Label Information/Location Model Name: ___________________________________________ Date purchased/installed: __________________ Serial Number: __________________________________________ Location ...

Page 3 - Safety Alert Key:; Used to address practices not related to personal injury.; Table of Contents; User Guide

3 Heatilator • NDI30, NDI30-SP, NDI35, NDI35-SP, NDI30-SPFK, NDI35-SPFK • 2226-900 Rev. G • 4/11 Safety Alert Key: • DANGER! Indicates a hazardous situation which, if not avoided will result in death or serious injury. • WARNING! Indicates a hazardous situation which, if not avoided could result in ...

Page 4 - B. Limited Lifetime Warranty; LIMITED LIFETIME WARRANTY; glass

Heatilator • NDI30, NDI30-SP, NDI35, NDI35-SP, NDI30-SPFK, NDI35-SPFK • 2226-900 Rev. G • 4/11 4 B. Limited Lifetime Warranty 4021-645C 12-29-10 Page 1 of 2 Hearth & Home Technologies Inc. LIMITED LIFETIME WARRANTY Hearth & Home Technologies Inc., on behalf of its hearth brands (”HHT”), exte...

Other Heatiator Models

All Heatiator Other