Goodman ATUF - Manual - manualsarea.com

Page 2 - Important Safety Instructions; CONTENTS; COOLING UNIT WITH OPTIONAL HEAT KITS

2 Important Safety Instructions The following symbols and labels are used throughout thismanual to indicate immediate or potential safety hazards. Itis the owner’s and installer’s responsibility to read and com-ply with all safety information and instructions accompanyingthese symbols. Failure to he...

Page 3 - CA RBON MONOXIDE POISONING HAZAR D; Shipping Inspection

3 To prevent the risk of property damage, personal injury, or death, do not store combustible materials or use gasoline or other flammable liquids or vapors in the vicinity of this unit. CA RBON MONOXIDE POISONING HAZAR D - Special Warning for Installation of Furnace or A ir H andling Units inEnclos...

Page 4 - indoor installation; Ductwork; Return Ductwork; Table 1; Electric Heat; ONLY; Table 2; CFM; Table 3

4 Pre-Installation Instructions Carefully read all instructions for the installation prior to in-stalling product. Make sure each step or procedure is under-stood and any special considerations are taken into accountbefore starting installation. Assemble all tools, hardwareand supplies needed to com...

Page 5 - Table 4; HKR Installation; electrical ground. The; must; Nominal Input; Table 5; Wire Sizing; Maximum Allowable Length in Feet; Table 6

5 3 5 6 8 10 15 20 21 600 16 25 32 37 800 12 19 24 38 38 1000 10 15 19 22 30 46 1200 8 13 16 19 25 38 51 56 1400 7 11 14 16 22 33 43 48 1600 6 9 12 14 19 28 38 42 1800 5 8 11 12 17 25 34 37 2000 5 8 10 11 15 23 30 34 CFM HEAT KIT NOMINAL kW Table 4 208/1/60 Supply Voltage - Temperature Rise Table °F...

Page 6 - USE COPPER CONDUCTORS ONLY.; Refrigerant Lines; Quench all welded joints with water or a wet rag.; CAUTION; piston kit chart

6 Maximum Overcurrent Protection (MOP) Every installation must include an NEC (USA) or CEC(Canada) approved overcurrent protection device. Also,check with local or state codes for any special regional re-quirements. Protection can be in the form of fusing or HACR style circuitbreakers. The Series an...

Page 7 - slide; Figure 1; AFTER THE TAILPIECE HAS COOLED; Figure 2; Downflow Conversion; Table 7; or ARPF Mod el; Figures 3 through 5; Figure 3

7 2. After the gas has escaped, remove the nut and discard the black or brass cap. 3. Remove the check piston to verify it is correct and then replace the piston. See piston kit chart in instructions. 4. Use a tube cutter to remove the spin closure on the suction line. 5. Remove the tailpiece clampe...

Page 8 - Figure 4; Figure 5; Horizontal Conversion; o r ARPF Mo del; Table 8; See Figure 6; Figure 6; Condensate Removal

8 3” FLAT INSULATIONRETAINER(BOTH SIDES) Figure 4 To complete the conversion, slide the evaporator coil intothe chassis and attach the three (3) access panels. (Figure 5). WRAPPER INSULATIONJACKET ZEE COILSUPPORT WRAPPERSTIFFENER DRAIN PANINSULATION KIT BLOWERASSEMBLY Figure 5 NOTE: When converted t...

Page 9 - Figure 7; Tip; ACHIEVING 2% LOW LEAKAGE RATE

9 drain line located inside the building. Use Armaflex® orsimilar material. A Secondary Condensate Drain Connection has been pro-vided for areas where the building codes require it. Pitch thedrain line 1/4" per foot to provide free drainage. Insulate drainlines located inside the building to pre...

Page 10 - ASPF Motor; CFM Delivery; Thermostats; Second Stage heat can be accomplished by multi-

10 0.1 " 0 .2 " 0 .3 " 0 .4" 0 .5" H igh 1 15 5 1 09 0 1 02 5 9 50 89 5 AR U F17 29 1 6 Med . 9 40 8 90 8 60 8 15 75 5 Lo w 6 95 6 65 6 50 6 10 55 0 H igh 1 15 5 1 09 0 1 02 5 9 50 89 5 AR U F18 24 1 6 Med . 9 40 8 90 8 60 8 15 75 5 Lo w 6 95 6 65 6 50 6 10 55 0 H igh 1 13 5 1 08...

Page 11 - Regular Maintenance; NOT; CFM deliverd against External Static Pressure

11 thermostat as shown in Figures 10 and 11 . Goodman® part number CHT18-60 is a single-stage cool andsingle-stage heat thermostat. Goodman® part number HPT18-60 is a single-stage cool,two-stage heat pump thermostat. The first stage is heat pumpheating and the second stage is optional electric heat....

Page 12 - WARNING; ROOM THERMOSTAT; GREEN; CONTACTOR

12 Wiring is subject to change. Always refer to the wiring diagram on the unit for the most up-to-date wiring. HIGH VOLTAGE! DISCONNECT ALL POWER BEFORE SERVICING. MULTIPLE POWER SOURCES MAY BE PRESENT. FAILURE TO DO SOMAY CAUSE PROPERTY DAMAGE, PERSONAL INJURY OR DEATH. WARNING ROOM THERMOSTAT W Y ...

Page 14 - ASPF THERMOSTAT CONNECTIONS; The following sections will be detailed:; COOLING UNIT WITH OPTIONAL HEAT KITS OF 10 kW AND BELOW

14 ASPF THERMOSTAT CONNECTIONS The following composite wiring diagrams detail various configurations in which the ASPF air handlers can be used. Ex-amples include single-stage cooling and heat pump with single or two-stage electric heating. All these configurations can beapplied with convenient conn...

Page 15 - COOLING UNIT WITH OPTIONAL HEAT KITS OF 15 kW AND ABOVE

15 HIGH VOLTAGE! DISCONNECT ALL POWER BEFORE SERVICING. MULTIPLE POWER SOURCES MAY BE PRESENT. FAILURE TO DO SOMAY CAUSE PROPERTY DAMAGE, PERSONAL INJURY OR DEATH. WARNING Wiring is subject to change. Always refer to the wiring diagram on the unit for the most up-to-date wiring. Y G W W2 R COOLING U...

Page 16 - HEAT PUMP UNIT WITH OPTIONAL HEAT KITS OF 15 kW AND ABOVE

16 Wiring is subject to change. Always refer to the wiring diagram on the unit for the most up-to-date wiring. HIGH VOLTAGE! DISCONNECT ALL POWER BEFORE SERVICING. MULTIPLE POWER SOURCES MAY BE PRESENT. FAILURE TO DO SOMAY CAUSE PROPERTY DAMAGE, PERSONAL INJURY OR DEATH. WARNING G C R HEAT PUMP UNIT...

Page 17 - Shorting the “speedup” quick connect to “C” decrease times as follows:; NOTE: This is not applicable to ASPF models.; ELECTRONIC BLOWER TIME DELAY RELAY

17 HIGH VOLTAGE! DISCONNECT ALL POWER BEFORE SERVICING. MULTIPLE POWER SOURCES MAY BE PRESENT. FAILURE TO DO SOMAY CAUSE PROPERTY DAMAGE, PERSONAL INJURY OR DEATH. WARNING Wiring is subject to change. Always refer to the wiring diagram on the unit for the most up-to-date wiring. 1 2 0 / 2 4 0 V A C ...

Page 18 - THIS PAGE LEFT INTENTIONALLY BLANK

Goodman ATUF - Manual

Table of Contents:

Summary

Other Goodman Models