GermGuardian 4270 - Manual

GermGuardian 4270

GermGuardian 4270 – Manual, read for free online in PDF format. We hope this helps you resolve any issues you may have. If you have further questions, please contact us through the contact form.

1 Page 1
2 Page 2
3 Page 3
4 Page 4
5 Page 5
6 Page 6
7 Page 7
8 Page 8
9 Page 9
10 Page 10
11 Page 11
12 Page 12
13 Page 13
14 Page 14
15 Page 15
16 Page 16
17 Page 17
18 Page 18
19 Page 19
20 Page 20
21 Page 21
22 Page 22
23 Page 23
24 Page 24
25 Page 25
26 Page 26
27 Page 27
28 Page 28
29 Page 29
30 Page 30
31 Page 31
32 Page 32
33 Page 33
34 Page 34
35 Page 35
36 Page 36
37 Page 37
38 Page 38
39 Page 39
40 Page 40
41 Page 41
42 Page 42
43 Page 43
44 Page 44
45 Page 45
46 Page 46
47 Page 47
48 Page 48
49 Page 49
50 Page 50
51 Page 51
52 Page 52
53 Page 53
54 Page 54
55 Page 55
56 Page 56
57 Page 57
58 Page 58
59 Page 59
60 Page 60
61 Page 61
62 Page 62
63 Page 63
64 Page 64
65 Page 65
66 Page 66
67 Page 67
68 Page 68
69 Page 69
70 Page 70
71 Page 71
72 Page 72
73 Page 73
74 Page 74
75 Page 75
76 Page 76
77 Page 77
78 Page 78
79 Page 79
80 Page 80
81 Page 81
82 Page 82
83 Page 83
84 Page 84
85 Page 85
86 Page 86
87 Page 87
88 Page 88
89 Page 89
90 Page 90
91 Page 91
92 Page 92
93 Page 93
94 Page 94
95 Page 95
96 Page 96
97 Page 97
98 Page 98
99 Page 99
100 Page 100
Page: / 100

Table of Contents:

  • Page 3 – Table of Contents
  • Page 5 – the stronger the magnetic field around the conductor.; ELECTROMAGNETIC INDUCTION; Figure 1-3. – A Simple Revolving Field Generator
  • Page 6 – A SIMPLE AC GENERATOR; The 2-pole ROTOR must be turned at 3600 rpm to produce an; A MORE SOPHISTICATED AC GENERATOR; Figure 1-6. – A More Sophisticated Generator
  • Page 8 – 20/240 VAC loads — one load with a maximum total wattage; GENERATOR CONVERSION TO; ground stud adjacent to the four-position terminal block.; Model
  • Page 11 – One Ohm, 25 Watt Resistor; BRUSHES
  • Page 12 – LED
  • Page 15 – Disconnect and isolate all Stator leads as follows:
  • Page 16 – TESTING ROTOR INSULATION; Remove the brush holders with brushes.; THE MEGOHMMETER; ROTOR MINIMUM INSULATION RESISTANCE:
  • Page 18 – • Shorting together of any two parallel Stator wind-
  • Page 19 – OHMS; VOLTS
  • Page 26 – ENGINE CONTROL CIRCUIT BOARD; TERMINAL; BATTERY
  • Page 27 – RECOMMENDED CABLE SIZE
  • Page 28 – Figure 5-7. – Starter Contactor and Connections
  • Page 30 – Figure 5-13. – High Coolant Temperature Switch; OVERSPEED PROTECTION; LOW OIL
  • Page 40 – VOLTAGE
  • Page 41 – TEST 4 RESULTS; TEST 5- WIRE CONTINUITY
  • Page 42 – TEST 7 - TEST STATOR DPE WINDING; EXCITATION “DPE” WINDING RESISTANCE
  • Page 43 – AC POWER WINDING RESISTANCE; TEST 9- CHECK BRUSH LEADS
  • Page 44 – TEST 11- CHECK ROTOR ASSEMBLY; Set a VOM to its “Rx1” scale and zero the meter.; ROTOR RESISTANCE; Set the VOM to its “Rx1 K” or “Rx10,000” scale and zero the
  • Page 46 – BATTERY CHARGE WINDING RESISTANCE
  • Page 47 – b. Actuate the switch to its “PRE-HEAT” position and; TEST 20- CHECK FUEL PUMP
  • Page 51 – by low or no RPM and excessive current draw.
  • Page 56 – DOWN TEST / COMPRESSION TEST
  • Page 60 – BELT TENSIONING
  • Page 61 – LINE CORNER
  • Page 63 – DESCRIPTION
  • Page 70 – Electrical Enclosure Assembly – Drawing No. 0D2361-E
  • Page 72 – Intake and Exhaust System – Drawing No. 0D2362-B
  • Page 74 – Fuel and Electrical Systems – Drawing No. 0D2363-C
  • Page 75 – Fuel Pump Assembly
  • Page 76 – Customer Controls Assembly – Drawing No. 0D2364-D
  • Page 83 – Liter Diesel Rocker Arm Assembly – Drawing No. 075683
  • Page 85 – To Injection Pump
  • Page 89 – Section 9
  • Page 90 – Major Features and Dimensions – Drawing No. 0D2650-A
  • Page 92 – TORQUE SPECIFICATIONS; ROTOR/STATOR RESISTANCE VALUES; TYPE
  • Page 93 – NOTES
  • Page 95 – ELECTRICAL DATA
Loading the manual

DIAGNOSTIC

REPAIR MANUAL

DIAGNOSTIC

REPAIR MANUAL

QUIETPACT

®

75D

RECREATIONAL VEHICLE GENERATOR

MODEL 4270

"Loading the manual" means you need to wait until the file loads and becomes available for online reading. Some manuals are very large, and the time they take to appear depends on your internet speed.

Summary

Page 3 - Table of Contents

Table of Contents Page 1 SAFETY ............................ INSIDE FRONT COVER SECTION 1: GENERATOR FUNDAMENTALS ...................... 3-7 MAGNETISM ................................................................ 3ELECTROMAGNETIC FIELDS .................................... 3ELECTROMAGNETIC INDUCT...

Page 5 - the stronger the magnetic field around the conductor.; ELECTROMAGNETIC INDUCTION; Figure 1-3. – A Simple Revolving Field Generator

Section 1 GENERATOR FUNDAMENTALS MAGNETISM Magnetism can be used to produce electricity andelectricity can be used to produce magnetism.Much about magnetism cannot be explained by ourpresent knowledge. However, there are certain pat-terns of behavior that are known. Application of thesebehavior patt...

Page 6 - A SIMPLE AC GENERATOR; The 2-pole ROTOR must be turned at 3600 rpm to produce an; A MORE SOPHISTICATED AC GENERATOR; Figure 1-6. – A More Sophisticated Generator

Section 1GENERATOR FUNDAMENTALS A SIMPLE AC GENERATOR Figure 1-4 shows a very simple AC Generator. Thegenerator consists of a rotating magnetic field calleda ROTOR and a stationary coil of wire called a STA-TOR. The ROTOR is a permanent magnet which con-sists of a SOUTH magnetic pole and a NORTH mag...

Other GermGuardian Models

All GermGuardian Other