GermGuardian 004582-2 - Manual

Table of Contents:

• Page 3 – DANGER
• Page 4 – Despite the safe design of this generator,; GENERAL HAZARDS; IMPORTANT SAFETY INSTRUCTIONS
• Page 5 – STANDARDS INDEX
• Page 6 – Figure 1 - Bracket Removal; Section 1 – General Information; Shipping
• Page 7 – CONNECTION; The battery shipped with the generator has been provided fully; Figure 3 - Battery Connections; Section 1 - General Information; Negative; Figure 2 - Handle Assembly
• Page 8 – Figure 4 - Control Panel
• Page 9 – CORD SETS AND CONNECTION PLUGS; Figure 8 - 120 VAC, 20 Amp GFCI Receptacle; Testing the GFCI: Test the GFCI outlet every month as follows:; Section 2 – Operation
• Page 10 – Figure 11 - 12 Volt DC, 10 Amp Receptacle; HOW TO USE THE GENERATOR; THE; Figure 13 - Grounding the Generator; Generator Ground Lug
• Page 11 – DO NOT; DON’T OVERLOAD THE GENERATOR
• Page 12 – BEFORE STARTING THE GENERATOR; Synthetic oil should only be used after first oil change.; GASOLINE; Never fill fuel tank indoors. Never fill fuel tank; Use regular UNLEADED gasoline with the generator engine. Do; Be careful not; Install fuel cap and wipe up any spilled gasoline.; Figure 14 - Fuel Tank; It is important to prevent gum deposits from forming
• Page 13 – TO START THE ENGINE; Never start or stop engine with electrical; Figure 16 - Idle Control Switch; “Full Choke”; Figure 17 - Full Choke Position
• Page 14 – Do not permit smoking, open flame, sparks
• Page 15 – MODEL; SPECIFICATIONS; Summer; SCHEDULE; Operation
• Page 16 – RECOMMENDATIONS; Never insert any object or tool through the air; MAINTENANCE; When working on the generator, always; completely into a suitable container.
• Page 17 – Replace the plug once each year.; Figure 18 - Spark Plug Gap; SERVICE AIR CLEANER; Figure 19 - Air Cleaner; Filter; To clean or replace paper air filter:; CLEAN SPARK ARRESTOR SCREEN; Clean and inspect the spark arrestor as follows:; Figure 20 - Spark Arrestor
• Page 18 – If feeling uncomfortable about doing this procedure or the; To check valve clearance:; Loosen the rocker jam nut (Figure 21). Use an 10mm allen wrench; Figure 21 - Valve Clearance Adjustment; NEVER store engine with fuel in tank indoors
• Page 19 – TERM; Remove all gasoline from the fuel tank.; Remove spark plugs and pour about 1/2 ounce (15 ml) of engine; Avoid spray from spark plug holes when; openings on generator are open and unobstructed.; STORAGE; gasoline will cause problems with the carburetor and fuel system.; BE SURE TO EMPTY THE FUEL TANK.; NEVER cover the generator while engine and
• Page 20 – GUIDE; PROBLEM; Engine will not crank.; Replace fuse with only an identical 10-amp; No Choke; Move choke to halfway position until engine runs
• Page 21 – Section 5 — Electrical Data; Electrical Schematic – Drawing No. 0G0733
• Page 22 – Wiring Diagram – Drawing No. 0G0731
• Page 24 – Section 6 — Exploded Views and Parts Lists
• Page 34 – only; ATTENTION WARRANTY DEPARTMENT; Section 7 – Warranty
• Page 35 – EMISSION CONTROL SYSTEM WARRANTY; EMISSION RELATED PARTS INCLUDE THE FOLLOWING:
• Page 36 – GENERAC POWER SYSTEMS “TWO YEAR” LIMITED WARRANTY FOR GUARDIAN; YEARS ONE and TWO; GENERAC