Generac 004709-0 - Manual

Table of Contents:

• Page 2 – Table of Contents
• Page 3 – INTRODUCTION; READ T HIS MANUAL THOROUGHLY; Notes contain additional information important to a procedure; C ONTENTS; AUTHORIZED SERVICE; Introduction
• Page 4 – GENERAL HAZARDS; Safety Rules
• Page 5 – CALIFORNIA PROPOSITION 65 WARNING
• Page 6 – GENERATOR IDENTIFICATION; General Information
• Page 7 – Figure 1.1 – Connections for 120 Volts Only; SPECIFICATIONS; REQUIREMENTS
• Page 8 – CONSUMPTION; Model
• Page 9 – GENERATOR CONTROL PANEL; Figure 2.1 – Generator Control Panel; PRIMER; AUTOMATIC CHOKE; SOLENOID; BEFORE STARTING THE; Instructions and information in this manual assume the genera-; LUBRICATION; Operation
• Page 10 – SUPPLY; STARTING THE GENERATOR
• Page 11 – PROTECTION SYSTEMS; Figure 2.2 – Low Oil Pressure and; BOOST; Figure 2.3 – Field Boost Circuit; PROTECTION
• Page 12 – Figure 2.4 – Solid State Voltage Regulator; ADDITIONAL INFORMATION; ATTENTION REQUIRED AFTER SUBMERSION; Never operate the engine with the oil level; Maintenance
• Page 13 – Check the oil level and fill to the “FULL” mark after checking for; Figure 3.2 – Engine Air Cleaner; CLEANING OR REPLACING THE PAPER FILTER; Oil Dipstick/Oil Fill; Figure 3.1 – Oil Maintenance Features
• Page 14 – CLEAN AIR INTAKE; Figure 3.3 – Cleaning Air Intake; CHECKING THE ENGINE; Figure 3.4 – Setting the Spark Plug Gap; Sparking can occur if the wire terminal does; Figure 3.5 – Fuel Filter; CLEAN SPARK ARRESTOR; If using the generator on any forest-covered, brush-covered or
• Page 15 – CLEANING THE GENERATOR; Servicing of the battery is to be performed or supervised by
• Page 16 – Using a fuel additive such as STA-BIL fuel stabilizer, or an; ADJUSTING VALVE; Figure 3.7 — Adjusting Valve Clearance
• Page 17 – Figure 3.8 — Tightening Jam Nut; RV GENERATOR SERVICE
• Page 18 – Notes
• Page 19 – ONLY QUALIFIED ELECTRICIANS OR CONTRACTORS
• Page 20 – NOTICE TO INSTALLER; Installation Instructions
• Page 22 – Figure 1.1 – 120-volt Single Voltage Connection; Do NOT connect loads in excess of circuit breaker ratings.
• Page 24 – LOCATION AND SUPPORT; LOCATION; Figure 2.1 – Typical Horizontal Support Frame; MOUNTING; Figure 2.2 – Typical Suspended Mounting System; RESTRAINT; Installation
• Page 25 – Figure 2.3 – Typical Generator Restraint; GENERATOR COMPARTMENTS; SIZE; Figure 2.4 – Clearances; CONSTRUCTION; Figure 2.5 – Typical Compartment Construction
• Page 26 – Figure 2.6 – Types of Lock Seams; Any method used to reduce noise must not adversely affect the; Figure 2.7 – Typical Noise Abatement
• Page 28 – AIRFLOW; Figure 2.9 – Airflow Through Engine/Generator; GASOLINE FUEL SYSTEM; Figure 2.10 – Generator Fuel System
• Page 29 – TANK; EXHAUST SYSTEM; ARRESTOR
• Page 30 – Figure 2.12 — Spark Arrestor Installation; ELECTRICAL CONNECTIONS
• Page 31 – Figure 2.13 – Generator AC Output Leads; BATTERY INSTALLATION; BATTERY; If the battery is to be used to power other vehicle accessories,
• Page 33 – CABLES; CABLE LENGTH; Figure 2.16 – Connecting Battery Cables; COMPARTMENT; OPTIONAL ACCESSORIES; Figure 2.17 – Remote Panel Plug-in Receptacle
• Page 34 – Post Installation Start-up Adjustments
• Page 35 – INSTALLATION CHECKLIST; DATE OF INSTALLATION
• Page 36 – TROUBLESHOOTING GUIDE; Problem Cause; Troubleshooting
• Page 38 – Electrical Data
• Page 39 – Electrical
• Page 40 – Exploded Views & Parts Lists
• Page 50 – CALIFORNIA AND FEDERAL EMISSION CONTROL WARRANTY STATEMENT; YOUR WARRANTY RIGHTS AND OBLIGATIONS; ATTENTION WARRANTY DEPARTMENT; Warranty
• Page 51 – EMISSION CONTROL SYSTEM WARRANTY; EMISSION RELATED PARTS INCLUDE THE FOLLOWING:
• Page 52 – GENERAC POWER SYSTEMS’ THREE-YEAR LIMITED WARRANTY; WARRANTY SCHEDULE – COMMERCIAL APPLICATIONS