Page 2 - Table of Contents; AUX E
Table of Contents SECTION I GENERAL INFORMATION ........................................................................ 1-1 1.1 INTRODUCTION........................................................................................................... 1-1 1.2 SCOPE ........................................
Page 3 - Page ii; APPENDIX A – MP3 CREATION; APPENDIX D- STC INFORMATION AND INSTRUCTIONS FOR CONTINUING; Table of Figures; Date Change
PS Engineering PAV80 Series IFE System Installation and Operator’s Manual 200-800-0101 Page ii Rev. 5 Feb. 2004 3.5 D ISPLAY D IMMING (7) ..................................................................................................... 3-5 SECTION IV- WARRANTY AND SERVICE ..........................
Page 4 - Section I GENERAL INFORMATION; Model Part; Remote; DESCRIPTION
PS Engineering PAV80 Series IFE System Installation and Operator’s Manual 200-800-0101 Page 1-1 Rev. 5 Feb. 2004 Section I GENERAL INFORMATION 1.1 INTRODUCTION Quality cockpit and cabin entertainment has long been an elusive dream in general aviation. From marginal performance to unapproved parts, p...
Page 5 - PAV80 Panel Unit
PS Engineering PAV80 Series IFE System Installation and Operator’s Manual 200-800-0101 Page 1-2 Rev. 5 Feb. 2004 Operation is subject to the following conditions: This device may not cause harmful interference. This device must accept any interference received, including interference that may cause ...
Page 6 - PVT801 Video Terminal Unit; EQUIPMENT SUPPLIED
PS Engineering PAV80 Series IFE System Installation and Operator’s Manual 200-800-0101 Page 1-3 Rev. 5 Feb. 2004 PVT801 Video Terminal Unit FAA-TSO COMPLIANCE APPLICABLE DOCUMENTS: SAE AS8034 RTCA/DO-160D RTCA/DO-178B (Level E) RTCA DO-254 (Level E) ENVIRONMENTAL Qualifications: B4BABSXXXXXXZBBBAUHX...
Page 7 - Optional Equipment
PS Engineering PAV80 Series IFE System Installation and Operator’s Manual 200-800-0101 Page 1-4 Rev. 5 Feb. 2004 Model Part Number Description PAV80 050-800-0100 DVD-IFE System with AM/FM CD MP3 PVT801 050-801-0100 LCD Video Display, 5.5-inch Remote 051-803-0150 Infrared remote control PAV80 Install...
Page 8 - APPROVED AUDIO SYSTEMS; Make Model
PS Engineering PAV80 Series IFE System Installation and Operator’s Manual 200-800-0101 Page 1-5 Rev. 5 Feb. 2004 1.8 APPROVED AUDIO SYSTEMS This is a list of audio system that the PAV80 should interface with adequately. Approved Audio Systems, PAV80 Certified interface is approved only for audio sys...
Page 9 - Section II - Installation; GENERAL INFORMATION; tainment; An; Unpacking and Preliminary Inspection; Requirements; The unit may be installed in any orientation.
PS Engineering PAV80 Series IFE System Installation and Operator’s Manual 200-800-0101 Page 2-1 Rev 2 Sept. 2003 Section II - Installation 2.1 GENERAL INFORMATION 2.1.1 SCOPE These sections provide detailed installation and interconnect instructions for the PAV80 In-Flight Enter- tainment System wit...
Page 10 - Existing Structure; Factory Avionics Location; Figure 2-1 Typical Tray Installation Location
PS Engineering PAV80 Series IFE System Installation and Operator’s Manual 200-800-0101 Page 2-2 Rev 2 Sept. 2003 2.00” 6.31” 2.3.3 Mounting Rack Installation Remove the unit from the mounting tray by unscrewing the 3/32" hex-head screw that is near the left edge of the unit. Carefully slide the ...
Page 11 - Panel Opening; Figure 2-4 Completed panel installation
PS Engineering PAV80 Series IFE System Installation and Operator’s Manual 200-800-0101 Page 2-3 Rev 2 Sept. 2003 Panel Opening Saw and file used to remove existing instrument panel from this location Figure 2-3 Completed panel opening (Typical) Figure 2-4 Completed panel installation 2.3.4 Connector...
Page 12 - nt; Cable Harness Wiring
PS Engineering PAV80 Series IFE System Installation and Operator’s Manual 200-800-0101 Page 2-4 Rev 2 Sept. 2003 B A C 120-425-4402Connector 475-440-0007 (2 plcs)Screws F ro nt o f tr ay Rearof tray 475-632-0007 Screw (x2) Washer 475-632-0001Nut 475-632-0005 430-730-0025Tray Shield Figure 2-5 -Tray ...
Page 13 - See Appendix B for typical circuit breaker layout.; Figure 2-7 Antenna Installation
PS Engineering PAV80 Series IFE System Installation and Operator’s Manual 200-800-0101 Page 2-5 Rev 2 Sept. 2003 2.4.2 Power The PAV80-Series units are compatible with both 14 and 28 Volt DC systems. A five (5) Amp PULL-TYPE breaker is required. Power and ground wires must be a twisted #18 AWG pair....
Page 14 - Aux Entertainment Audio and AUX Enable; The video input is Pin 17 (with respect to Pin U); W a r n i n g; PVT801 Display Installation:; Figure 2-8 Portable mounting bracket with PVA801 attached; OPTIONAL PVA802 Video Distribution Amplifier Installation
PS Engineering PAV80 Series IFE System Installation and Operator’s Manual 200-800-0101 Page 2-6 Rev 2 Sept. 2003 2.4.5 Aux Entertainment Audio and AUX Enable Besides the disc and AM/FM, the PAV80 has the ability to act as a switching control for an additional en-tertainment input, both audio and vid...
Page 15 - Figure 2-9 View of typical PVA802 Installation; Adjustments; Checkout; player should pull the disk smoothly and drop into place.
PS Engineering PAV80 Series IFE System Installation and Operator’s Manual 200-800-0101 Page 2-7 Rev 2 Sept. 2003 Figure 2-8 PVA802 Dist. Amp Circuit breaker location (Typical) Connect the PVA802 to a 5-amp PULL TYPE circuit breaker. The unit connector is a crimp type, however, we recommend soldering...
Page 16 - e. Evaluate the muting override control if equipped.; FM; Inspection
PS Engineering PAV80 Series IFE System Installation and Operator’s Manual 200-800-0101 Page 2-8 Rev 2 Sept. 2003 b. Evaluate the audio performance c. Evaluate the audio level to verify that the music is adequate under flight conditions. d. Evaluate the muting system to demonstrate that the music wil...
Page 17 - Section III OPERATION; Figure 3-1 Front Panel Controls; Controls
PS Engineering PAV80 Installation and Operator’s Manual 200-800-0101 Page 3-1 Rev. 5 Feb. 2004 Section III OPERATION GENERAL INFORMATION 3.1 SCOPE This section describes the operation of the PAV80 In-Flight Entertainment system. Operating controls consist of two rotary knobs with push-push switches,...
Page 19 - Operation
PS Engineering PAV80 Installation and Operator’s Manual 200-800-0101 Page 3-3 Rev. 5 Feb. 2004 Table 1-PAV80 Functions Action Disc Result Radio Result ▲ short press Stop ▲ long press Eject (also in AUX) ► short press Play / Pause ►► short press Next track ►► long press Fast forward Increase frequenc...
Page 20 - Volume Control; PAV80 IFE SYSTEM
PS Engineering PAV80 Installation and Operator’s Manual 200-800-0101 Page 3-4 Rev. 5 Feb. 2004 3.4 Remote Operation The remote supplied is used to control various functions of the secondary audio output. Volume Control Menu Selection Disc Control Track Selection MENU 1 2 3 NEXT 4 5 6 0 7 8 9 FF ENTE...
Page 21 - Dimming
PS Engineering PAV80 Installation and Operator’s Manual 200-800-0101 Page 3-5 Rev. 5 Feb. 2004 3.5 Display Dimming The display can be adjusted for ambient light conditions by the connection to the aircraft dimmer bus. At minimum bus voltage (or no lighting present) the display is set at maximum.
Page 22 - Section IV- Warranty and Service; Service
PS Engineering PAV80 Installation and Operator’s Manual 200-800-0101 Page 4-1 Rev. 5 Feb. 2004 Section IV- Warranty and Service 4.1 Warranty In order for the factory warranty to be valid, the installations in a certified aircraft must be accomplished by an FAA-certified avionics shop and authorized ...
Page 23 - Appendix A; Appendix A – MP3 Creation; Creating MP3s from an Audio CD
PS Engineering PAV80 Installation and Operator’s Manual 200-800-0101 Appendix A Rev. 5 Feb. 2004 Appendix A – MP3 Creation 5.1 Creating MP3s from an Audio CD 1. Start MusicMatch JukeBox.( www.musicmatch.com ) Press the recorder button, which is the small red dot located in the top right corner. This...
Page 24 - Appendix B; Appendix B – Installation Drawings; AUTOPILOT; New Installation
PS Engineering PAV80 Installation and Operator’s Manual 200-800-0101 Appendix B Rev. 5 Feb. 2004 Appendix B – Installation Drawings PAV80 Unit AUTOPILOT XPNDR AUDIO PANEL NAV/COM PIPER PN 101271-013 COPILOT'S PANEL ASSY. Viewed from front DATE REV 2 REVISIONS DRAWING NUMBER INCORPORATED ENGINEERING ...
Page 25 - PLAN VIEW; Install wire bundle and cable clamps as required IAW AC43.13-1B:; ELEV VIEW; PAV80 Installation Diagram; Antenna
PS Engineering PAV80 Installation and Operator’s Manual 200-800-0101 Appendix B Rev. 5 Feb. 2004 Intercom Jacks (existing)Video Jack (new) Typical, 1 each side 13 12 11 10 9 43 2 1 L ocated PVA802 1 G L P7- 11-03 1 2 3 4 5 14 15 16 17 18 6 7 8 9 19 20 21 22 10 23 24 11 12 25 13 Video Monitor Cable V...
Page 26 - Connector viewed from the rear; Connector Key; Z Y X W V U T S R P N M L K J H F E D C B; Connector viewed from the FRONT of unit tray
PS Engineering PAV80 Installation and Operator’s Manual 200-800-0101 Appendix B Rev. 5 Feb. 2004 Washer 475-632-0001& Nut 475-632-0005 475-632-0007 (2 plcs)Screws Tray Shield 07 09 03 GLP 3 Add t b k h ll hi l Detail A A Rear of tray Front of tray 0.92 in 0.32 in 5.57 in 0.32 in 7.71 in 6.25 1.9...
Page 27 - Figure 6-4 Display connector layout; Mounting Slot; Figure 6-5 - PVT801 Monitor Dimension Details
PS Engineering PAV80 Installation and Operator’s Manual 200-800-0101 Appendix B Rev. 5 Feb. 2004 PVT801 Display InterfaceView from solder cup 1= Video Ground2= Display Power 3= Power Ground 4= Video Signal5= No Connection 1 2 3 4 5 Figure 6-4 Display connector layout 1.38 in 0.2 in ConnectorExit 3.0...
Page 30 - Figure 6-10 PVA802 Connector viewed from cable side
PS Engineering PAV80 Installation and Operator’s Manual 200-800-0101 Appendix B Rev. 5 Feb. 2004 Ø0.136 (4 plcs) 1.250 3.500 4.000 5.470 4.725 Figure 6-9 PVA802 Video Distribution Amplifier Installation (Dwg. 120-802-0100) Video Input Signal A/C Power ground Video Input Low P ow er ( 11 -3 3 V D C )...
Page 31 - Appendix C; Appendix C Connector Interconnect; Single Display System; PAV80 Connector; Entertainment Output; View from solder cup
PS Engineering PAV80 Installation and Operator’s Manual 200-800-0101 Appendix C Rev. 5 Feb. 2004 Appendix C Connector Interconnect 7.1 Single Display System Entertainment Outputconnected to audio panel or intercom Antenna InputAntenna Ground 2B Notes: Secondary Entertainment Output (L)Secondary Ente...
Page 32 - nn
PS Engineering PAV80 Installation and Operator’s Manual 200-800-0101 Appendix C Rev. 5 Feb. 2004 Multiple Display System Wiring E nt er ta in m en t O ut pu t co nn ec te d to au di o pa ne l o r in te rc om A nt en na In pu t A nt en na G ro un d 2 B Notes : Se co ndary Entert ainm ent Ou tput (L) ...
Page 33 - Appendix D; Appendix; STC information and instructions for continuing airworthiness; location; Instructions for Continuing Airworthiness, PAV80s; Section Item
PS Engineering PAV80 Installation and Operator’s Manual 200-800-0101 Appendix D Rev. 5, Feb. 2004 Appendix D- STC information and instructions for continuing airworthiness 8.1 Instructions for FAA Form 337, PAV80s The STC was developed using an Approved Model List (AML). One method of airworthiness ...
Page 34 - Master Drawing List; Title; Use of Approved Model List
PS Engineering PAV80 Installation and Operator’s Manual 200-800-0101 Appendix D Rev. 5, Feb. 2004 8.3 Master Drawing List The following drawings are contained on the FAA-Approved Master Drawing List, Document Number 002-800-1000: Title In this manual Part Number Revision Date Installation Manual X 0...
Page 36 - Appendix E; Appendix E RTCA DO160D/EUROCAE ED-14D Enviro; nmental; Qualification Form; Manufacturer: PS Engineering Incorporated 9800 Martel Road; Conditions Section
PS Engineering PAV80 Installation and Operator’s Manual 200-800-0101 Appendix E Rev. 5 Feb. 2004 Appendix E RTCA DO160D/EUROCAE ED-14D Enviro nmental Qualification Form Part Number: 050-800-(-xxx) Manufacturer: PS Engineering Incorporated 9800 Martel Road Lenoir City TN 37772 Conditions Section Cond...
