Fisher & Paykel OR120 - Manual

4 Operation Your freestanding cooker has been carefully designed to operate safely during normal cooking procedures. Please keep the following guidelines in mind when you are using it: WARNING! Hot Surface Hazard Accessible parts may become hot when this cooker is in use.To avoid burns and scalds ke...

5 Important safety precautions Isolating switch: make sure this cooker is connected to a circuit which incorporates an isolating switch providing full disconnection from the power supply. Household appliances are not intended to be played with by children. Children, or persons with a disability whic...

6 Installation instructions 600 mm 1200 mm MAX 927 mm MIN 915 mm 120 mm Fig. 1 Location The installation conditions, concerning protection against overheating of the surfaces adjacent to the cooker, must conform to Fig.3a or 3b.The appliance must be kept no less than 200 mm away from any side wall w...

7 Installation instructions 450 mm minim um minim um 650 mm 0 mm 0 mm 500 mm minim um 200 mm minim um 450 mm minim um minim um 650 mm 20 mm 20 mm 500 mm minim um 200 mm minim um Gas connection made using rigid or flexible metal pipe. Class 2 Subclass 1 Class 1 Gas connection made using rubber hose w...

8 Installation instructions + 8 mm + 8 mm 0 mm + 12 mm Levelling the cooker Important! Using the supplied adjustable feet is MANDATORY. For safety reasons and to ensure adequate ventilation, the cooker chassis MUST NOT sit directly on the floor, a plinth, or other support surface. The cooker is alre...

9 Installation instructions Moving the cooker Important! Two people must always raise the cooker, as shown, to prevent damaging the adjustable feet. Do not lift the cooker by the door handles.DO NOT DRAG the cooker. Lift the feet clear of the floor. Ventilation requirements (GB & IE only) The ap...

10 Installation instructions Gas installation (GB & IE only) Important! This cooker uses NATURAL GAS only and cannot be used on any other gas without modification. This appliance is manufactured for conversion to LPG if required. If the injectors are not supplied they can be obtained from the Af...

11 Notes: Flexible hoses can be used where the sited ambient temperature of the hose does not exceed 70°C. These hoses must be manufactured in accordance with BS669 part 1 and be of the correct construction for the type of gas being used. Gas hoses designed for natural gas MUST NOT be used for suppl...

12 Installation instructions C D A B Feeder cable section “TYPE H05RR-F” 230V 3 x 2.5 mm 2 (**) (**) - Connection with wall box connection. PE 1 2 3 4 5 N (L 2 ) L 1 230 V Red orBrown(Live) Black orBlue(Neutral) GreenandYellow(Earth) 2 3 4 5 1 N(L2) PE L1 PE Earth N Neutral L Live Connecting the fee...

13 Maintenance instructions Replacing the burner injectors If the injectors are not supplied, contactthe Fisher & Paykel Authorised ServiceCentre.Select the injectors to be replacedaccording to the ‘Table for the choice ofinjectors’. To replace the injectors: Remove pan supports and burners from...

14 Maintenance instructions F G H Setting the burner minimum Check whether the flame spreads to all burner ports when the burner is lit with the gas tap set to the minimum position. If some ports do not light, increase the minimum gas rate setting. Check whether the burner remains lit even when the ...

15 BURNERS Nominal Power [kW ] Reduced Power [kW ] G 30 - 28-30 mbar G 31 - 37 mbar G 20 20 mbar By-pass [1/100 mm] Ø injector [1/100 mm] By-pass [1/100 mm] Ø injector [1/100 mm] Semi-rapid 1,75 0,45 32 65 97 (Z) Triple ring wok 3,50 1,50 65 95 135 ( T ) Dual inner crown 1,00 (*) 0,32 (*) 27 50 (no....

16 Introducing your cooker Thank you for buying a Fisher & Paykel freestanding cooker. Once it is installed and ready to use, you will want to know everything about it to make sure you get excellent results right from the start. This guide introduces you to all its special features. We recommend...

17 Using your cooktop Gas burners The knob controls the flow of gas through the safety tap. = closed valve = maximum aperture or flow = minimum aperture or flow You can choose to cook at any heat between and , but never between and OFF. . 1 Semi-rapid burner 2 Triple-ring wok burner 3 Dual burner 0 ...

18 Using your cooktop Before using your cooktop Before using your new cooktop, please: Read this user guide, taking special note of the ‘Safety and warnings’ section. Make sure all controls are turned off. Lighting the cooktop 1 Choose the control knob for the burner you want to use. 2 Press the kno...

19 Using your cooktop The dual burner can be used as: a small burner, with the flame only from the inner crown. as a high powered burner, with flames from both the inner and outer crowns. To change from using the inner crown only to using both the inner and outer crowns together, press the control k...

20 Using your cooktop Choosing a burner Use flat-bottomed pans, and make sure that they match your burner, as shown in the following table. A small pot on a large burner is not efficient. Diameters of pans which may be used on the cooktop Burners Minimum Maximum Semi-rapid 16 cm 24 cm Dual crown 26 ...

21 Cooktop troubleshooting Problem Possible solutions My cooktop burners do not light. Check the cooker is switched on.Check the gas supply valve is turned on and the supply to the house is working. You should hear the gas when you turn a burner on.The ignitors may be dirty. Clean them with a toothb...

22 Using your ovens for the fi rst time Fig. 18 Control panel Temperature knob Function knob Before using your new oven, please: 1 Read this user guide, taking special note of the ‘Safety and warnings’ section. 2 Remove all accessories and packaging. 3 Set the clock. The oven will not work until the...

23 Clock and timer Fig. 20 Clock display and control buttons Buttons Timer Cooking time End of cooking time Manual position; and cancels the set program Decreases the number shown on the display or changes the volume of the beeps Increases the number shown on the display Illuminated symbols AUTO - f...

24 Using your oven 1 Select the function using the function knob. The oven lights will come on. 2 Select the temperature using the temperature control knob. The oven temperature indicator light, above the temperature knob on the control panel, will glow until the oven has reached the set temperature...

25 Cooking functions OVEN LAMP Only the oven light comes on. It remains on in all the cooking functions. BAKE The upper and lower heating elements come on. BAKE is the traditional method of cooking. It is best to cook on only one shelf at a time in this function. GRILL The grill at the top of the ov...

26 FAN BAKE The upper and lower heating elements and the fan come on. Important! Safe food handling: leave food in the oven for as short a time as possible before and after cooking or defrosting. This is to avoid contamination by organisms which may cause food poisoning. Take particular care during ...

27 Use automatic cooking to automatically turn the oven on, cook, and then turn the oven off. 1 Check the clock shows the correct time. 2 Select the function and temperature. The oven will come on. 3 Decide how long the food will take to cook, allowing time for preheating if necessary. 4 Press the b...

28 Before using your warmer drawer, please: Condition it by heating it on maximum for about two hours. Wipe it out with a damp cloth and mild detergent, and dry thoroughly. Important! Always start with hot food. Safe food handling: leave food in the oven for as short a time as possible before and af...

29 Care and cleaning Important! Before you start cleaning your cooker, please: Read these cleaning instructions and the ‘Safety and warnings’ section at the start of this user guide. Turn the cooker off at the wall. Make sure the cooker is a safe temperature to touch. Do not use a steam cleaner. Do ...

30 Care and cleaning Fig. 28 Replacing the semi-rapid burners Fig. 27 Semi-rapid burner parts Burner parts and pan supports You can remove and clean these parts with hot soapy water or non-abrasive detergents. Clean spills regularly before they become burnt on. Do not wash these parts in a dishwashe...

31 Care and cleaning Replacing the triple-ring wok burner To replace the wok burner, fit the burner ring to the housing as shown by the arrow in the Fig. following. Make sure the burner is not able to rotate. Fig. 29 Triple-ring wok burner parts Probe Ignitor Fig. 30 Replacing the triple-ring wok bu...

32 Care and cleaning Correct position of dual burners The DUAL burner must be correctly positioned; the burner rib must be fitted as shown by the arrows. Position the central small cap in its housing as shown by the arrows. Position the big cap in its housing as shown by the arrows. Important! Never...

33 Care and cleaning Cleaning the inside of your ovens Do not use abrasive cleaners, cloths or pads to clean the enamel. To make cleaning easier, you can remove the side racks, the oven door, and the fat filter. Once you have removed the side racks, the top grill element also drops down to make clea...

34 Care and cleaning Cleaning the enamel cavity Clean the enamel on the inside of the oven when it has cooled down, using household detergents or an ammonia-based cleaner. You may use ‘off the shelf ’ oven cleaners, if you carefully follow the manufacturers’ instructions. Cleaning the fat filter Cle...

35 Care and cleaning Fig.27 Fig.35a Cleaning the oven door glass Do not use harsh abrasive cleaners or sharp metal scrapers to clean the oven door glass since they scratch the surface, which may result in shattering of the glass. The oven door has three panes of glass. To clean these, you need to re...

36 Care and cleaning 3 Remove the middle pane: Gently unlock the middle pane of glass from the bottom clamps by moving it as in Fig. 36b. Gently lift the bottom edge of the pane (arrow 1 in Fig. 36c) and remove it by pulling it out from the top clamps (arrow 2 in Fig. 36c). Clean the glass with an a...

37 Care and cleaning Fig.37a Replacing the middle and inner panes of glass 1 Make sure the door is locked open (see Figs 35a - 35c). 2 Replace the middle pane: Check that the four rubber pads are in place (“M” in Fig. 37a). Check that you are holding the pane the correct way. You should be able to r...

38 Care and cleaning 3 Replace the inner pane: Check that the four rubber pads are in place (“D” in Fig. 38a). Check that you are holding the pane the correct way. You should be able to read the wording on it as it faces you. Insert the pane in the left “E” and right “F” slide guides (Fig. 38b), and...

39 Care and cleaning Removing the oven door(s) The oven door(s) can easily be removed as follows: Open the door to the full extent (Fig. 39a). Open the lever “A” completely on the left and right hinges (Fig. 39b). Hold the door (Fig.39c). Gently close the door until left and right hinge levers “A” a...

40 Care and cleaning 3 Removing the drawers 1 Open the drawer completely (Fig. 40a). 2 Move the lever of the left guide down and move the lever of the right guide up. 3 Remove the drawer, while still holding the levers. Important! Warming drawer (left drawer only): Do not remove drawer while hot. Do...

41 Care and cleaning Replacing the oven lamp Let the oven cavity and the heating elements cool down. Remove the protective cover “B”. Unscrew and replace the bulb “A” with a new one suitable for high temperatures (300°C) with the specifications: 230-240V 50 Hz, 25W, E14 Refit the protective cover, “...

42 Warranty and service Before you call for service or assistance ... Check the things you can do yourself. Refer to the installation instructions and your user guide and check that: 1 Your product is correctly installed. 2 You are familiar with its normal operation. If after checking these points y...