Page 2 - ASSEMBLY, OPERATION AND MAINTENANCE INSTRUCTIONS; SECTION
STYLE, GRILLED TO PERFECTION ASSEMBLY, OPERATION AND MAINTENANCE INSTRUCTIONS FOR EVERDURE 4 BURNER ESEE BUILT-IN GAS BARBECUE RANGE MURRAY ESEE & SUNBURY ESEE OUTDOOR BARBECUES CONTENTS SECTION PAGE NO. General Safety Instructions ……………… 3 Appliance Details ………………………… 4 Gas Connections ……………………...
Page 3 - IMPORTANT SAFETY INSTRUCTIONS (ELECTRICAL)
STYLE, GRILLED TO PERFECTION IMPORTANT SAFETY INSTRUCTIONS IMPORTANT: Read the assembly instruction section and safety precautions of this booklet carefully before removing the contents of this carton. If you are unsure about anything regarding your barbecue, please contact your Service Centre befor...
Page 4 - GAS CONNECTIONS; FOR PROPANE CYLINDER CONNECTION; Leak test all gas connections.
STYLE, GRILLED TO PERFECTION APPLIANCE DETAILS MAIN BARBECUE Gas Type: Propane N.G Burner Pressure: 2.75 kPa 0.95 kPa Injector Diameter: Ø1.10 mm Ø1.80 mm Heat Input: 60 MJ/ hr 60 MJ/ hr Note: The size of the injector diameter is stamped on one of the hexagon faces (e.g. ‘180’ for Ø1.80mm injector)....
Page 5 - LEAK TESTING; DO NOT USE NAKED FLAME FOR LOCATING GAS LEAKS.; GAS CONVERSION; FLAME SAFEGUARD SYSTEM
STYLE, GRILLED TO PERFECTION LEAK TESTING Make sure gas control knobs are Off and turn the cylinder valve On. 1. Check for leaking joints by brushing with solution of half-liquid detergent and half water. If a leak is present, bubbles will appear (or you may hear a hissing sound). Retightening conne...
Page 6 - OUTDOOR INSTALLATION GUIDE; at least 25% of the total wall area is completely open: and
STYLE, GRILLED TO PERFECTION OUTDOOR INSTALLATION GUIDE This Appliance shall only be used in an above ground open-air situation with natural ventilation, without stagnant areas, where gas leakage and products of combustion are rapidly dispersed by wind and natural convection. This appliance must not...
Page 7 - OPERATING INSTRUCTIONS; GAS TYPE AND CONSUMPTION
STYLE, GRILLED TO PERFECTION OPERATING INSTRUCTIONS GAS TYPE AND CONSUMPTION The barbecues are designed to operate on Propane and NG Gas (gas type must be specified at time of purchase). Gas consumption, Pressure and Injector Orifice size are shown on the Data Plate found on the left-hand side of th...
Page 8 - LIGHTING PROCEDURE; LIGHTING THE BARBECUE USING THE ELECTRONIC IGNITION; LIGHTING SYSTEM INSTRUCTIONS; Battery
STYLE, GRILLED TO PERFECTION LIGHTING PROCEDURE Read all operating instructions before lighting. Open roasting hood before lighting. Make sure all gas control knobs are in the ‘Off’ position and open cylinder valve or connect natural gas. LIGHTING THE BARBECUE USING THE ELECTRONIC IGNITION The Everd...
Page 9 - COOKING WITH YOUR BARBECUE PLATES; updated cooking guides.
STYLE, GRILLED TO PERFECTION COOKING COOKING WITH YOUR BARBECUE PLATES A fairly protected location is desirable for pleasant and efficient cooking. Try to keep the barbecue sheltered from strong winds as this will drastically reduce cooking efficiency. Check frequently that the burners remain alight...
Page 10 - STORAGE; cooking surfaces to prevent rust.; MAINTENANCE; Test the gas circuit for leaks and remedy any found.
STYLE, GRILLED TO PERFECTION CLEANING & STORAGE CLEANING Before cleaning, ensure the appliance has cooled and is safe to touch. Painted surfaces can be cleaned using a mild household detergent or cleaner and a clean cloth (do not use scourers or harsh detergents). It is advisable to test cleaner...
Page 11 - TROUBLESHOOTING; Power not on
STYLE, GRILLED TO PERFECTION TROUBLESHOOTING Burner will not ignite when using the igniter: Cylinder valve is not on Turn cylinder valve on. Cylinder is empty Replace with a full cylinder. Igniter button is not working Check battery. Igniter is not sparking Remove plate and visually check ignition b...
Page 12 - ASSEMBLY INSTRUCTIONS; For all service and assembly enquiries call:
STYLE, GRILLED TO PERFECTION ASSEMBLY INSTRUCTIONS PARTS LIST Barbecue Chassis Carton: Cooking Plates Pack: Roasting Hood Carton: Barbecue Chassis (with light switch & cable) Hot Plate Roasting Hood (with lights) Fat Tray Grill Plate Fastener Pack Gas Hose & Regulator (Propane only) Vapouris...
Page 13 - BURNER BARBECUE COMPONENTS
STYLE, GRILLED TO PERFECTION M5 x 12MM SCREW 4 BURNER BARBECUE COMPONENTS GRILL PLATE 9 7 10 RIGHT HAND BARBECUE CARCASS 5 3 1 REAR LOUVRE ROD VAPOURISER 8 SPACER LEFT HAND 4 6 FAT TRAY 2 BUILT-IN BRACKET BUILT-IN BRACKET x1 x1 x1 x1 x2 x8 x1 x1 SOLID PLATE x1 x4 M5 x 30MM SCREW 16 x8 13
Page 14 - BURNER HOOD COMPONENTS; BURNER POWER ADAPTOR COMPONENTS
STYLE, GRILLED TO PERFECTION 4 BURNER HOOD COMPONENTS FIBRE WASHER 14 x4 M5 NUT 13 M5 x 20 COUNTERSUNK SCREW x4 12 x4 11 HOOD x1 4 BURNER POWER ADAPTOR COMPONENTS 15 POWER ADAPTOR AND CABLE x1 14
Page 15 - FITTING THE BUILT-IN BRACKETS TO THE BARBECUE ASSEMBLY; BARBECUE ASSEMBLY
STYLE, GRILLED TO PERFECTION BRACKETS WITH M5 X 12 SCREWS (PARTS 10). NOTE: THE BRACKETS HAVE THEIR TOP LIPS POINTING AWAY 4. THREAD M5 X 30 SCREWS (PARTS 16) THROUGH 4 HOLES ON EACH BRACKET, THROUGH A SPACER (PART 6) 3. ALIGN THE BRACKETS AT EITHER SIDE OF THE BARBECUE, TO MATCH THE HOLES IN THE BR...
Page 16 - ATTACHING THE HOOD TO THE BARBECUE
STYLE, GRILLED TO PERFECTION 2. PLACE THE HOOD ASSEMBLY (PART 11) ON TOP OF THE BARBECUE SO THAT THE TABS IN THE REAR HOOD SIDES LINE UP WITH THE HOLES ALONG THE INNER EDGES OF THE BARBECUE. TAKE CARE NOT TO DAMAGE 3. PLACE 1 x M5 SCREW THROUGH THE HOLE OF A REAR HOOD SIDE TAB, FIX A FIBRE WASHER, A...
Page 17 - NOTE: TO BE INSTALLED ONLY BY AN AUTHORISED PERSON
STYLE, GRILLED TO PERFECTION BUILT-IN DIMENSIONS C NOTE: TO BE INSTALLED ONLY BY AN AUTHORISED PERSON PLEASE NOTE: MINIMUM CLEARANCE TO COMBUSTIBLES UNDER FAT TRAY IS 100mm PLEASE NOTE: THIS IS A GUIDE ONLY - PLEASE REFER TO YOUR LOCAL AUTHORITY'S REGULATIONS AND AS5601. BASED ON CLASSIC "06"...
Page 18 - BARBECUE ASSEMBLY: ADDING COOKING PLATES
STYLE, GRILLED TO PERFECTION BARBECUE ASSEMBLY: ADDING COOKING PLATES D NOTE: THE HOOD AND BUILT-IN STRUCTURE ARE NOT SHOWN FOR CLARITY. 7 8 9 1. WITH THE BARBECUE & HOOD ASSEMBLY IN PLACE, THE SUPPLIED PLATES CAN BE FITTED. PLACE THE VAPOURISER (DIMPLES UP) IN PLACE OVER THE RHS 2 BURNERS. PLAC...
Page 19 - EVERDURE BARBECUE ACCESSORIES (OPTIONAL); EVERDURE BARBECUE COVERS; Australian outdoor elements
STYLE, GRILLED TO PERFECTION EVERDURE BARBECUE ACCESSORIES (OPTIONAL) Everdure also offers a comprehensive range of essential barbecue accessories - everything that you need to turn your barbecue into a complete outdoor cooking system and also to prolong the use of your product. Visit www.everdure.c...
Page 20 - GAS CONVERSION & INSTALLATION; GAS CONVERSIONS CAN ONLY BE DONE BY AN AUTHORISED PERSON.; IMPORTANT – FOR THE INSTALLER
STYLE, GRILLED TO PERFECTION GAS CONVERSION & INSTALLATION GAS CONVERSIONS CAN ONLY BE DONE BY AN AUTHORISED PERSON. IMPORTANT – FOR THE CONSUMER & INSTALLER 1. CHECK WITH EVERDURE Not all Everdure barbecues are certified for conversion to NG. If in doubt, contact us on 1300 766 066 in Austr...
Page 21 - EXPLODED COMPONENT DIAGRAMS
STYLE, GRILLED TO PERFECTION EXPLODED COMPONENT DIAGRAMS REF DESCRIPTION QTY USED PER BBQ 1.00 HOOD HANDLE 1 2.00 TEMPERATURE GAUGE 1 3.00 FRONT HOOD ASSEMBLY 1 4.00 REAR HOOD no lighting panel 1 5.00 HOOD HINGE BOLT 2 6.00 LIGHTING PANEL (ESEE MODELS ONLY) 1 7.00 GLASS COVER - LIGHT (ESEE MODELS ON...
Page 22 - NOTES
STYLE, GRILLED TO PERFECTION NOTES ___________________________________________________________________ ___________________________________________________________________ ___________________________________________________________________ _____________________________________________________________...
Page 23 - Gas Heaters; Gas Radiant
STYLE, GRILLED TO PERFECTION NOTES ___________________________________________________________________ ___________________________________________________________________ ___________________________________________________________________ _____________________________________________________________...
Page 24 - STYLE. GRILLED TO PERFECTION
STYLE, GRILLED TO PERFECTION A division of Shriro Australia Pty Ltd 104 Vanessa St Kingsgrove NSW 2208 In Australia: 1300 766 066 www.everdure.com IM Ref: MRXXE 0480 07/2013/05FC F O R O U T D O O R U S E O N L Y STYLE. GRILLED TO PERFECTION
