Delfield 4400 series - Manual

Page 2 - Delfield; IMPORTANT WARNING AND SAFETY INFORMATION; WARNING; CAUTION

Delfield IMPORTANT WARNING AND SAFETY INFORMATION WARNING Read this manual thoroughly before operating, installing, or performing maintenance on the equipment. FAILURE TO FOLLOW INSTRUCTIONS IN THIS MANUAL CAN CAUSE PROPERTY DAMAGE, INJURY OR DEATH. DO NOT STORE OR USE GASOLINE OR OTHER FLAMMABLE VA...

Page 3 - Table of Contents

Compact Refrigerators Table of Contents SAFETY PRECAUTIONS .................................................................... 2 INTRODUCTION ................................................................................. 4 General ....................................................................

Page 4 - INTRODUCTION; General; RECEIVING AND INSPECTING; Figure 1. Serial Number Location

Delfield INTRODUCTION General All cabinets have stainless steel exteriors and ABS inte-riors. Door gaskets are magnetic and mount to the door, snapping in place and are removable without tools. Serial Number Location The serial number on all 4400 series compact refrigera-tors is printed under the to...

Page 5 - SPECIFICATIONS

Compact Refrigerators SPECIFICATIONS FLAT TOP REFRIGERATOR bASES MODEL DESCRIPTION L OVERALL H STORAGE SHELVES 1/6 PAN H.P. REFG. CHG. AMP NEMA SHIP. D CUBIC FT. SQ. FT. CAPACITY (ounces) PLUG WT. (lbs) 4427N one door 27” 31.5” 36” 5.7 3.2 — 1/5 9 7.2 5-15P 220 D4427N two drawer 27” 31.5” 36” 1.38 —...

Page 9 - INSTALLATION

Compact Refrigerators INSTALLATION Location Cabinets represented in this manual are intended for indoor use only. Be sure the location chosen has a floor strong enough to support the total weight of the cabinet and contents. Reinforce the floor as necessary to provide for maximum loading. The locati...

Page 10 - Caster Mounting Detail

10 Delfield Figure 2. 5-15P Connector Refer to the amperage data list in SPECIFICATIONS, the serial tag, your local code or the National Electrical Code to be sure the cabinet is connected to the proper power source. A protected circuit of the correct voltage and amperage must be run for connection ...

Page 11 - OPERATION; Figure 5. Thermostat Location - Salad Top

11 Compact Refrigerators OPERATION REFRIGERATED CAbINETS After the cabinet is connected to the power source it will automatically begin operating. With the covers and doors closed, the temperature of the cabinet should reach 36°F to 40°F (2°C to 4°C) in about one hour. Temperature on salad top will ...

Page 12 - MAINTENANCE; STAINLESS STEEL CARE AND; CLEANING THE CONDENSER COIL

1 Delfield MAINTENANCE CAUTION The thermostat must be turned to OFF and the cabinet disconnected from the power source whenever per-forming service, maintenance functions or cleaning the refrigerated area. STAINLESS STEEL CARE AND CLEANING To prevent discoloration or rust on stainless steel several ...

Page 13 - Refrigeration Cycle; Figure 6. Door Hinge

1 Compact Refrigerators bASIC MAINTENANCEGasket Maintenance Gaskets require regular cleaning to prevent mold and mildew build up and also to maintain the elasticity of the gasket. Gasket cleaning can be done with the use of warm soapy water. Avoid full strength cleaning products on gaskets as this c...

Page 14 - Flat Top Units; WIRING DIAGRAMS

1 Delfield L1 Flat Top Units G BLACK NEMA 5-15P Supply Cord and Plug furnished EVAPORATOR FANS TEMPERATURE CONTROL CONDENSING UNIT WHITE N Salad Top Units NEMA 5-15P Supply Cord and Plug furnished L1 TEMPERATURE CONTROL HPS N HPS Temperature Control Knob Access 1 3 5 WIRING DIAGRAMS

Page 16 - Manufacturers Limited Lifetime Warranty

1 Delfield Manufacturers Limited Lifetime Warranty Delfield warrants to the original purchaser-user, subject to the limitations and exclusions set forth below, that the ABS interior of the Delfield models identified above will be free of manufactured defects for as long as the equipment is owned by ...

Page 17 - STANDARD ONE YEAR WARRANTY

1 Compact Refrigerators STANDARD ONE YEAR WARRANTY (One year parts, 90 days labor) The Delfield Company (“Delfield”) warrants to the Original Purchaser of the Delfield product (herein called the “Unit”) that such Unit, and all parts thereof, will be free from defects in material and workman-ship und...

Page 18 - NOTES