Cub Cadet S7237 - Manual

8 SAFETY DECALS AND LABELS WARNING SHIELD MISSING DO NOT OPERATE Part Number: 00030635 Part Number: 777S30503 Part Number: 01002166 Part Number: 777S33087 Part Number: 02005110 Part Number: 777S33086 Part Number: 02002693 ! WARNIN Maximum weight on hitch is 50 lbs. Maximum towed load is 500 lbs. Nev...

9 SPECIFICATIONS GENERAL INFO.Controls: Engine ignition and start switch; throttle; choke; speed control pedals; electric blade clutch switch; parking brake; mower deck lift Steering: 14” diameter steering wheel coupled to hydraulic steering valve and cylinder Parking Brake: Mechanical linkage brake...

10 OPERATING INSTRUCTIONS A.General 1. When Mowing: a. Keep adults, children, and pets away from the area to be mowed. b. When operating this mower, in the forward direc- tion, do not allow the speed control pedals to rap-idly return to Neutral. Always operate the pedal smoothly and avoid any sudden...

12 highest (also transport position) or lowest (also for mower deck removal and installation). The following features are incorporated into the hydraulic actuated valve implement lift design: Lever implement lift allows for some operators with physical limitations to use the implement lift mechanism...

15 c. Make sure that the speed control pedal is in the neutral position. d. Turn the electric blade clutch switch “Off”.e. Push the throttle control to a position a third of the way between slow and fast. f. Insert the key in the ignition and start switch and turn the switch to “On”. g. Gasoline Eng...

18 d. Raise the seat forward to expose the hydraulic oil fill point. e. Clean the area around the hydraulic fill oil cap.f. Remove hydraulic fill oil cap.g. Place a suitable container (at least 1 gallon) under the hydraulic reservoir and filter. h. Remove the hydraulic filter to allow hydraulic oil ...

20 b. Front Wheel—25 psi max; 20-25 psi recom- mended c. Cutting Deck Ball Wheels—Solid Polyurethane. Use the Following guidelines for maintaining the tires: a. Balance inflation pressure between the rear tires to help maintain straight travel (see tire side wall for proper inflation pressure). b. K...

21 F. Hydraulic System WARNING: Never overfill the hydraulic units. Damage can occur if the oil level is not within the proper operating range. Note: W hen adding hydraulic oil, do so in small quan- tities and recheck the oil level before adding more. It is important that you do not overfill the res...

23 MAINTENANCE SCHEDULE A. Daily Checks 1. Before starting engine: a. Check the fuel level.**b. Check the engine oil level.**c. Check the hydraulic oil level.d. Check the hydraulic hoses for leaks, abrasion, kinks, twists, or a flattened condition. e. Check the tires and tire pressure. Drive Tires: ...

24 . OIL CHART Apply a few drops of engine oil or use a spray lubricant. Apply the oil to both sides of pivot points. Wipe off any excess. Start engine and operate mower briefly to insure that oil spreads evenly. Number of Oil Points Description DAILY 44222212 WEEKLY 122111422 Deck Suspension Pivots...

25 Performance Adjustments A. Engine RPM Check and Adjustment 1. Verify that the speed control pedals are in the neutral position, the parking brake is on, and the PTO drive is disengaged. 2. Start the mower and let it run at approximately half throttle for 3-5 minutes to bring the engine up to oper...

26 lower the mowing deck into the 4" height of cut posi-tion. (The 4" height of cut position is recommended in order for one to see and obtain a measurement. Any height of cut position is acceptable as long as a proper measurement can be taken.) 2. Check the right and left front tire pressur...

28 Front Skirt Inner Baffle Discharge Baffle Cutting Blades Gauge Wheels Front Roller Rear Rollers Standard set-up Low installed installed Hi-lift Low = 3" to 5" Low = 3" to 5" Low = 3" to 5" Stems (Dandelion, Bahia, Buckhorn, etc.) Med removed installed Hi-lift High = 1"...

29 SLOPE GAUGE Do not mo w on incline s with a slope in excess of 2 0 degre es ( a r ise o f ap pr oximately 3 fee t every 10 fee t). A riding mower cou ld ov er turn and cause ser iou s inju ry. If op er at in g a walk-b ehin d mo wer on su ch a slope, it is extre m ely difficu lt to mai n tain you...