Page 2 - NOTES
Page 3 - TABLE OF CONTENTS; PAGE
3 TABLE OF CONTENTS PAGE TRACTOR PREPARTION . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4IMPORTANT SAFE OPERATION PRACTICES . . . . . . . . . . . . . . . . . . . . . 5CALLING SERVICE INFORMATION . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 9FINDING YOUR...
Page 4 - SECTION 1: TRACTOR PREPARATION; Connect the Battery; Make sure the ignition switch is; Position the High Back Seat; right; Adjustments
4 SECTION 1: TRACTOR PREPARATION Connect the Battery Battery posts, terminals andrelated accessories containlead and lead compounds.Wash hands after handling . The tractor is shipped with a sealedbattery, with the positive battery cablefactory connected. The negative cablemust be connected. Note: Ma...
Page 5 - SECTION 2: IMPORTANT SAFE OPERATION PRACTICES; : THIS SYMBOL POINTS OUT IMPORTANT SAFETY; WARNING; GENERAL OPERATION
5 SECTION 2: IMPORTANT SAFE OPERATION PRACTICES WARNING : THIS SYMBOL POINTS OUT IMPORTANT SAFETY INSTRUCTIONS WHICH, IF NOT FOLLOWED, COULD ENDANGERTHE PERSONAL SAFETY AND/OR PROPERTY OF YOURSELF ANDOTHERS.READ AND FOLLOW ALL INSTRUCTIONS IN THIS MANUALBEFORE ATTEMPTING TO OPERATE YOUR UNIT. FAILUR...
Page 7 - CHILDREN
7 • Avoid starting or stopping on a slope. If tires lose traction, disen-gage the blade(s) and proceedslowly straight down the slope. • Follow the manufacturers recom- mendations for wheel weights orcounterweights to improve stability. • Use extra care with grass catchers or other attachments. These...
Page 8 - Restrict the use of
8 • To reduce fire hazard, keep the machine free of grass, leaves orother debris build-up. Clean up oil orfuel spillage. Allow machine to coolat least 5 minutes before storing. • Before cleaning, repairing or inspecting, make certain the bladeand all moving parts have stopped.Disconnect the spark pl...
Page 9 - Figure 1; Model Number
9 SECTION 3: CALLING SERVICE INFORMATION The engine manufacturer is responsible for all engine-related issues withregards to performance, power-rating, and specifications. If you have difficulties with the unit, have any question regarding the operationor maintenance of this equipment, or desire add...
Page 10 - SECTION 5: SAFETY LABELS FOUND ON YOUR UNIT; Figure 2; Running Board - Center; DANGER
10 SECTION 5: SAFETY LABELS FOUND ON YOUR UNIT Figure 2 TO ENSURE SAFE AND PROPER OPERATION OF TRANSMISSION, ONLY USE CUB CADET DRIVE SYSTEM FLUID PLUS. 737-3120 - 1 QUART 737-3121 - 1 GALLON READ OPERATOR'S MANUAL WARNING WARNING ! HOT AREAS DECK HEIGHTADJUSTMENT (360 Turn Equals 1/2" Adjustmen...
Page 11 - SECTION 6: CONTROLS and FEATURES; Figure 3; Choke Lever
11 A C F G H E P K I M N O R T S J B (Not Shown) Q ABCDEFGH I KLMNOPQR Low Fuel Indicator LampIndicator Panel/Hour MeterKey Switch ModuleParking Brake LeverPTO SwitchBrake PedalReverse PedalForward Pedal12V Power Outlet Transmission Release RodTransmission Oil Fill / DipstickFuel Fill CapCup HolderH...
Page 12 - Battery Indicator; Hour Meter/ Battery Display; Figure 4
12 NOTE: References to LEFT and RIGHT indicate that side of the tractorwhen facing forward while seated inthe drivers seat. Reference to FRONTindicates the grille end of the tractor;to REAR, the drawbar end. Steering Wheel The steering wheel, centered on thedash panel, is used to turn the tractor le...
Page 13 - Reverse Push Button; Mowing in reverse is; Figure 5
13 • The hour meter is activated when the key switch is turned to either the“NORMAL MOWING” or the"REVERSE CAUTION MODE"switch positions. A record of theactual hours of operation should bekept to assure maintenance proce-dures are completed according tothe schedule in this manual. • When the...
Page 14 - D. Parking Brake Lever; Figure 6; Always look; Figure 9; 2V Power Outlet
14 D. Parking Brake Lever Figure 6 The parking brake lever is located tothe right of the steering wheel in thedash panel. With the brake pedaldepressed fully, push the parkingbrake lever downward and release thebrake pedal to lock the parking brake. E. PTO Switch The PTO switch is located on thelowe...
Page 16 - Safety Interlock Switches; Cub Cadet; Fueling The Tractor; NOTE; Do not
16 SECTION 7: OPERATION Safety Interlock Switches This tractor is equipped with a safetyinterlock system for the protection ofthe operator. If the interlock systemshould ever malfunction, do notoperate the tractor. Contact yourauthorized Cub Cadet Dealer. The safety interlock system prevents theengi...
Page 18 - Although not recommended,
18 • If properly engaged, the cruise lever and forward control pedal shouldlock in the down position, and thetractor will maintain the sameforward speed. • Disengage the cruise control using one of the following methods: - Depress the brake pedal to disengage the cruise controland stop the tractor. ...
Page 19 - KEY SWITCH MODULE
19 Using the REVERSE CAUTION MODE key position The REVERSE CAUTION MODE position of the key switch module allowsthe machine to be operated in reversewith the blades (PTO) engaged. IMPORTANT: Mowing in reverse is not recommended . Use extreme caution whileoperating the tractor in the“Reverse Caution ...
Page 20 - Do not engage the
20 Using The Drawbar Drawbar equipment must be hitched tothe tractor only at the hitch hole. SeeFigure 13. Figure 13 Mowing WARNING: To avoid possi- ble injury, never direct thedischarge of material towardbystanders or allow anyonenear the machine while in op-eration. Although the areahas been suppo...
Page 21 - SECTION 8: ADJUSTMENTS; Seat Adjustment
21 SECTION 8: ADJUSTMENTS Seat Adjustment WARNING: Do not adjust the seat when the tractor ismoving, as this could causethe operator to lose controlof the tractor. For the comfort of the operator, thetractor is equipped with an easy tooperate adjustable seat. There arealso three seat mounting positi...
Page 22 - Brake Inspection and Adjustment; Transmission Released; Turning Radius Adjustment
22 Brake Inspection and Adjustment During normal operation, the tractorbrake is subject to minimal wear. How-ever, the brake should be periodicallytested, and adjusted if necessary. Checking the Brake. Place the tractor on a firm and levelsurface. Stop the engine and removethe ignition key.Pull and ...
Page 23 - SECTION 9: MAINTENANCE; Maintenance Chart; Operation to
23 SECTION 9: MAINTENANCE Maintenance Chart ‡ Change oil and filter after first 5 hours † More often under dusty conditions †† Clean every 25 hours or more often under dusty or dirty conditions NOTE: With the exception of utilizing the deck wash feature on the mower deck,we do not recommend the use ...
Page 24 - LUBRICATION ILLUSTRATION; ONLY
24 LUBRICATION ILLUSTRATION Cub Cadet 251H EP Greaseor equivalent No. 2 lithium grease Engine Oil: See Figure 27 on page 34Transmission Oil - Cub Cadet Drive Oil Can (High quality lubricating oil) System Fluid Plus - ONLY Engin e Fron t Pivot Axl e L /R Steeri ng Knuckle L /R Fro n t W heel s Foot C...
Page 25 - Turn
25 Accessing Engine Compartment The engine compartment can beaccessed by raising the hood asfollows: • Lift the hood straight upward at the recessed notches of the side panelsto disengage the internal hood latch. • Carefully pivot the hood forward to open. To close the hood: • Carefully pivot the ho...
Page 26 - Battery Removal; Always connect the; Battery Maintenance
26 with a solution of ammonia/water orbaking soda/water. • NEVER connect (or disconnect) battery charger clips to the batterywhile the charger is turned on, as itcan cause sparks. • Keep all sources of ignition (ciga- rettes, matches, lighters) away fromthe battery. The hydrogen gas gen-erated durin...
Page 28 - Do not reuse the transmission
28 then fully reinserted before beingwithdrawn again for a true reading. Figure 21 Adding Transmission Oil WARNING: The fluid for yourtransmission has been spe-cially formulated to ensurethe safe and proper opera-tion of your tractor. Add CubCadet Drive System FluidPlus ONLY. Do not use anyother flu...
Page 30 - Fuse; With the exception of utilizing
30 Fuse Fuses are installed to protect the trac-tor’s electrical system from damagecaused by excessive amperage.Always use the same capacity fuse forreplacement. Refer to the Specifica-tions Chart. If the electrical systemdoes not function, check the fuses.To replace a fuse, note the position ofthe ...
Page 31 - SECTION 10: ENGINE INFORMATION
31 SECTION 10: ENGINE INFORMATION KOHLER CO. FEDERAL AND CALIFORNIA EMISSION CONTROL SYSTEMS LIMITED WARRANTY SMALL OFF-ROAD EQUIPMENT ENGINES The U.S. Environmental Protection Agency (EPA), the California Air Resources Board (CARB), andKohler Co. are pleased to explain the Federal and California Em...
Page 32 - LIMITATIONS; MAINTENANCE AND REPAIRS REQUIREMENTS
32 LIMITATIONS This Emission Control System Warranty shall not cover any of the following: (a) repair or replacement required because of misuse or neglect, improper maintenance, repairs improperly performed or replacement not conforming to Kohler Co. specifications that adverselyaffect performance a...
Page 33 - EVERY HOUR; during the first five; Adding Engine Oil; Full
33 Cleaning The Engine This tractor has an air-cooled engine.Air must be able to circulate freelyaround the engine through theflywheel screen, through the coolingshrouds and over the fins of thecylinder head and cylinder block. Keepthese areas free of accumulated dirtand debris or the engine will ov...
Page 34 - Changing Engine Oil; MAINTENANCE CHART; A length of flexible tubing is
34 Refer to Figure 27 for informationregarding the proper type of oil to addto the crankcase. • Place the tractor on a level surface and engage the parking brake. Stopthe tractor engine and remove theignition key. • Clean the area around the oil filler cap to prevent debris from enteringthe crankcas...
Page 36 - IMPORTANT; Properly maintained air
36 WARNING: Operating theengine with loose or dam-aged air cleaner componentswill allow unfiltered air intothe carburetor, causing ex-tensive wear and eventualfailure of the engine. Servicing The Precleaner Wash and re-oil the foam precleanermore often under extremely dusty ordirty conditions. See F...
Page 37 - SECTION 11: TROUBLE SHOOTING; Hard To Start
37 SECTION 11: TROUBLE SHOOTING Possible Cause Possible Remedy Hard To Start No fuel in fuel tank or carburetor Fill the tank with fuel. Check the fuel line, carburetor and fuel filter. Fuel line or carburetor clogged Clean the fuel line and carburetor with a commercial carburetor cleaner. Fuel filt...
Page 39 - SECTION 12: OPTIONAL EQUIPMENT; Description
39 SECTION 12: OPTIONAL EQUIPMENT When you purchased your tractor, you probably had it completely equipped foryour particular needs at that time. However, later you may wish to obtainoptional equipment or accessories. These items and other allied equipment canbe purchased from, and installed by, you...
Page 40 - SECTION 13: SPECIFICATIONS; Tires
40 SECTION 13: SPECIFICATIONS Engine Manufacturer . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . KohlerHorsepower . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 23Cylinders . . . . . . . . . . . . . . . . . . . . . . . . ....
Page 41 - SECTION 14: SLOPE GAUGE; Do not mow on inclines with a slope in excess of 15
41 SECTION 14: SLOPE GAUGE WARNING: Do not mow on inclines with a slope in excess of 15 degrees (a rise of approximately 2-1/2 feet every 10 feet). A ridingmower could overturn and cause serious injury. If operating a walk-behind mower on such a slope, it is extremely difficult to maintainyour footi...
Page 43 - one; ) year for commercial users, commencing on the date of
43 CUB CADET LLC MANUFACTURER’S ONE YEAR LIMITED WARRANTY (COMMERCIAL USE) The limited warranty set forth below is given by CUB CADET LLC (“CUB CADET”)with respect to new merchandise purchased and used in the United States, itspossessions and territories. CUB CADET warrants this product against defe...
Page 44 - (Some states do not allow; How State Law Relates to this Warranty:; This limited warranty gives you
44 No implied warranty, including any implied warranty of merchantability orfitness for a particular purpose, applies after the applicable period ofexpress written warranty above. No other express warranty or guaranty,whether written or oral, except as mentioned above, given by any person orentity, ...
Page 45 - Batteries and belts are subject to separate terms as follows:; Year/500 Hour Limited Warranty
45 CUB CADET LLC MANUFACTURER’S LIMITED WARRANTY (RESIDENTIAL USE) The limited warranty set forth below is given by CUB CADET LLC (“CUB CADET”)with respect to new merchandise purchased and used in the United States, itspossessions and territories. CUB CADET warrants this product against defects in m...
Page 48 - SECTION 15: QUICK REFERENCE PARTS; Cub Cadet Drive; CARTRIDGE
SECTION 15: QUICK REFERENCE PARTS Description Part Number Engine Oil 737-3030A (10W30) 737-3049 (5W30) Air Filter KH-47-083-03 KH-24-083-02 Engine Oil Filter KH-12-050-08 Spark Plug 759-3336 Transmission Oil Cub Cadet Drive System Fluid Plus 737-3120 - Quart 737-3121 - Gallon Transmission Oil Filter...
