Crown 24-06 - Manual

Crown 24-06

Crown 24-06 – Manual, read for free online in PDF format. We hope this helps you resolve any issues you may have. If you have further questions, please contact us through the contact form.

1 Page 1
2 Page 2
3 Page 3
4 Page 4
5 Page 5
6 Page 6
7 Page 7
8 Page 8
9 Page 9
10 Page 10
11 Page 11
12 Page 12
13 Page 13
14 Page 14
15 Page 15
16 Page 16
17 Page 17
18 Page 18
19 Page 19
20 Page 20
21 Page 21
22 Page 22
23 Page 23
24 Page 24
25 Page 25
26 Page 26
27 Page 27
28 Page 28
29 Page 29
30 Page 30
31 Page 31
32 Page 32
33 Page 33
34 Page 34
35 Page 35
36 Page 36
37 Page 37
38 Page 38
39 Page 39
40 Page 40
41 Page 41
42 Page 42
43 Page 43
44 Page 44
45 Page 45
46 Page 46
47 Page 47
48 Page 48
49 Page 49
50 Page 50
51 Page 51
52 Page 52
53 Page 53
54 Page 54
55 Page 55
56 Page 56
57 Page 57
58 Page 58
59 Page 59
60 Page 60
61 Page 61
62 Page 62
63 Page 63
64 Page 64
65 Page 65
66 Page 66
67 Page 67
68 Page 68
69 Page 69
70 Page 70
71 Page 71
72 Page 72
73 Page 73
74 Page 74
75 Page 75
76 Page 76
77 Page 77
78 Page 78
79 Page 79
80 Page 80
81 Page 81
82 Page 82
83 Page 83
84 Page 84
85 Page 85
86 Page 86
87 Page 87
88 Page 88
89 Page 89
90 Page 90
Page: / 90

Table of Contents:

  • Page 3 – IMPORTANT INFORMATION - READ CAREFULLY; DANGER; Indicates an imminently haz ardous situation; CAUTION; WARNING; Indicates a potentially haz ardous situation; NOTICE; Indicates special instructions on installation,
  • Page 4 – by ow ner and service technician.
  • Page 5 – boiler. See page 9 for standard safety relief valve set pressures.
  • Page 6 – TABLE OF CONTENTS
  • Page 7 – Primary Loop using Sequencer and Outdoor Reset.; TABLE OF CONTENTS - Continued
  • Page 8 – Section I - General Information; FIGURE 1: Dimensional Information
  • Page 9 – TABLE I; Maximum Allowable Working Pressure:
  • Page 10 – R ecommended clearance for service may be; Table III: Recommended Rear Service Clearance
  • Page 11 – WAR N IN G; Failure to supply adequate air to the boiler
  • Page 12 – FIGURE 3b: VENTS — FAULTS & SUGGESTIONS; VENT SIZING; FAULTY BOILER BURNER OPERATION
  • Page 13 – B oiler sections must be draw n-up on; C AU TION; When assembling sections w ithout; SECTION II - CAST IRON BLOCK ASSEMBLY; Figure 5: Positioning of Back Section
  • Page 14 – N ipples must be driven in evenly and to
  • Page 15 – To avoid damage to the draw -up rod; Figure 8: Series 24 Section Arrangement
  • Page 16 – D o not over torque draw up nuts after grind
  • Page 17 – READ THE STATEMENTS BELOW BEFORE
  • Page 18 – D O N OT install gauge until after hydrostatic; Failure to properly hydrotest all boilers at
  • Page 19 – SECTION III - INSTALLATION INSTRUCTIONS; INSTALL CANOPY/FLUE OUTLET ASSEMBLY
  • Page 21 – Warning; AVOID Breathing Fiber Particulates and Dust; Precautionary Measures; Important P roduct S afety Information
  • Page 23 – To install multiple side panels, start at the
  • Page 24 – Figure 22: Series 24 Jacket
  • Page 25 – Failure to properly fill all gaps betw een the; For boilers without tankless heaters
  • Page 26 – Figure 25a Purpose of Tappings - Steam Boilers
  • Page 27 – Figure 25b: Steam Trim
  • Page 28 – STEAM BOILERS — INSTALL STEAM TRIM
  • Page 30 – Figure 26a: Purpose of Tappings - Water Boilers
  • Page 31 – Figure 26b: Water Trim
  • Page 32 – Failure to properly pipe boiler may result in; All steam and hot water pipes must have; BURNER INSTALLATION
  • Page 33 – reduce boiler longevity.; A hot w ater boiler installed above radiation
  • Page 34 – Typical Crown Boiler Loop w/3-way Diverting
  • Page 35 – Recommendation 1 — Use when:; system flow does not impact flow through the boiler; Pipe Sizing and Notes
  • Page 36 – Figure 32: Series 24 Minimum Piping Recommendation 2 - Water Boiler; Recommendation 2 — Use when:; Figure 33: Series 24 Minimum Piping Recommendation 3 - Water Boiler
  • Page 37 – Recommendation 3 — Use when:
  • Page 38 – professional to design for the proper application.; BOILER PIPING, DOMESTIC HOT WATER; D O N OT use the boiler circulator as an
  • Page 40 – ypical Steam Piping
  • Page 41 – CONNECT TANKLESS HEATER PIPING; The follow ing guidelines should be follow ed; D o not operate tankless heater w ith hard
  • Page 42 – Ratings are given in gallons per minute continuous
  • Page 44 – Figure 40b: Water Boiler - Pressure Relief Valve
  • Page 45 – ypical Boiler W
  • Page 46 – ypical Boiler with RTC Return Sensor (Rear)
  • Page 47 – SECTION IV - OPERATING INSTRUCTIONS; ALWAYS INSPECT INSTALLATION BEFORE; Failure to clean the system w ill result in
  • Page 48 – ADJUST BURNER; D o not attempt to start the burner w hen
  • Page 49 – Table V: Boil Min Delay Settings
  • Page 50 – TEST CONTROLS; B efore installation of the boiler is
  • Page 51 – P robe and float type low w ater cutoff
  • Page 53 – FREQUENT WATER ADDITION
  • Page 54 – SECTION V - SERVICE INSTRUCTIONS; that the w ires are reconnected properly.; D AN GE R; N ever modify, remove or tamper w ith any control device.
  • Page 55 – D o not start the burner unless canopy,; E xercise caution w hen handling phosphoric
  • Page 56 – If boiler is not used during w inter time, it
  • Page 57 – Table VI: Beckett Burner Specifications; SECTION VI - BURNER SPECIFICATIONS; OIL BURNERS
  • Page 58 – SECTION VII - REPAIR PARTS & CARTON CONTENTS; consult the area Crown representative or the factory at:
  • Page 59 – SERIES 24 MASTER PARTS LIST
  • Page 60 – Figure 43: Series 24 Jacket; AIR P
  • Page 61 – JACKET CARTON
  • Page 63 – SECTION JOINER CARTON ASSY; CANOPY CARTON
  • Page 66 – V Return Temperature Control (RTC) Packages
  • Page 70 – MINIMUM; This diagram is for reference only; SECTION VIII - APPENDIX
  • Page 73 – A2. 3-way RTC in Primary/Secondary – Heating and DHW using T
  • Page 75 – AC supplying the R
  • Page 76 – NOT
  • Page 78 – ater Heater on Primary Loop
  • Page 80 – ankless
  • Page 82 – Application Only with RTC – NO Building Heat (MECHANICAL); The return sensor
  • Page 83 – Application Only with RTC – NO Building Heat (ELECTRICAL)
  • Page 86 – Bell and Gossett
  • Page 87 – Armstrong
  • Page 88 – APPENDIX C – VALVE AND ACTUATOR MOUNTING INSTRUCTIONS
  • Page 89 – SERVICE RECORD; DATE
  • Page 90 – Manufacturer of Hydronic Heating Products
Loading the manual

1

D

E S I G N E D T O

L

E A D

Series 24

Forced Draft Steam or Water Boilers

INSTALLATION INSTRUCTIONS

These instructions must be affixed on or adjacent to the boiler.

WARNING

: Improper installation, adjustment, alteration,

service or maintenance can cause property damage, injury,

or loss of life. For assistance or additional information, con-

sult a qualified installer, service agency or the gas supplier.

This boiler requires a special venting system. Read these

instructions carefully before installing.

Models:

• 24-03

• 24-04

• 24-05

• 24-06

• 24-07

• 24-08

• 24-09

• 24-10

• 24-11

• 24-12

Manufacturer of Hydronic Heating Products

P.O. Box 14818 3633 I. Street

Philadelphia, PA 19134

Tel: (215) 535-8900 • Fax: (215) 535-9736 • www.crownboiler.com

D

E S I G N E D T O

L

E A D

"Loading the manual" means you need to wait until the file loads and becomes available for online reading. Some manuals are very large, and the time they take to appear depends on your internet speed.

Summary

Page 3 - IMPORTANT INFORMATION - READ CAREFULLY; DANGER; Indicates an imminently haz ardous situation; CAUTION; WARNING; Indicates a potentially haz ardous situation; NOTICE; Indicates special instructions on installation,

3 IMPORTANT INFORMATION - READ CAREFULLY , g n i b m u l P l a c o L d n a e t a t S ,l a n o it a N h ti w e c n a d r o c c a n i d e ll a t s n i e b t s u m s r e li o b ll A e s e h T . s e it il it u g n i v r e s e h t f o s n o it a l u g e r e h t d n a s e d o C l a c i r t c e l E d n a g...

Page 4 - by ow ner and service technician.

4 WARNING Improper installation, adjustment, alteration, service or maintenance can cause property damage, personal injury or loss of life. Failure to follow all instructions in the proper order can cause personal injury or death. R ead and understand all instructions, including all those contained ...

Page 5 - boiler. See page 9 for standard safety relief valve set pressures.

5 G N I N R A W , a n i m u l a n i a t n o c l e u f e h t d n a n o it s u b m o c f o s t c u d o r p , n o it c u r t s n o c f o s l a ir e t a m e c n a il p p A r o c i x o t r e h t o r o / d n a s e d y h e d l a , s e d i x o n e g o r ti n , e d i x o n o m n o b r a c , s l a t e m y v a...

Other Crown Models

All Crown Other