Cornelius Ice Cooled Dispensers - Manual
Cornelius Ice Cooled Dispensers – Manual, read for free online in PDF format. We hope this helps you resolve any issues you may have. If you have further questions, please contact us through the contact form.
Table of Contents:
- Page 2 – Clean and Sanitize Ice Bin, Drains and Drip Tray; Sanitizing Solution
- Page 4 – The CO; Regulator
- Page 5 – DRINK DISPENSER VALVES
- Page 6 – TROUBLESHOOTING
- Page 7 – NOTE
- Page 10 – WARRANTY; IMI Cornelius Offices
Rev 10/8/03
166239002
1
IMI Cornelius Inc; 1994–2003
166239002
Rev. Level 1
IMI CORNELIUS INC
One Cornelius Place
Anoka, MN 55303-6234
Telephone (800) 238-3600 Facsimile (800) 535-4231
OPERATORS MANUAL – ICE COOLED DISPENSERS
This instruction applies to all models of Drop-In and Free-Standing Ice Cooled
dispensers.
RECOMMENDED MAINTENANCE
Details of each task are listed immediately below the chart. Refer to the details by task number.
Maintenance Schedule
Task
D W M Q
1. Clean all exterior surfaces
O
2. Clean dispensing valves, Post-Mix
O
3. Clean dispensing valves, Pre-Mix
O
4. Clean & sanitize ice bin
O
5. Sanitize tank systems, post-mix and pre-mix
S
6. Sanitize syrup lines, B-I-B systems
S
7. Sanitize Bin Drain & Drip Tray Drain
O
Legend:
D
aily
W
eekly
M
onthly
Q
uarterly
O
perator
S
erviceperson
DETAILS OF MAINTENANCE TASKS
1. Clean All Exterior Surfaces
Cleaning The Tower
IMPORTANT: DO NOT USE ABRASIVE CLEANERS
A.
Remove the cup rest from the drip tray.
B.
Wash the drip tray with warm soapy water. Rinse the drip tray, allowing the rinse water to run down
the drain hose.
C.
Wipe entire exterior of the tower with a damp cloth. Dry the tower with a clean cloth (see caution be-
low).
"Loading the manual" means you need to wait until the file loads and becomes available for online reading. Some manuals are very large, and the time they take to appear depends on your internet speed.
Summary
Rev 10/8/03 166239002 2 IMI Cornelius Inc; 1994–2003 166239002 Rev. Level 1 CAUTION: To minimize the possibility of damaging the surface of the painted tower caremust be taken when choosing a cloth. The cloth must be of clean cotton with a deep nap,or equivalent. If a damp cloth is instructed to use...
Rev 10/8/03 166239002 4 IMI Cornelius Inc; 1994–2003 166239002 Rev. Level 1 F. Rinse the B-I-B disconnects in the sanitizing solution. G. Sanitizing fittings must be attached to each B-I-B disconnect. If these fittings are not available, thefittings from empty B-I-B bags can be cut from the bags and...
Rev 10/8/03 166239002 5 IMI Cornelius Inc; 1994–2003 166239002 Rev. Level 1 DRINK DISPENSER VALVES IMI CORNELIUS INC.MASON CITY IA.DRINK DISPENSERS VALVE TYPE MANUFACTURER PORTION CONTROL MAXIMUM OPERATING PRESSURE CORNELIUS 130 psi LANCER 100psi FLOWMATIC 100psi McCANN 130psi PUSH BUTTON CORNELIUS ...
