Coleman 8350 Series - Manual

5 1 6 1. Grill Hood 2. Thermometer 3. Hood Handle 4. Electronic Igniter: Main and Rear Infrared Burner. 5. Convection Vents 6. Control Knobs: Main Burners 7. Control Knob: Rear Infrared Burner 8. Grilling/Cooking Surface 9. Rear Infrared Burner 10. Warming Shelf Grill Features — 8350 Series NOTE: Se...

1 2 3 5 4 11 9 8 10 14 1. 9992-4131 Hood Assembly w/Logo Plate 2. 9992-4141 Hood Handle Assembly 3. 9992-1111 Temperature Gauge Only 4. 9992-2731 Back IR Cover 5. 9992-1301 Warming Rack 6. 9992-4561 Back IR Burner Assembly NG 7. 9992-4071 Back IR Electrode Assembly 8. 9992-4081 Main Burner Electrode...

7 PLANNING AND DESIGN Start by identifying the number and size of components you want to include in your outdoor cooking center. Countertopsmust be constructed of non-combustible, outdoor-safe materials. Consider outdoor lighting to illuminate after-darkgrilling. For assistance in designing and buil...

8 Note: Make Sure To Use Non-Combustible Material For Construction Additional Requirements: • Access doors required for drip tray removal. Some sort of access panel is required for removal or cleaning of the drip tray.• If using a backsplash apron or rear wall, locate electrical service on the left ...

Natural Gas Installation — 8350 Series NOTE: Your 8350 Series grill is set up from the factory to use NATURAL GAS. If you want to use LP GAS, you must purchase the LP GAS CONVERSION KIT (sold separately). Please skip to thesection titled “ LP Cylinder Conversion - 8350 Series ” . Y OUR N ATURAL GAS ...

10 Grill Assembly — 8350 Series Fig. 4 Igniter Battery Installation 1. The AA battery, spring and igniter cap must be installed beforeusing (Fig. 4). 2. Install the AA battery, negative end first. 3. Slide the spring assembly over the battery. 4. Screw the igniter cap onto the igniter (Fig. 5). Fig....

11 LP GAS CONVERSION KIT (not shown) Part Number Description 9992-258 8350 Series Natural Gas to LP Conversion Kit LP Cylinder Conversion — 8350 Series IMPORTANT! T O ENSURE PROPER GAS FLOW , BURNER CONTROL VALVES MUST BE “OFF” BEFORE OPENING THE GAS CYLINDER VALVE . WARNING: During assembly of the ...

Liquefied Petroleum gas (abbreviated L.P. gas or propane), is highly flammable. It becomes liquid when stored under highpressure inside a cylinder and vaporizes when released. L.P. gasis heavier than air and tends to collect in low areas. It is importantthat there are no leaking connections on your ...

13 CAUTION Have the gas dealer weigh the cylinder after filling to ensurethat the cylinder is not over filled. The pressure regulator and hose assembly with the Type 1 fittingsupplied with the appliance must be used. Do not use anotherhose and regulator assembly other than the one supplied with theg...

15 DANGER T O P REVENT F IRE OR E XPLOSION H AZARD : • NO SMOKING. DO NOT use or permit sources of ignition in the area while doing a leak test. • Perform leak tests outdoors only.• NEVER perform a leak test with fire or flame. Leak Testing • If you detect a leak: 1. Turn off the fuel supply. Push i...

16 1. Regularly check the burner venturi tubes for blockage from an insect nest. Read “Cleaning the Venturi” in the section titled “Care,Maintenance, and Cleaning”, and also the section titled“Troubleshooting”. 2. Check that all the burner venturi [H] are set over the valve outlets [J] correctly. Th...

17 Lighting Main Burners CAUTION Use a LONG wooden match or a butane lighter with an extension. Make sure all burner controls are off except for the burner being lighted. If a long-reach match or lighter is notaccessible, there is a match extension provided. Insert a match in the holder end of theex...

18 Using the Rotisserie — 8350 Series The grill rotisserie system is designed to cook items from the back using infrared heat. The rotisserie burner is aninfrared type which provides intense searing radiant heat. Preferred by chefs over other cooking methods, this intenseheat sears in the natural ju...

19 Lighting the Rotisserie Burner 1. Push and turn on the control knob for the ROTISSERIE BURNER counterclockwise to the “HIGH” position (Fig. 17 and 22). Wait 5 seconds. 2. Press and hold the electronic igniter button (Fig. 23). You will hear a snapping sound.3. If the burner does not light in 4 se...

20 Good Bad Yellow Blue Holes in Burner Yellow Blue Burner Control Setting Tips • The high flame setting is too hot for direct cooking. The high flame setting is good for quick searing of meat, then finishcooking on medium or low flame settings. • Use the high flame setting with the lid closed to pr...

21 Direct Method: • The heat source is directly below the food. • Use for browning meat or cooking hot dogs and hamburgers, but check food frequently. • Use for skillet and stir-fry cooking, but limit the amount of oil and heat to be used. • Cook roasts, turkey or duck on low heat. Place meat with w...

22 REPRESENTATIVE ILLUSTRATION Steps For Cleaning Venturi: 1. Remove the cooking grates and the heat tents and set aside.2. Using a 1/4” hex nut driver, remove the self-tapping screws holding the front heat shield (Fig. 28 and 29). Set the front heat shield aside. 3. Using a 1/4” hex nut driver, rem...

Replacing the Electrode Module Fig. 33 Fig. 34 Fig. 35 Care, Maintenance and Cleaning (continued) Steps For Replacing the Electrode Module: 1. Remove the cooking grates and the heat tents and set aside.2. Using a 1/4” hex nut driver, remove the self-tapping screws holding the front heat shield (Fig....

CAUTION All cleaning and maintenance should be done only when the grill is cool & with the fuel supply turned off at the cylinder.If your grill is set up for use with Natural Gas, turn off thegas supply at the system manual shut off valve. Suggested Cleaning Materials: • Mild dishwashing liquid ...

Please do not send other correspondence to the address belo w. PRODUCT REGISTRA TION DEP AR TMENT PO BO X 2931 WICHIT A ,KS 67201 A TTN: DEPT 586 IMPORTANT! Coleman ¨ Grill Warranty Registration Card COMPLETE THE ATTACHED REGISTRATION CARD AND RETURN WITHIN 10 DAYS TO RECEIVE THESE IMPORTANT BENEFIT...

7) Side burner (if applies) 8) Steamer/Fryer/Warmer (if applies) 9) Side table design 10) Color of the grill (not including stainless steel) 11) Warming racks 12) Dependable igniter 13) Size of the grill (available cooking square inches) 14) Integrated storage cabinet 15) Price16) Rotisserie (if app...

27 TYPE 1 CONNECTION ILLUSTRATION Thermal Sensitive Handwheel 1-5/16" Acme Connection Nipple with Excess Flow Valve Regulator YOUR NEW GAS GRILL IS EQUIPPED WITH ATYPE 1 CONNECTION DEVICE WHICH HAS 3SAFETY FEATURES (FIG. 38): 1. Proof of gas seal between the connector and the cylinder before gas...

The Coleman Company, Inc. • 3600 N. Hydraulic • Wichita, KS 67219 U.S.A. 1-800-356-3612 • TDD: 316-832-8707 9992-032 (12/22/05) © 2005 The Coleman Company, Inc. All rights reserved. Coleman ® and are registered trademarks of The Coleman Company, Inc. Coleman Gas Barbecue Grill 5/1 Year Limited Warra...