Char-Broil 463821908 - Manual

Page 2 - Wash your hands after handling this product.; Indicates an imminently hazardous situation; WARNING; Indicates an potentially hazardous situation; CAUTION; Indicates a potentially hazardous situation or; Model Number; DANGER; National Fuel Gas

2 • 463821908 1. Do not store or use gasoline or other flammable liquids or vapors in the vicinity of this or any other appliance. 2. An LP tank not connected for use shall not er not connected for use shall not be stored in the vicinity of this or any other WARNING CAUTION For residential use only....

Page 3 - TABLE OF CONTENTS; To insure your satisfaction; Do not attempt to repair or alter the

TABLE OF CONTENTS For Your Safety . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 2 Grill Service Center. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 2 Product Record Information . . . . . . . . . . . . . . . . . . . . . . . . . . . . 2 Installatio...

Page 4 - USE AND CARE

• NEVER store a spare LP tank under or near the appliance or in an enclosed area. • Never fill a tank beyond 80% full.• An over filled or improperly stored tank is a hazard due to possible gas release from the safety relief valve. • If you see, smell or hear gas escaping, immediately get away from t...

Page 5 - Connecting Regulator to the LP tank; LP tank Exchange; Continued on next page.

WARNING If “growing” bubbles appear do not use or move the LP tank. Contact an LP gas supplier or your fire department! Connecting Regulator to the LP tank 1. LP tank must be properly secured onto grill. (Refer to assembly section.) 2. Turn all control knobs to the OFF position. 3. Turn LP tank OFF ...

Page 6 - Leak Testing Valves, Hose and Regulator; rushing sound; immediately

6. Turn the coupling nut clockwise and tighten to a full stop. The regulator will seal on the back-check feature in the LP tank valve, resulting in some resistance. An additional one-half to three-quarters turn is required to complete the connection. Tighten by hand only – do not use tools. NOTE: If...

Page 7 - must

For Safe Use of Your Grill and to Avoid Serious Injury:• Do not let children operate or play near grill. • Keep grill area clear and free from materials that burn. • Do not block holes in sides or back of grill. • Check burner flames regularly. • Use grill only in well-ventilated space. NEVER use in...

Page 8 - Troubleshooting Section

CAUTION If ignition does NOT occur in 5 seconds, turn the burner controls OFF, wait 5 minutes and repeat the lighting procedure. If the burner does not ignite with the valve open, gas will continue to flow out of the burner and could accidently ignite with risk of injury. Burner Flame Check • Remove...

Page 9 - Cleaning the Burner Assembly; Turn gas off at control knobs and LP tank.; “Leak Test”; Storing Your Grill; Cleaning the Burner

Cleaning the Burner Assembly Follow these instructions to clean and/or replace parts of burnerassembly or if you have trouble igniting grill.1. Turn gas off at control knobs and LP tank. 2. vaporiser b 3. 4. 5. 6. 7. 8. VERY IMPORTANT: Burner tubes must reengage valve openings. See illustration (A)....

Page 10 - Food Safety; For more information call: USDA Meat and Poultry Hotline at; How To Tell If Meat Is Grilled Thoroughly

Food Safety Food safety is a very important part of enjoying the outdoor cooking experience. To keep food safe from harmful bacteria, follow these four basic steps: Clean: Wash hands, utensils, and surfaces with hot soapy water before and after handling raw meat and poultry. Separate: Separate raw m...

Page 13 - Leg Extenders; hitch pins; Leg Extender

463821908 • 13 2 ASSEMBLY – Model No. 463821908 1 Attach back support brace to legs with (4) #10-24x2" carriage bolts and #10-24 Plastic wing nuts . A Attach right leg assembly to bottom shelf with (2) #10-24x2" carriage bolts and #10-24 Plastic wing nuts . B Push Leg Extenders into the bott...

Page 19 - Push control knobs onto valves.

463821908 • 19 A Insert ends of Swing Away pivot wire into holes in sides of grill lid. Insert ends of Swing Away leg wire into holes in sides of firebox. NOTE: Pivot and leg wires, running side-to-side, should be under wires running front-to-back. If pivot and leg wires are on top Swing Away is ins...

Page 21 - Troubleshooting

EMERGENCIES: If a gas leak cannot be stopped, or a fire occurs due to gas leakage, call the fire department. Emergencies Problem Gas leaking from cracked/cut/burned hose. Gas leaking from LP tank. Gas leaking from LP tank valve. Gas leaking between LP tank and regulator connection. Fire coming throu...

Page 22 - continued

Troubleshooting ( continued ) Problem Burner(s) will not light using ignitor. Burner(s) will notmatch light. Low flame, drop in gas flow. Flames blow out. Flare-up. Persistent grease fire. Flashback...(fire in burner tube(s)). Unable to fill LP tank. Possible Cause PIEZO PUSH-BUTTON AND ROTARY: • Pu...

Page 23 - LIMITED WARRANTY

Manufacturer warrants to the original consumer-purchaser only that this product shall be free from defects in workmanship and materials after correct assembly and under normal and reasonable home use for the periods indicated below beginning on the date of purchase. The manufacturer reserves the rig...

Page 27 - Please register your grill online at:

Please register your grill online at: (If you register online, you do not need to send in this registration card.) WWW.GRILLREGISTRATION.COM Chimenea / Envíelo a: La parrilla estaba ensamblada 463821908 • 27

Page 28 - STOP; Should you encounter a problem with our product; Do not return this product to the store.; WE CAN HELP; GRILL SERVICE CENTER; Grilling Safety Checklist; Read and understand owners manual.; Thank You for Your Purchase!

Char-Broil, LLC Printed in China • Columbus, GA 31902 • STOP Should you encounter a problem with our product CALL US FIRST Do not return this product to the store. WE CAN HELP GRILL SERVICE CENTER 1-800-241-7548 HOURS 8AM-6PM EST Mon-Fri Please ensure your warranty registration is complete. Grilling...

Char-Broil 463821908 - Manual

Table of Contents:

Summary

Other Char-Broil Models