Char-Broil 463722413 - Manual

Page 2 - TABLE OF CONTENTS; Do not store or use gasoline or other; For residential use only. Do not use for commercial; WARNING; DANGER; THIS GRILL IS FOR OUTDOOR USE ONLY.; CAUTION; For residential use only. Do not use for commercial; WARNING

2 TABLE OF CONTENTS For Your Safety . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 2-3 Grilling Guide . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4-7 Use and Care . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 8-13 Lim...

Page 3 - Installation Safety Precautions; Grease Fires

3 WARNING Installation Safety Precautions • Use grill, as purchased, only with LP (propane) gas and the regulator/valve assembly supplied. If your grill is Dual Fuel ready,a conversion kit must be purchased for use with natural gas. • Grill installation must conform with local codes, or in their abs...

Page 4 - GRILLING GUIDE – Getting Started

4 First Time Use Read your Assembly Manual and ensure the grill is put together properly. Remove all Point-of-Purchase advertising material from all grill surfaces before first use. We recommend operating your grill on its highest setting for 15-20 minutes prior to your first use. This aids in remov...

Page 5 - GRILLING GUIDE – Grilling 101

5 Outdoor grilling is really quite simple. You'll succeed with burgers, dogs, or steaks usually on your very first try. With experience, you will learn how to work with your grill, creating more imaginative meals all the time. This knowledge makes up the art of grilling. Before you start grilling, o...

Page 7 - GRILLING GUIDE – Cleaning Your Grill; VISIT CHARBROIL.COM FOR

7 Why Clean? We've all heard the saying 'An ounce of prevention is worth a pound of cure'. This is great advice when it comes to keeping your grill clean. Routine Care Periodic cleaning of this grill is necessary,as grill fires can occur when grease andfood debris collect in the bottom of the grill....

Page 8 - USE AND CARE; LP Cylinder Filling

8 • NEVER store a spare LP cylinder under or near the appliance or in an enclosed area. • Never fill a cylinder beyond 80% full.• An over filled or improperly stored cylinder is a hazard due to possible gas release from the safety relief valve. This could cause an intense fire with risk of property ...

Page 9 - Connecting Regulator to the LP Cylinder; LP Cylinder Exchange; LP Cylinder Leak Test

9 WARNING If “growing” bubbles appear do not use or move the LP cylinder. Contact an LP gas supplier or your fire department! Connecting Regulator to the LP Cylinder 1. LP cylinder must be properly secured onto grill. (Refer to assembly section.) 2. Turn all control knobs to the OFF position. 3. Tur...

Page 10 - Leak Testing Valves, Hose and Regulator

10 6. Turn the coupling nut clockwise and tighten to a full stop. The regulator will seal on the back-check feature in the LP cylinder valve, resulting in some resistance. An additional one-half to three-quarters turn is required to complete the connection. Tighten by hand only – do not use tools. N...

Page 12 - Sideburner Ignitor Lighting

12 CAUTION If burner does not light, turn knobs to OFF, wait 5 minutes, and try again. Always close valve during the 5 minute waiting period. If the burner does not ignite with the valve open, gas will continue to flow out of the burner and could accidentally ignite with risk of injury. Burner Flame...

Page 13 - Cleaning the Burner Assembly; SPIDER AND WEBS

13 • Plated wire grates: Wash grates with concentrated grill cleaner or use soap and water solution. Dry thoroughly and store indoors between cookouts. • Stainless steel surfaces: To maintain your grill’s high quality appearance, wash with mild detergent and warm soapy water and wipe dry with a soft...

Page 14 - LIMITED WARRANTY

14 This warranty only applies to units purchased from an authorized retailer. Manufacturer warrants to the original consumer-purchaser only that this product shall be free from defects in workmanship and materials after correct assembly and under normal and reasonable home use for the periods indica...

Page 15 - PARTS LIST

15 PARTS LIST NOTE: Some grill parts shown in the assembly steps may differ slightly in appearance fromthose on your particular grill model. However, the method of assembly remains the same. Key Qty Description A 1 FIREBOX B 1 IGNITOR C 1 BURNER D 1 COLLECTOR/ ELECTRODE ASSY E 1 LID F 1 LOGO PLATE G...

Page 16 - PARTS DIAGRAM

PARTS DIAGRAM 16 E F SS GG FF H RR W B QQ N OO C D HH KK II JJ V G J K EE X NN A L M Y T T MM MM AA U CC Q P Z BB LL U R S N I O DD TT PP

Page 17 - ASSEMBLY

ASSEMBLY 17 1 Left leg Place upper leg as shown. NOTE: Left front and left back legs do not have leg extenders. In front, attach upper leg, side brace and left front leg (curve) with #10-24x1-1/4’’ machine screw and #10-24 flange nut . In back, attached the left back leg (straight) to upper leg. Att...

Page 28 - Troubleshooting

28 DANGER: If a gas leak cannot be stopped, or a fire occurs due to gas leakage, call the fire department. Emergencies Problem Gas leaking from cracked/cut/burned hose. Gas leaking from LP cylinder. Gas leaking from LP cylinder valve. Gas leaking between LP cylinder and regulator connection. Fire co...

Page 30 - NOTES

Page 32 - THANK YOU; FOR YOUR RECENT; PURCHASE FROM; REGISTER YOUR PRODUCT TO RECEIVE A; SPECIAL OFFER; CHECK OUT THESE; GREAT FEATURES; ON OUR WEBSITE; Valuable product information

THANK YOU FOR YOUR RECENT PURCHASE FROM REGISTER YOUR PRODUCT TO RECEIVE A SPECIAL OFFER CHARBROIL.COM/REGISTER CHECK OUT THESE GREAT FEATURES ON OUR WEBSITE • Valuable product information • Inspiring grilling accessories • Reliable customer support • Delicious recipes and tips from chefs • Exciting...

Char-Broil 463722413 - Manual

Table of Contents:

Summary

Other Char-Broil Models