Page 2 - For residential use only. Do not use for commercial; DANGER; TABLE OF CONTENTS; DANGER; THIS GRILL IS FOR OUTDOOR USE ONLY.; CAUTION
1. Do not store or use gasoline or other flammable liquids or vapors in the vicinity of this or any other appliance. 2. An LP cylinder not connected for use shall not be stored in the vicinity of this or any other appliance. WARNING For residential use only. Do not use for commercial cooking. DANGER...
Page 3 - Wash your hands after handling this product.; National Fuel Gas; over tighten screws and
WARNING CALIFORNIA PROPOSITION 651. Combustion by-products produced when using this product contain chemicals known to the State of California to cause cancer, birth defects, and other reproductive harm. 2. This product contains chemicals, including lead and lead compounds, known to the State of Cal...
Page 4 - Turn on the appropriate control knob and light the grill per the; Pre-Heating Your Grill; GRILLING GUIDE – Getting Started; Regulator
4 First Time Use Read your Assembly Manual and ensure the grill is put together properly. Remove all Point-of-Purchase advertising material from all grill surfaces before first use. We recommend operating your grill on its highest setting for 15-20 minutes prior to your first use. This aids in remov...
Page 5 - GRILLING GUIDE – Grilling 101
5 Outdoor grilling is really quite simple. You'll succeed with burgers, dogs, or steaks usually on your very first try. With experience, you will learn how to work with your grill, creating more imaginative meals all the time. This knowledge makes up the art of grilling. Before you start grilling, o...
Page 7 - GRILLING GUIDE – Cleaning Your Grill; Storing Your Grill
7 Why Clean? We've all heard the saying 'An ounce of prevention is worth a pound of cure'. This is great advice when it comes to keeping your grill clean. Routine Care Periodic cleaning of this grill is necessary,as grill fires can occur when grease andfood debris collect in the bottom of the grill....
Page 8 - USE AND CARE; OPD Hand Wheel; LP Cylinder Filling; LP Cylinder Valve
• NEVER store a spare LP cylinder under or near the appliance or in an enclosed area. • Never fill a cylinder beyond 80% full.• An over filled or improperly stored cylinder is a hazard due to possible gas release from the safety relief valve. This could cause an intense fire with risk of property da...
Page 9 - Connecting Regulator to the LP Cylinder; full stop; Safety Relief Valve; ck; Strap and Cap; LP Cylinder Exchange; Exchange your cylinder only; LP Cylinder Leak Test; Do not use household cleaning agents.
WARNING If “growing” bubbles appear do not use or move the LP cylinder. Contact an LP gas supplier or your fire department! Connecting Regulator to the LP Cylinder 1. LP cylinder must be properly secured onto grill. (Refer to assembly section.) 2. Turn all control knobs to the OFF position. 3. Turn ...
Page 10 - Leak Testing Valves, Hose and Regulator; rushing sound; immediately
6. Turn the coupling nut clockwise and tighten to a full stop. The regulator will seal on the back-check feature in the LP cylinder valve, resulting in some resistance. An additional one-half to three-quarters turn is required to complete the connection. Tighten by hand only – do not use tools. NOTE...
Page 11 - Lighting instructions are continued on the next page; Do not let children operate or play near grill.
Safety Tips s Before opening LP cylinder valve, check the coupling nut for tightness. s When grill is not in use, turn off all control knobs and LP cylinder valve. s Never move grill while in operation or still hot. s Use long-handled barbecue utensils and oven mitts to avoid burns and splatters. s ...
Page 12 - Troubleshooting Section; LOW
Burner Flame Check • Remove cooking grates and flame tamers. Light burners, rotate knobs from HI to LOW . You should see a smaller flame in LOW position than seen on HI . Perform burner flame check on sideburner, also. Always check flame prior to each use. If only low flame is seen refer to "Sud...
Page 13 - Cleaning the Burner Assembly; Turn gas OFF at control knobs and LP cylinder.; Cleaning the Burner; Firebox
Cleaning the Burner Assembly Follow these instructions to clean and/or replace parts of burnerassembly or if you have trouble igniting grill.1. Turn gas OFF at control knobs and LP cylinder. 2. Remove cooking grates and flame tamers. 3. Remove carryover tubes and burners. 4. 5. Carefully lift each b...
Page 14 - ITEMS MANUFACTURER WILL NOT PAY FOR:; of products not approved by the manufacturer.; DISCLAIMER OF IMPLIED WARRANTIES and LIMITATION OF REMEDIES; LIMITED WARRANTY; SCOPE OF COVERAGE
This warranty only applies to units purchased from an authorized retailer. Manufacturer warrants to the original consumer-purchaser only that this product shall be free from defects in workmanship and materials after correct assembly and under normal and reasonable home use for the periods indicated...
Page 15 - PARTS LIST; Key
PARTS LIST NOTE: Some grill parts shown in the assembly steps may differ slightly in appearance fromthose on your particular grill model. However, the method of assembly remains the same. 15 Key Qty Description A 1 FIREBOX, GRILL BOTTOM B 4 MAIN BURNER C 1 ELECTRODE, MAIN BURNER D 3 BURNER CARRY OVE...
Page 17 - ASSEMBLY; Attach side panels to bottom shelf using three; mm lock washer; Rear; Place bottom shelf upside down. Insert; Caster
Locking caster Bottom shelf Fixed caster Rear Front ASSEMBLY 2 1 17 2 1/4-20x1/2” screw Attach side panels to bottom shelf using three 1/4-20x1/2” screws, 7mm lock washers, and 7mm flat washers per panel. IMPORTANT: Panel with large hole mustBe on left side of bottom shelf. 7mm lock washer 7mm flat ...
Page 18 - Attach rear cart brace to cart frames using two #; lock washers and; mm; flat washers on each side.; mm lock washers; and; mm flat washers
4 3 Attach rear cart brace to cart frames using two # 8 - 32 x1/2 ” screws, 4 mm lock washers and 4 mm flat washers on each side. 18 3 3 Attach front brace to side panels using two #10-24X1/2” screws , 5mm lock washers and 5mm flat washers on each side. Magnet 5mm flat washers 5mm lock washers #10-2...
Page 19 - nuts; Two; Secure right door with four; machine screws
5 6 Insert wire ends on lower tank exclusion wire into bottom shelf (A) . Attach with two #8-32x3/8" screws diagonally. Place upper tank exclusion wire on front brace and back brace as shown, secure with two #8-32x3/8" screws and #8-32 flange nuts (B) . Front brace #8-32x3/8" screw #8-32...
Page 20 - SHARP EDGES! Wear gloves if necessary; Side s; Mount fascia onto side shelf using three; Carefully lower the grill head onto the cart.; Make sure the; Insert
C CAUTION SHARP EDGES! Wear gloves if necessary Repeat on front bracket 1/4-20x1/2" screw 1/4-20 flange nut Fiber washer Lock washer Flat washer #10-24x1/2" screw Repeat on left side shelf Flat washer Lock washer 1/4-20x1/2" screw Side s helf Hoo k side shelf into inside edge Mount fasci...
Page 21 - mm fiber; mm Fiber
21 Repeat step 7 (A) on left side shelf. Hang sideburner shelf on tabs mounted on the firebox. Secure shelf brackets to cart side panel using two 1/4-20x1/2" screws , fiber washers and 1/4-20 flange nuts on each bracket (A) . Secure fascia to firebox using two 1/4-20x1/2" screws , 7mm lock w...
Page 22 - Burner tube; Valve
11 12 22 Remove two #8-32x3/8" screws from sideburner valve bracket. From behind the fascia, place sideburner valve bracket into hole. Attach bezel to valve with #8-32x3/8" screws. Press sideburner control knob onto valve stem. Control knob Control knob bezel Sideburner valve bracket Insert ...
Page 23 - Place sideburner cooking grate into holes in drip pan.
23 Sideburner grate Place sideburner cooking grate into holes in drip pan. Place four flame tamers over burners by inserting tabs into slots in front of firebox. Opposite ends of flame tamers rest on pins in back of firebox. Flame tamer Back of firebox Flame t amer Front of firebox
Page 24 - Place cooking grates into grill bottom.; Cooking Grates
24 Place cooking grates into grill bottom. Cooking Grates To assemble Swing Away, first insert pivot wire into holes in side of grill lid. Second, insert leg wires into holes in sides of grill bottom. Pivot wire Swing Away Leg wire
Page 25 - AA Battery
17 25 Hang grease cup wire from bottom of firebox and place grease cup into grease cup clip. Failure to install grease cup will cause hot grease to drip from bottom of grill with risk of fire or property damage. CAUTION Unscrew ignitor cap and place AA battery into ignitor slot with positive end (+)...
Page 26 - LP tank is sold separately.; using; Cylinder valve must face to front of cart once; Tank screw; LP Cylinder
19 LP tank is sold separately. Fill and leak check the tank (see Use & Care section) before attaching to grill and regulator. Once tank has been filled and leak checked, place tank into tank hole in bottom shelf. Make sure tank valve is facing front of grill. Put regulator assembly through circu...
Page 27 - Troubleshooting
DANGER: If a gas leak cannot be stopped, or a fire occurs due to gas leakage, call the fire department. Emergencies Problem Gas leaking from cracked/cut/burned hose. Gas leaking from LP cylinder. Gas leaking from LP cylinder valve. Gas leaking between LP cylinder and regulator connection. Fire comin...
Page 28 - continued; Problem
Troubleshooting ( continued ) Problem Burner(s) will not light using ignitor.(See Electronic Ignition Troubleshooting also) Burner(s) will notmatch light. Sudden drop in gasflow or low flame. Flames blow out. Flare-up. Persistent grease fire. Flashback...(fire in burner tube(s)). Unable to fill LP c...
Page 29 - Troubleshooting - Electronic Ignition; SECTION I
Troubleshooting - Electronic Ignition Problem (Ignition) SECTION I No sparks appear at any electrodes when Electronic Ignition Button is pressed; no noise can be heard from spark module. SECTION II SECTION III Sparks are present but not at all electrodes and/or not at full strength Possible Cause • ...
Page 30 - NOTES
Page 31 - Attach copy of your; STICKER ON PRODUCT; Please register your product online at:
31 First Name | Nombre | Prénom Initial | Inicial | Initiale Last Name | Apellido | Nom de Famillie Address (number & street) | Dirección (número y calle) | Adresse (numéro et rue) Apt Number | Nº de apart | Nº d’appt. City | Cludad | Ville State | Estado | Province Zip Code | Código Zip | Code ...
