Char-Broil 463460708 - Manual

WARNING If “growing” bubbles appear do not use or move the LP cylinder. Contact an LP gas supplier or your fire department! Connecting Regulator to the LP Cylinder 1. LP cylinder must be properly secured onto grill. (Refer to assembly section.) 2. Turn all control knobs to the OFF position. 3. Turn ...

6. Turn the coupling nut clockwise and tighten to a full stop. The regulator will seal on the back-check feature in the LP cylinder valve, resulting in some resistance. An additional one-half to three-quarters turn is required to complete the connection. Tighten by hand only – do not use tools. NOTE...

WARNING For Safe Use of Your Grill and to Avoid Serious Injury:• Do not let children operate or play near grill. • Keep grill area clear and free from materials that burn. • Do not block holes in sides or back of grill. • Check burner flames regularly. • Use grill only in well-ventilated space. NEVE...

Burner Flame Check • Remove cooking grates and flame tamers. Light burners, rotate knobs from HIGH to LOW. You should see a smaller flame in LOW position than seen on HIGH. Perform burner flame check on sideburner, also. Always check flame prior to each use. If only low flame is seen refer to "S...

Cleaning the Burner Assembly Follow these instructions to clean and/or replace parts of burnerassembly or if you have trouble igniting grill.1. Turn gas off at control knobs and LP cylinder. 2. Remove cooking grates and flame tamers. 3. Remove screws and carryover tubes from rear of burners. 4. Remo...

Indirect Cooking Poultry and large cuts of meat cook slowly to perfection on the grill by indirect heat. The heat from selected burners circulates gently throughout the grill, cooking meat or poultry without the touch of a direct flame. This method greatly reduces flare-ups when cooking extra fatty ...

463460708 • 11 CARE AND CLEANING OF YOUR STAINLESS STEEL GRILL Routine cleaning is necessary to preserve the appearance and corrosion resistance of Stainless Steel. The perception that many people have is that stainless steel will not rust. That is not the case in certain conditions. Rust marks are ...

14 • 463460708 ASSEMBLY – Model No. 463460708 1 Attach the two locking casters at the rear of the bottom shelf and the two non-locking casters at the front . Use the provided caster wrench to fully tighten casters. Locking caster Bottom shelf Non-locking caster Rear Front 2 1/4-20x1/2” screw Attach ...

4 3 463460708 • 15 Insert wire ends on tank exclusion shelf into bottom shelf (A) . Attach with two #8-32x3/8" screws diagonally. Tighten two #8- 32x3/8" screws at the back of tank exclusion wire first (B) . Line up the front of tank exclusion wire to holes in top brace and secure with two #...

16 • 463460708 5 6 Two #8-32x3/8" machine screws are installed partially in the cart side panel. Slide door hinges onto the screws as shown. Secure right door with four #8-32x3/8" machine screws . Repeat assembly for left door. #8-32x3/8" machine screw This step requires two people to li...

9 Place drip pan onto sideburner shelf. Secure with #10-24x 1/2" screws, insulation washers , 5mm flat washers, 5mm lock washers , #10-24 hex nuts, #10-24x 1/2” screws, 5mm lock washers, 5mm flat washers and side burner lid supports. 18 • 463460708 10 Remove two #8-32x3/8" screws from sidebu...

12 463460708 • 19 11 Insert sideburner into sideburner drip pan (A) , make sure burner tube engages with sideburner valve. Illustration (B) shows correct burner-to-valve engagement. Center stud on bottom of sideburner fits into center hole in sideburner drip pan. Secure with one wingnut (C) . Connec...

20 • 463460708 13 Place four flame tamers over burners by inserting tabs into slots in front of firebox. Opposite ends of flame tamers rest on pins in back of firebox. Flame tam er Back of fire box Fla me ta mer Front of fire box 14 Place cooking grates into grill bottom. Cooking Grates

463460708 • 21 To assemble Swing Away, first insert pivot wire into holes in side of grill lid. Second, insert leg wires into holes in sides of grill bottom. 15 Pivot wire Swing Away Leg wire Hang grease cup wire from bottom of firebox and place grease cup into grease cup clip. Failure to install gr...

17 Unscrew ignitor cap and place AA battery into ignitor slot with positive end (+) facing outward. Screw ignitor cap onto ignitor. + – AA Battery Tank screw LP tank is sold separately. Fill and leak check the tank (see Use & Care section) before attaching to grill and regulator. Once tank has b...

EMERGENCIES: If a gas leak cannot be stopped, or a fire occurs due to gas leakage, call the fire department. Emergencies Problem Gas leaking from cracked/cut/burned hose. Gas leaking from LP cylinder. Gas leaking from LP cylinder valve. Gas leaking between LP cylinder and regulator connection. Fire ...

Troubleshooting ( continued ) Problem Burner(s) will not light using ignitor.(See Electronic Ignition Troubleshooting also) Burner(s) will notmatch light. Sudden drop in gasflow or low flame. Flames blow out. Flare-up. Persistent grease fire. Flashback...(fire in burner tube(s)). Unable to fill LP c...

Troubleshooting - Electronic Ignition Problem (Ignition) SECTION I No sparks appear at any electrodes when ignition button is pushed; no noise can be heard from spark module. SECTION II No sparks appear at any electrodes when ignition switch is pushed; noise can be heard from spark module. SECTION I...

26 • 463460708 Manufacturer warrants to the original consumer-purchaser only that this product shall be free from defects in workmanship and materials after correct assembly and under normal and reasonable home use for the periods indicated below beginning on the date of purchase. The manufacturer r...

Mail to: / Envíelo a:Consumer Warranty ServiceP. O. Box 1240Columbus, GA 31902-1240 Thank you for completing this questionnaire. Your answers will help us and other companies reach you with offers that may interest you. If you prefer not to receive these offers, please check here .Gracias por comple...

STOP Should you encounter a problem with our product CALL US FIRST Do not return this product to the store. WE CAN HELP GRILL SERVICE CENTER 1-800-241-7548 HOURS 8AM-6PM EST Mon-Fri Please ensure your warranty registration is complete. Grilling Safety Checklist Read and understand owners manual. Nev...