Char-Broil 463262911 - Manual

Page 2 - DANGER; TABLE OF CONTENTS; DANGER; THIS GRILL IS FOR OUTDOOR USE ONLY.

1. Do not store or use gasoline or other flammable liquids or vapors in the vicinity of this or any other appliance. 2. An LP cylinder not connected for use shall not be stored in the vicinity of this or any other appliance. WARNING CAUTION For residential use only. Do not use for commercial cooking...

Page 3 - Wash your hands after handling this product.; National Fuel Gas

WARNING CALIFORNIA PROPOSITION 651. Combustion by-products produced when using this product contain chemicals known to the State of California to cause cancer, birth defects, and other reproductive harm. 2. This product contains chemicals, including lead and lead compounds, known to the State of Cal...

Page 4 - USE AND CARE; OPD Hand Wheel; LP Cylinder Filling; LP Cylinder Valve

• NEVER store a spare LP cylinder under or near the appliance or in an enclosed area. • Never fill a cylinder beyond 80% full.• An over filled or improperly stored cylinder is a hazard due to possible gas release from the safety relief valve. This could cause an intense fire with risk of property da...

Page 5 - Connecting Regulator to the LP Cylinder; full stop; Safety Relief Valve; ck; Strap and Cap; LP Cylinder Exchange; Exchange your cylinder only; LP Cylinder Leak Test; Do not use household cleaning agents.

WARNING If “growing” bubbles appear do not use or move the LP cylinder. Contact an LP gas supplier or your fire department! Connecting Regulator to the LP Cylinder 1. LP cylinder must be properly secured onto grill. (Refer to assembly section.) 2. Turn all control knobs to the OFF position. 3. Turn ...

Page 6 - Leak Testing Valves, Hose and Regulator; rushing sound; immediately

6. Turn the coupling nut clockwise and tighten to a full stop. The regulator will seal on the back-check feature in the LP cylinder valve, resulting in some resistance. An additional one-half to three-quarters turn is required to complete the connection. Tighten by hand only – do not use tools. NOTE...

Page 7 - Do not let children operate or play near grill.; CAUTION; Lighting instructions are continued on the next page

WARNING For Safe Use of Your Grill and to Avoid Serious Injury:• Do not let children operate or play near grill. • Keep grill area clear and free from materials that burn. • Do not block holes in sides or back of grill. • Check burner flames regularly. • Use grill only in well-ventilated space. NEVE...

Page 8 - Troubleshooting Section; LOW

Burner Flame Check • Remove cooking grates and flame tamers. Light burners, rotate knobs from HI to LOW . You should see a smaller flame in LOW position than seen on HI . Perform burner flame check on sideburner, also. Always check flame prior to each use. If only low flame is seen refer to "Sud...

Page 9 - Cleaning the Burner Assembly; Turn gas OFF at control knobs and LP cylinder.; Storing Your Grill; Cleaning the Burner; Firebox

Cleaning the Burner Assembly Follow these instructions to clean and/or replace parts of burnerassembly or if you have trouble igniting grill.1. Turn gas OFF at control knobs and LP cylinder. 2. Remove cooking grates and flame tamers. 3. Remove carryover tubes and burners. 4. 5. Carefully lift each b...

Page 10 - Grill Halogen Light; LIGHT OPERATION INSTRUCTIONS; Bulb Replacement; Bulb Specification; Wattage: 10 W per bulb; Light plug

Grill Halogen Light LIGHT OPERATION INSTRUCTIONS Bulb Replacement 1. Make sure light switch on the control panel is in the “OFF” position. 2. Connect light plug to an extension cord, then put the extension cord plug into the outlet on the wall. 3. Turn the light switch to “ON”. ON OFF WARNING Keep a...

Page 11 - Cleaning the Lens; Prior to cleaning, make sure the light switch is in the “; OFF; ” position and the light plug is; Never remove the grounding plug or use with an adapter of 2 prongs.

WARNING IMPORTANT 1. To protect against electric shock, do not immerse cord or plugs in water or other liquid. Cleaning the Lens 1. Prior to cleaning, make sure the light switch is in the “ OFF ” position and the light plug is disconnected from the power supply. 2. Do not clean the glass lens when w...

Page 12 - ITEMS MANUFACTURER WILL NOT PAY FOR:; of products not approved by the manufacturer.; DISCLAIMER OF IMPLIED WARRANTIES and LIMITATION OF REMEDIES; LIMITED WARRANTY; SCOPE OF COVERAGE

This warranty only applies to units purchased from an authorized retailer. Manufacturer warrants to the original consumer-purchaser only that this product shall be free from defects in workmanship and materials after correct assembly and under normal and reasonable home use for the periods indicated...

Page 13 - PARTS LIST; Key; NOT Pictured

PARTS LIST NOTE: Some grill parts shown in the assembly steps may differ slightly in appearance from those on your particular grill model. However, the method of assembly remains the same. 13 Key Qty Description A 1 TOP LID, OUTER B 1 INNER INSERT F/ TOP LID C 1 HANDLE F/ TOP LID D 1 LOGO PLATE E 2 ...

Page 14 - PARTS DIAGRAM

PARTS DIAGRAM 14 A B C G K M O N M N Q FF R S V T Y TT UU CC II JJ KK LL U Z DD EE AA BB GG HH X W MM NN NN MM W P K G D H OO I J L QQ SS RR F E PP

Page 15 - lock washers and 7mm flat washers on each side.

15 1 2 Attach right side fascia to right side shelf using two #10x3/8” screws, 5mm lock washers and 5mm flat washers, shown A. On back of grill, place lower back panel between side panels. Secure lower back panel using two 1/4-20x1/2” screws, 7mm lock washers and 7mm flat washers on each side. Right...

Page 16 - Pull foldable side shelf outward and press it down, shown C.; Foldable side shelf

3 A B C 16 Attach foldable side shelf brackets to the tracks under right side shelf using one shoulder screw, 7mm flat washer, 7mm lock washer and 1/4” nut each side, shown A/B. Pull foldable side shelf outward and press it down, shown C. Push foldable side shelf toward right side shelf untill they ...

Page 17 - Attach rear of shelf using one 1/4-20x11⁄2”; screw; Flange into bracket; Bracket

4 17 Insert flange on right side shelf into side shelf brackets on side of firebox, shown A. Attach rear of shelf using one 1/4-20x1½” screw, 7mm lock washer, 7mm flat washer, fiber washer and 1/4” nut, shown D/E. Attach right side shelf using two 1/4-20x3/4” screws, 7mm flat washers, 7mm lock washe...

Page 18 - Flame tamers; Cooking grate; Warming rack

18 Install flame tamers by sliding one end of each flame tamer into slots at front of firebox and resting opposite end on pins in back of firebox. Back of firebox Front of firebox Flame tamers Pin 5 6 Place cooking grates onto the firebox, shown A. Insert the two wire ends at rear of warming rack in...

Page 19 - Cylinder screw at rear of cart; Cylinder screw; Regulator; LP Cylinder

– 19 7 LP CYLINDER IS SOLD SEPARATELY. Fill and leak check the cylinder before attaching to grill and regulator (see Use & Care section). Once cylinder has been filled and leak checked, place cylinder into hole in bottom shelf. Make sure cylinder valve is facing front of grill. Secure cylinder w...

Page 20 - Troubleshooting

EMERGENCIES: If a gas leak cannot be stopped, or a fire occurs due to gas leakage, call the fire department. Emergencies Problem Gas leaking from cracked/cut/burned hose. Gas leaking from LP cylinder. Gas leaking from LP cylinder valve. Gas leaking between LP cylinder and regulator connection. Fire ...

Page 21 - continued; Problem

Troubleshooting ( continued ) Problem Burner(s) will not light using ignitor.(See Electronic Ignition Troubleshooting also) Burner(s) will notmatch light. Sudden drop in gasflow or low flame. Flames blow out. Flare-up. Persistent grease fire. Flashback...(fire in burner tube(s)). Unable to fill LP c...

Page 22 - Troubleshooting - Electronic Ignition; SECTION I

Troubleshooting - Electronic Ignition Problem (Ignition) SECTION I No sparks appear at any electrodes when Electronic Ignition Button is pressed; no noise can be heard from spark module. SECTION II SECTION III Sparks are present but not at all electrodes and/or not at full strength Possible Cause • ...

Char-Broil 463262911 - Manual

Table of Contents:

Summary

Other Char-Broil Models