Page 2 - For residential use only. Do not use for commercial; DANGER; TABLE OF CONTENTS; DANGER; THIS GRILL IS FOR OUTDOOR USE ONLY.; CAUTION
1. Do not store or use gasoline or other flammable liquids or vapors in the vicinity of this or any other appliance. 2. An LP cylinder not connected for use shall not be stored in the vicinity of this or any other appliance. WARNING For residential use only. Do not use for commercial cooking. DANGER...
Page 3 - Wash your hands after handling this product.; National Fuel Gas; over tighten screws and
WARNING CALIFORNIA PROPOSITION 651. Combustion by-products produced when using this product contain chemicals known to the State of California to cause cancer, birth defects, and other reproductive harm. 2. This product contains chemicals, including lead and lead compounds, known to the State of Cal...
Page 4 - USE AND CARE; OPD Hand Wheel; LP Cylinder Filling; LP Cylinder Valve
• NEVER store a spare LP cylinder under or near the appliance or in an enclosed area. • Never fill a cylinder beyond 80% full.• An over filled or improperly stored cylinder is a hazard due to possible gas release from the safety relief valve. This could cause an intense fire with risk of property da...
Page 5 - Connecting Regulator to the LP Cylinder; full stop; Safety Relief Valve; ck; Strap and Cap; LP Cylinder Exchange; Exchange your cylinder only; LP Cylinder Leak Test; Do not use household cleaning agents.
WARNING If “growing” bubbles appear do not use or move the LP cylinder. Contact an LP gas supplier or your fire department! Connecting Regulator to the LP Cylinder 1. LP cylinder must be properly secured onto grill. (Refer to assembly section.) 2. Turn all control knobs to the OFF position. 3. Turn ...
Page 6 - Leak Testing Valves, Hose and Regulator; rushing sound; immediately
6. Turn the coupling nut clockwise and tighten to a full stop. The regulator will seal on the back-check feature in the LP cylinder valve, resulting in some resistance. An additional one-half to three-quarters turn is required to complete the connection. Tighten by hand only – do not use tools. NOTE...
Page 7 - Lighting instructions continued on next page.; Do not let children operate or play near grill.
Safety Tips Before opening LP cylinder valve, check the coupling nut for tightness. When grill is not in use, turn off all control knobs and LP cylinder valve. Never move grill while in operation or still hot. Use long-handled barbecue utensils and oven mitts to avoid burns and splatters. ...
Page 8 - Troubleshooting Section
Ignitor Check •Turn gas off at LP cylinder. Press and hold electronic ignitor button. "Click" should be heard and spark seen each time between each collector box or burner and electrode. See "Troubleshooting" if no click or spark. Valve Check •Important: Make sure gas is off at LP cy...
Page 9 - Cleaning the Burner; Cleaning the Burner Assembly; VERY IMPORTANT: Burner tubes must reengage valve; Turn gas OFF at control knobs and LP cylinder.; Firebox; Carryover tube; Firebox burner; Storing Your Grill
CAUTION •Clean cooking grates.•Store in dry location.•When LP cylinder is connected to grill, store outdoors in a well- ventilated space and out of reach of children. •Cover grill if stored outdoors. Choose from a variety of grill covers offered by manufacturer. •Store grill indoors ONLY if LP cylin...
Page 10 - ITEMS MANUFACTURER WILL NOT PAY FOR:; of products not approved by the manufacturer.; DISCLAIMER OF IMPLIED WARRANTIES and LIMITATION OF REMEDIES; LIMITED WARRANTY; SCOPE OF COVERAGE
This warranty only applies to units purchased from an authorized retailer. Manufacturer warrants to the original consumer-purchaser only that this product shall be free from defects in workmanship and materials after correct assembly and under normal and reasonable home use for the periods indicated...
Page 11 - PARTS LIST; Key Qty; Key Qty Description
PARTS LIST NOTE: Some grill parts shown in the assembly steps may differ slightly in appearance from those on your particular grill model. However, the method of assembly remains the same. 11 Key Qty Description A 1 TOP LID B 1 HANDLE, F/ TOP LID C 2 END CAPS, F/ HANDLE D 1 LOGO PLATE, W / TEMP GAUG...
Page 12 - PARTS DIAGRAM
PARTS DIAGRAM 12 H I P Q R S UU AA BB BB U FF PP II G GG SS NN OO HH V W TT T DD QQ QQ RR RR CC R Q J K L L J M Z M J LL LL MM LL N EE X JJ KK O Y D F B C C E G A
Page 13 - ASSEMBLY; Attach side panels to bottom shelf using three; IMPORTANT: Panel with large hole must; Locking caster; Rear
13 ASSEMBLY 2 1/4-20x1/2” screw 1 Attach side panels to bottom shelf using three 1/4-20x1/2” screws per panel. IMPORTANT: Panel with large hole must be on right side of bottom shelf. Left side panel Door magnet (with large hole) Make sure side panels are pushed as far to the rear of bottom shelf as ...
Page 14 - regulator hose is hanging outside; Lower back panel
14 3 4 This step requires two people to lift and position grill head onto cart. Carefully lower the grill head onto the cart, aligning slots at bottom of grill head with posts on cart side panels. Make sure the regulator hose is hanging outside the cart. Grill head must face open side of cart. Place...
Page 15 - for clarity of illustration; Upper back panel; fiber
15 6 On back of grill, place upper back panel between side panels and above lower back panel. Secure upper back panel in lower holes using one 1/4-20x1½” screw and fiber washer on each side. Do not fully tighten screws until side shelf installation is complete in later steps. 1/4-20x1½” screw fiber ...
Page 16 - screw
16 7 Attach right side fascia to right side shelf using four #10-24x3/8” screws, 5mm lock washers and 5mm flat washers, shown A . D E #10-24x3/8” Screw 5mm Lock Washer 5mm Flat Washer right side fascia A Insert flange on right side shelf into side shelf brackets on right side of firebox, shown B . s...
Page 17 - left side shelf; left side fascia
8 17 left side shelf Attach left side fascia to left side shelf using four #10-24x3/8” screws, 5mm lock washers and 5mm flat washers, shown A . Insert flange on left side shelf into side shelf brackets on side of firebox, shown B . side shelf bracket B #10-24x3/8” screw 5mm flat Washer left side fas...
Page 18 - screws and; Note: Use left and right holes
9 18 Position sideburner valve bracket beneath sideburner shelf fascia so that valve stem comes through larger center hole in fascia. Align the holes on valve bracket with left and right holes on fascia. Secure using screws and lock washers that were removed from bracket, shown A . Attach sideburner...
Page 19 - Wing nut
10 19 Insert sideburner into left shelf. The stud on bottom of the burner fits into the rear small hole in sideburner drip pan, shown A . Under sideburner shelf, attach sideburner ignitor wire to electrode. Make sure burner tube engages sideburner valve, shown B . Secure burner to sideburner drip pa...
Page 20 - Insert AA battery into ignition module, negative (; Nut; Front brace; Tank heat shield
11 20 12 Inside of cart, insert rear tabs(w/o holes) of tank heat shield into slots on the bottom of upper back panel, shown A . Attach front tabs(w/holes) of tank heat shield under front brace using two #8x3/8” self-tapping screws, shown B . Connect each of the wires from the main burner electrodes...
Page 21 - Trough
13 21 Insert the pin on bottom of doors into hole in bottom shelf. Press upper hinge pin in front brace, align hinge hole on top of door, and release hinge pin into door. pin on bottom of door Top of door PRESS 14 Left door Trough pin Trough Right door Place trough into fire box. Align pins at front...
Page 22 - onto the the firebox. Make sure insert the; Warming Rack; ends into the holes properly as shown.; LP TANK IS SOLD SEPARATELY.; Tank Screw at rear of cart; LP Tank valve must face to front of cart once; Always keep LP tank in upright position during use,; Assembled
15 22 Place cooking grates onto the firebox as shown. Place the Warming Rack onto the the firebox. Make sure insert the Warming Rack ends into the holes properly as shown. Cooking grate Warming Rack Regulator 16 LP TANK IS SOLD SEPARATELY. Fill and leak check the tank before attaching to grill and r...
Page 23 - Main Burner Conversion; reference only. Not all steps will apply to your grill conversion.
23 1 Main Burner Conversion Your grill may differ from illustration shown. This portion of the manual covers a variety of grill styles. Use pictures as reference only. Not all steps will apply to your grill conversion. Make sure all Control Knobs are in the OFF position, LP Tank Valve is closed, Tan...
Page 24 - Pull the Burner Control Knobs off of Valve Stems.; Tube Burner
24 4 Bezels Valve Stem Screws Port holesdownward Main Burner Control Knobs Natural Gas Bezel 80007893 Pull the Burner Control Knobs off of Valve Stems. Remove Screws and Washers that secure each Bezel to the Control Panel. Save removed Bezels for converting back to LP Tank Gas. Install new Natural G...
Page 25 - Sideburner Conversion
25 6 7 Open Sideburner lid and remove the Sideburner Grate. Beneath Sideburner shelf, remove Wingnut. Remove Sideburner from shelf. Wingnut Sideburner Grate Orifice Removal Tool Using the provided Orifice Removal Tool, unscrew the Orifice from the end of the Sideburner Valve. Save removed Orifice an...
Page 26 - Secure Burner to shelf with Wingnut. Reference illustration 6.
26 8 9 Pull the Sideburner Control Knob off of Valve Stem. Remove the existing Bezel by removing the two Screws and Washers securing Bezel to shelf fascia. Save removed Bezel for converting back to LP Tank Gas. Install new natural gas Bezel (see illustration below) and press Control Knob back onto V...
Page 27 - Outdoor Stove & Griddle Conversion
27 11 Using the provided Orifice Removal Tool, unscrew the Orifice from the end of the Sideburner Valve. Save removed Orifice and Orifice Removal Tool for converting back to LP Tank Gas. No replacement Orifice is required. 10 Open Sideburner lid and remove the Sideburner Gate. Beneath Sideburner she...
Page 28 - Natural Gas Bezel
12 13 Pull the Sideburner Control Knob off of Valve Stem. Remove the existing Bezel by removing the two Screws and Washers securing Bezel to shelf fascia. Save removed Bezel for converting back to LP Tank Gas. Install new natural gas Bezel (see illustration below) and press Control Knob back onto Va...
Page 29 - Natural Gas Hose Conversion; Connection for converting back to LP Tank Gas.; Your Grill may differ from illustration shown.
14 Natural Gas Hose Conversion Using a wrench, not provided, remove LP Regulator Hose Assembly from Manifold Connection. Save removed LP Manifold Connection for converting back to LP Tank Gas. Your Grill may differ from illustration shown. LP Regulator Hose Assembly Manifold Connection Natural Gas H...
Page 30 - Connecting Your Grill to the Natural Gas Source.; Figure A; connected hose and socket.
Connecting Your Grill to the Natural Gas Source. 1. A professionally-installed shut-off valve between the supply piping and the socket is recommended, but not required, by the National Fuel Gas Code. Socket connection must be made outdoors. 2. Coat the gas supply pipe nipple with gas resistant pipe ...
Page 31 - Troubleshooting
DANGER: If a gas leak cannot be stopped, or a fire occurs due to gas leakage, call the fire department. Emergencies Problem Gas leaking from cracked/cut/burned hose. Gas leaking from LP cylinder. Gas leaking from LP cylinder valve. Gas leaking between LP cylinder and regulator connection. Fire comin...
Page 32 - continued; Problem
Troubleshooting ( continued ) Problem Burner(s) will not light using ignitor.(See Electronic Ignition Troubleshooting also) Burner(s) will notmatch light. Sudden drop in gasflow or low flame. Flames blow out. Flare-up. Persistent grease fire. Flashback...(fire in burner tube(s)). Unable to fill LP c...
Page 33 - Troubleshooting - Electronic Ignition; SECTION I
Troubleshooting - Electronic Ignition Problem (Ignition) SECTION I No sparks appear at any electrodes when Electronic Ignition Button is pressed; no noise can be heard from spark module. SECTION II SECTION III Sparks are present but not at all electrodes and/or not at full strength Possible Cause • ...
Page 34 - NOTES
Page 35 - Attach copy of your; STICKER ON PRODUCT; Please register your product online at:
35 First Name | Nombre | Prénom Initial | Inicial | Initiale Last Name | Apellido | Nom de Famillie Address (number & street) | Dirección (número y calle) | Adresse (numéro et rue) Apt Number | Nº de apart | Nº d’appt. City | Cludad | Ville State | Estado | Province Zip Code | Código Zip | Code ...
