Char-Broil 463250308 - Manual

Page 2 - Call Grill Service Center for Help and Parts; Model Number; DANGER; Wash your hands after handling this product.; National Fuel Gas; DANGER; Safety Symbols; Indicates an imminently hazardous situation; WARNING; Indicates an potentially hazardous situation; CAUTION; Indicates a potentially hazardous situation or

1. Do not store or use gasoline or other flammable liquids or vapors in the vicinity of this or any other appliance. 2. An LP cylinder not connected for use shall not be stored in the vicinity of this or any other appliance. WARNING CAUTION For residential use only. Do not use for commercial cooking...

Page 3 - TABLE OF CONTENTS; To insure your satisfaction

463250308 • 3 TABLE OF CONTENTS For Your Safety...................................................2 Grill Service Center............................................2 Product Record Information...............................2 Installation Safety Precautions..........................2 Safety Symbols.....

Page 4 - USE AND CARE; OPD Hand Wheel

• NEVER store a spare LP cylinder under or near the appliance or in an enclosed area. • Never fill a cylinder beyond 80% full.• An over filled or improperly stored cylinder is a hazard due to possible gas release from the safety relief valve. • If you see, smell or hear gas escaping, immediately get...

Page 5 - Connecting Regulator to the LP Cylinder; full stop; Safety Relief Valve; Strap and Cap; LP Cylinder Exchange; Exchange your cylinder only; LP Cylinder Leak Test; For your safety

WARNING If “growing” bubbles appear do not use or move the LP cylinder. Contact an LP gas supplier or your fire department! Connecting Regulator to the LP Cylinder 1. LP cylinder must be properly secured onto grill. (Refer to assembly section.) 2. Turn all control knobs to the OFF position. 3. Turn ...

Page 6 - Leak Testing Valves, Hose and Regulator; rushing sound; immediately; Never remove threaded

6. Turn the coupling nut clockwise and tighten to a full stop. The regulator will seal on the back-check feature in the LP cylinder valve, resulting in some resistance. An additional one-half to three-quarters turn is required to complete the connection. Tighten by hand only – do not use tools. NOTE...

Page 7 - Do not let children operate or play near grill.

WARNING For Safe Use of Your Grill and to Avoid Serious Injury:• Do not let children operate or play near grill. • Keep grill area clear and free from materials that burn. • Do not block holes in sides or back of grill. • Check burner flames regularly. • Use grill only in well-ventilated space. NEVE...

Page 8 - Troubleshooting Section

Burner Flame Check •Remove cooking grates and troughs. Light burners, rotate knobs from to . You should see a bigger flame in position than seen on . Perform burner flame check on side burner, also. Always check flame prior to each use. If only low flame is seen refer to "Sudden drop or low flam...

Page 9 - Electrode; Burner; Cleaning the Burner Assembly; Turn gas off at control knobs and LP cylinder.; Storing Your Grill; Cleaning the Burner

463250308 • 9 Electrode Burner Cleaning the Burner Assembly Follow these instructions to clean and/or replace parts of burnerassembly or if you have trouble igniting grill.1. Turn gas off at control knobs and LP cylinder. 2. Remove cooking grates and flame tamers. 3. Remove screws and carryover tube...

Page 10 - Food Safety; Wash hands, utensils, and surfaces with hot

Food Safety Food safety is a very important part of enjoying the outdoor cooking experience. To keep food safe from harmful bacteria, follow these four basic steps: Clean: Wash hands, utensils, and surfaces with hot soapy water before and after handling raw meat and poultry. Separate: Separate raw m...

Page 12 - or; Char-Broil® Stainless Steel; Char-Broil® Stainless Steel; STUBBORN STAINS AND RUST; Char-Broil® Stainless Restoration Kit

CARE AND CLEANING OF YOUR STAINLESS STEEL GRILL Routine cleaning is necessary to preserve the appearance and corrosion resistance of Stainless Steel. The perception that many people have is that stainless steel will not rust. That is not the case in certain conditions. Rust marks are regular steel p...

Page 13 - Key; Tools required for assembly:; Caster Wrench - Provided • Phillips screwdriver - Not provided; Estimated assembly time:

PARTS LIST – Model No. 463250308 NOTE: Some grill parts shown in the assembly steps may differ slightly in appearance from those on your particular grill model. However, the method of assembly remains the same. Key Qty Description Part # A 1 Bottom Shelf.....................80016693 B 2 Locking Cast...

Page 15 - Left side of the drawer

B 1/4” Lock Washer 1/4-20x3/4” Screw 1/4” Flat Washer ASSEMBLY – Model 463250308 Right Shelf Handle and Drawer handle Assembly 1 Draw the Drawer out of the right side shelf , make sure using your two hands and push the lock in right directions shown A B and C . D To w el B ar Right Side Shelf 1/4” L...

Page 17 - Temperature Probe

Tank 　 Gauge 　 Assembly 3 First, secure t emperature probe the clamp on the left side panel show A . Make the gauge wire go through the hole on the left side shelf and insert to the tank gauge show B and C . A B C Gauge Wire Gauge Wire Temperature Probe Clamp 463250308 • 17

Page 18 - Side Burner Assembly; Correct Alignment; Incorrect Alignment; Burner Tube

Side Burner Assembly 4 Correct Alignment A Burner Tube side burner Valve D #10-24x3/8” Screw #10 Lock Washer 5mm Silicon washer #10-24x3/8” Screw #10 Lock Washer 5mm Silicon Washer Insert back of side burner through left shelf cut-out shown C , reverse 180 ° after go through the cut-out and make cen...

Page 19 - side burner Control Knob Assembly

side burner Control Knob Assembly A Control Knob side burner Bezel Fasia side burner Shelf Valve Stem #8 Lock Washer #8-32x3/8” Screw Position side burner valve bracket beneath side burner shelffascia so that valve stem comes through larger center hole infascia shown A . Attach side burner bezel to ...

Page 21 - bled; Trough Assy; Fir; Re; Fro

Fir ebo x bled Ra ck Trough Install 7 First, place Trough Middle onto Firebox show A. Second, place two Trough Assy onto Firebox. Make sure this is put in the right direction as show in B. Fir box ox A Re ar Fro nt Trough Middle Trough Assy Trough Middle B 463250308 • 21

Page 22 - ox; Cooking Grate and Swing away; cooking grates; wing away

ox bled Ra ck Cooking Grate Swing away Cooking Grate and Swing away 8 Place cooking grates onto the firebox as shown. Place the S wing away onto the the firebox.Make sure insert the Swing away ends into the holes properly shown as below. 22 • 463250308

Page 23 - Tank Screw at bottom of slide bracket

LP Tank . Tank Screw at bottom of slide bracket CAUTION LP Tank valve must face to front of cart once tank is attached. Failure to install cylinder correctly may allow gas hose to be damaged in operation, resulting in the risk of fire. 12 Always keep LP tank in upright position during use, transport...

Page 24 - Unscrew electronic ignition cap on left side panel. Insert; AA; battery into ignitor,

Battery Cap Battery Positive(+)side up towards Cap + - 13 Electronic Ignition 　 Unscrew electronic ignition cap on left side panel. Insert AA battery into ignitor, negative (—) end first . Replace button. 24 • 463250308

Page 25 - Troubleshooting

EMERGENCIES: If a gas leak cannot be stopped, or a fire occurs due to gas leakage, call the fire department. Emergencies Problem Gas leaking from cracked/cut/burned hose. Gas leaking from LP cylinder. Gas leaking from LP cylinder valve. Gas leaking between LP cylinder and regulator connection. Fire ...

Page 27 - Troubleshooting - Electronic Ignition; SECTION I; Check Procedure

Troubleshooting - Electronic Ignition Problem (Ignition) SECTION I No sparks appear at any electrodes when control knob turned to ; no noise can be heard from spark module. SECTION II No sparks appear at any electrodes when control knob turned to ; noise can be heard from spark module. SECTION III S...

Page 28 - LIMITED WARRANTY; ITEMS MANUFACTURER WILL NOT PAY FOR:

LIMITED WARRANTY Manufacturer warrants to the original consumer-purchaser only that this product shall be free from defects in workmanship and materials after correct assembly and under normal and reasonable home use for the periods indicated below beginning on the date of purchase. The manufacturer...

Page 29 - Please register your product online at:

Mail to: / Envíelo a:Consumer Warranty ServiceP. O. Box 1240Columbus, GA 31902-1240 Thank you for completing this questionnaire. Your answers will help us and other companies reach you with offers that may interest you. If you prefer not to receive these offers, please check here .Gracias por comple...

Page 32 - STOP; Should you encounter a problem with our product; Do not return this product to the store.; WE CAN HELP; GRILL SERVICE CENTER; Grilling Safety Checklist; Read and understand owners manual.; Thank You for Your Purchase!

STOP Should you encounter a problem with our product CALL US FIRST Do not return this product to the store. WE CAN HELP GRILL SERVICE CENTER 1-888-430-7870 HOURS 8AM-6PM EST Mon-Fri Please ensure your warranty registration is complete. Grilling Safety Checklist Read and understand owners manual. Nev...

Char-Broil 463250308 - Manual

Table of Contents:

Summary

Other Char-Broil Models