Char-Broil 11101706 - Manual

Page 2 - Safety Symbols; Indicates an imminently hazardous situation; WARNING; CAUTION; Indicates a potentially hazardous situation or; DANGER; and immediately call your fire department.; DANGER; Never allow oil or grease to get hotter then 400 F; WARNING; Use as a turkey fryer may

DANGER Safety Symbols The symbols and boxes shown below explain what each heading means. Read and follow all of the messages found throughout the manual. DANGER: Indicates an imminently hazardous situation which, if not avoided, will result in death or serious injury. WARNING WARNING: Indicates an p...

Page 3 - Internal Cooking Temperatures; How To Tell If Meat Is Cooked Thoroughly

WARNING 1. Never leave the appliance unattended. Keep children and pets away from the appliance at all times. 2. The use of alcohol, prescription or non-prescription drugs may impair the consumer’s ability to properly assemble or safely operate the appliance. 3. This appliance is for OUTDOOR use onl...

Page 4 - Wash your hands after handling this product.; Installation Safety Precautions; National Fuel Gas Code,; Storing Your A; ppliance; Cleaning the

WARNING CALIFORNIA PROPOSITION 651. Combustible by-products produced when using this product contains chemicals known to the State of California to cause cancer, birth defects, or other reproductive harm. 2. This product contains chemicals, including lead and lead compounds, known to the State of Ca...

Page 5 - LP Cylinder Filling; CARE AND USE

• NEVER store a spare LP cylinder under or near the appliance or in an enclosed area. • Never fill a cylinder beyond 80% full. • An over filled or improperly stored cylinder is a hazard due to possible gas release from the safety relief valve. This could cause an intense fire with risk of property d...

Page 6 - Connecting Regulator to the LP Cylinder; full stop; LP Cylinder Exchange; Exchange your; LP Cylinder Leak Test; For your safety

WARNING If “growing” bubbles appear do not use or move the LP cylinder. Contact an LP gas supplier or your fire department! Connecting Regulator to the LP Cylinder 1. LP cylinder must be properly secured onto . (Refer to assembly section.) 2. Turn all control knobs to the OFF position. 3. Turn LP cy...

Page 7 - Leak Testing Valves, Hose and Regulator; rushing sound; immediately

6. Turn the coupling nut clockwise and tighten to a full stop. The regulator will seal on the back-check feature in the LP cylinder valve, resulting in some resistance. An additional one-half to three-quarters turn is required to complete the connection. Tighten by hand only – do not use tools. NOTE...

Page 8 - Do not block openings in the bottom of the appliance.; appliance; If you have an appliance problem see the

24” 10 ft. 10 ft. WARNING CAUTION • Do not use water on a grease fire. Personal injury may result. If a grease fire develops, turn knobs and LP cylinder off. For Safe Use of Your appliance and to Avoid Serious Injury:• This appliance will be hot during and after use. Use insulated oven mitts or glov...

Page 9 - Lighting Instructions:; Burner Flame Check; Troubleshooting Section

CAUTION If ignition does NOT occur in 5 seconds, turn the control knob CLOSED, wait 5 minutes and repeat the lighting procedure. If the burner does not ignite with the valve open, gas will continue to flow out of the burner and could accidently ignite with risk of injury. Turn control knob and LP cy...

Page 10 - Cleaning the Burner Assembly; Remove control panel with valve assembly from appliance.; Proper Engagement

Cleaning the Burner Assembly Follow these instructions to clean and/or replace parts of burnerassembly or if you have trouble igniting appliance.1. Close gas control knobs and LP cylinder knob and disengage regulator from cylinder. 2. Remove 2 screws (one from each side) connecting control panel to ...

Page 11 - LIMITED WARRANTY

This warranty only applies to units purchased from an authorized retailer. Manufacturer warrants to the original consumer-purchaser only that this product shall be free from defects in workmanship and materials after correct assembly and under normal and reasonable home use for the periods indicated...

Page 12 - PARTS LIST - EXPLODED VIEW; To order warranty or replacement parts contact

PARTS LIST - EXPLODED VIEW Ke y Qty De scription A 1 BURNER B 1 W INDSHIELD C 3 LEG D 3 FOOT E 3 BRACE, F/ LEG F 1 CONTROL PANEL G 1 HOSE/VALVE/REGULATOR H 2 CONTROL KNOB I 1 PAN, COOKING J 1 THERMOMETER Not Shown: … 1 HARDW ARE PACK … 1 INSTRUCTION MANUAL, ENGLISH … 1 INSTRUCTION MANUAL, SPANISH A ...

Page 13 - ASSEMBLY; To begin - place the

ASSEMBLY STEP 1 First choose a suitable location to assemble your Multi-Purpose Cooker. We recommend that you assemble the unit on a piece of carpet or other non-abrasive surface to prevent scratching the appliance. To begin - place the Burner Assembly upside down in the work area. Insert the Leg As...

Page 15 - onto the; Cooking Pan Supports

ASSEMBLY STEP 3 Carefully turn the Multi-Purpose Cooker over onto its Legs. Place the Cooking Pan onto the Cooking Pan Supports as shown. Cooking Pan Supports Cooking Pan WARNING NEVER USE THIS APPLIANCE AS ATURKEY FRYER! Use as a turkey fryer may result in a hazardous situation causing property dam...

Page 16 - Troubleshooting

EMERGENCIES: If a gas leak cannot be stopped, or a fire occurs due to gas leakage, call the fire department. Emergencies Problem Gas leaking from cracked/cut/burned hose. Gas leaking from LP cylinder. Gas leaking from LP cylinder valve. Gas leaking between LP cylinder and regulator connection. Fire ...

Page 17 - continued

Troubleshooting ( continued ) Possible Cause • Out of gas. • Excess flow valve on regulator tripped. • Vapor lock at coupling nut/LP cylinder connection. • Low on LP gas. • Excess flow valve tripped. • Grease buildup. • Excessive fat in meat. • Excessive cooking temperature. • Grease trapped by food...

Page 18 - Notes