Century Jefferson - Manual

Table of Contents:

• Page 2 – Jefferson Direct Vent/Natural Vent Gas Heater; Table of Contents
• Page 3 – Jefferson Direct Vent /Natural Vent Gas Heater; Installation & Operating Instructions; Proposition 65 Warning:; Fuels used in gas, woodburning; Jefferson Direct Vent/Natural Vent
• Page 4 – “GAS VENT DIRECTLY BELOW, KEEP; MANUFACTURER REQUIREMENTS; Gas Equipment Venting System NOT Provided
• Page 5 – Jefferson dimensions.; Jefferson Direct Vent/Natural Vent Stove Dimensions; Attention
• Page 6 – Installation Requirements; Possible stove locations.; Direct Vent System Only; Stardance; Clearance Requirements; Minimum Clearances to Combustible Materials; Locating The Stove
• Page 8 – Gas Specifications; Input; Gas Inlet and Manifold Pressures; ment, alteration, service or maintenance; Horizontal Termination -
• Page 9 – Vent Termination Clearances; NOTE: The restrictor; Vertical vent termination window.; IMPORTANT
• Page 11 – General Venting Information - Termination Location; Canadian Installations
• Page 12 – Termination clearances.; Termination Clearances; of Caps; Venting Runs; = Acceptable venting configuration; Venting Requirements - Natural Vent Only; Vent termination window - Natural Vent ONLY.
• Page 13 – Venting Requirements and Options -; Approved Vent System Components; Simpson DuraVent Components; Direct vent pipe may be used on the Natural
• Page 14 – Assembly Procedures; Failure to position the parts in accor-; Tools Required; glass swivel latch; Swivel the latches to release the glass frame from; WARNING; Install the Optional Fan; FDV attach snapstat; Snapstat assembly and installation.
• Page 15 – Venting System Assembly - Direct Vent; For Canadian installations:; Install the Vent Adapter Pipe; Dry fit the Inner Pipe assembly to the stove for; The upper flange of the fan skirt should be located; Correct position of fan skirt installation.; Install the restrictor plate only if required for the vent-
• Page 16 – Attach the Inner Vent Assembly to the stove.; attach inner pipe; Connect the inner starter with the next section of; attach inner assy; Attach inner assembly to flue collar.; Insert the pipe; install outer adpater; Consult the “Vertical; Discard the inner starter pipe; shipped with the log-
• Page 17 – Side Wall Termination Assembly; Vent Opening; Combustible Wall; Locate vent opening.; CFM System; For DuraVent pipe only:; Assemble the wall sleeve and firestop.; measure vertical vent; Determine the vertical pipe length.; dura vent
• Page 18 – measure thru wall; Measure the horizontal length.; install pipe thru wall; Install the horizontal pipe and wall plate parts.; install wall terminal; Install the vent terminal.; Vent Termination Below Grade; If the
• Page 19 – install snorkel; Snorkel kit installation.; snorkel detail; Use extension brackets to mount snorkel against; Install firestops and attic insulation shield.; Vent Assembly
• Page 20 – vent thru roof; Roof support and flashing.; The venting system must; Install the Vent Pipe; Decorative; Decorative 7” pipe may be fitted around the B-vent; attach draft hood; Install draft hood adapter.
• Page 21 – Install the Log Set; Remove the logs from their packaging and inspect; install logs 1; install logs 2; Loosely sprinkle the lava rocks directly on top of the; logs
• Page 22 – Connect the Gas Supply Line; THIS APPLIANCE SHOULD BE CONNECTED; In order to connect Natural Gas,; Air Shutter Adjustment; NOTE; Air Shutter Adjustment Instructions
• Page 23 – FDV28 remove Front; Remove stove front.; Jefferson; Remove rear log bracket and left and right log bracket
• Page 24 – Remove and replace injector orifices.; injector orifice; Complete the Assembly; Run wires down back of stove, under bottom of rear; attach switch; Attach switch wires to valve.; attach switch assy; Attach switch assembly to rear shroud.; Install the Stove Front; FDV28 attach Front; front plate top view; Engage with side ribs.; Use only a thermostat rated for 500 - 750 millivolts.; Install the wall thermostat in the desired location and; Thermostat
• Page 25 – Operation; Your First Fire; Flame adjustment knob for Honeywell valve.; Flame Characteristics; Pilot assembly location; Pilot assembly location.; pilot; Correct pilot flame appearance. PSE pilot.; Pilot flame; log flames; Correct burner flame appearance.
• Page 26 – FOR YOUR SAFETY READ BEFORE LIGHTING; WHAT TO DO IF YOU SMELL GAS; To Turn Off Gas To Heater; Lighting and Operating Instructions; Lighting Instructions; Lighting instructions
• Page 27 – Troubleshooting / Honeywell #8420 Gas Control System; SYMPTOM
• Page 28 – Conversion Precautions; Fuel Conversion Instructions; attach gas line; Conversion Procedure; Pilot Type 1
• Page 29 – gas conversion; Remove pilot hood.; Remove pilot orifice.; Remove pilot hood. (Your pilot may have a different; Gas Conversion; Remove pilot orifice.; Conversion to LP; Table 2. Injector Orifice Size Matrix
• Page 30 – Maintenance; painted surfaces; Remove the Stove Front.
• Page 31 – Gasket Replacement; Determine the correct length of gasket by laying it; Inspect the Vent System Annually; glass gasket detail; Wrap the gasket material around the outside edge of; Release the latches to release the glass frame.
• Page 32 – rdv connections diag.; Schematic Diagram; Wiring Diagrams; On/off switch and optional thermostat circuit.; wiring
• Page 33 – JDVB; Lava Rocks Burner
• Page 34 – Ref. Descripción
• Page 35 – Optional Accessories; Fan Kits; Refer to Page 14 for installation instructions.; Remote Controls; ON/OFF and Temperature; Decorative Rings
• Page 39 – This warranty does not apply to parts:; CFM Corporation; CFM CORPORATION WARRANTY FOR ALL CENTURY GAS PRODUCTS
• Page 40 – Efficiency Ratings; Model; JDVBRN