Carrier 592-085 - Manual

Carrier 592-085

Carrier 592-085 – Manual, read for free online in PDF format. We hope this helps you resolve any issues you may have. If you have further questions, please contact us through the contact form.

1 Page 1
2 Page 2
3 Page 3
4 Page 4
5 Page 5
6 Page 6
7 Page 7
8 Page 8
9 Page 9
10 Page 10
11 Page 11
12 Page 12
13 Page 13
14 Page 14
15 Page 15
16 Page 16
17 Page 17
18 Page 18
19 Page 19
20 Page 20
21 Page 21
22 Page 22
23 Page 23
24 Page 24
25 Page 25
26 Page 26
27 Page 27
28 Page 28
29 Page 29
30 Page 30
31 Page 31
32 Page 32
33 Page 33
34 Page 34
35 Page 35
36 Page 36
37 Page 37
38 Page 38
39 Page 39
40 Page 40
41 Page 41
42 Page 42
43 Page 43
44 Page 44
45 Page 45
46 Page 46
47 Page 47
48 Page 48
49 Page 49
50 Page 50
51 Page 51
52 Page 52
53 Page 53
54 Page 54
55 Page 55
56 Page 56
Page: / 56

Table of Contents:

  • Page 3 – NEW CONSTRUCTION; Initial Cost Savings For The Building Owner; CARRIER WARRANTY; APPLICATIONS
  • Page 6 – tors’ sleeves without use of retrofit kit; QUIET OPERATION; The fan motor requires no
  • Page 7 – REMOVABLE FRONT PANEL; If desired, the front panel can be; Removable Front Panel
  • Page 8 – WASHABLE VENT AIR FILTER; The vent will provide 50 cfm of fresh air.; Outdoor Vent Filter Location
  • Page 9 – SNOW BAFFLE; Bi-Molded Condenser Shroud
  • Page 10 – Fan Cycle Switch; • Cycle — This setting allows the fan to cycle on and; Easy Service Access
  • Page 11 – ENHANCED COPPER TUBING; surface and turbulent refrigerant gas flow); SEAMLESS BASEPAN; gallons of; CONDENSATE DRAIN VALVE; Condensate Disposal System
  • Page 12 – Special Features; Manual Compressor Override Switch:; How The Heat Pump Works
  • Page 14 – units
  • Page 16 – Corrosion-Protected Polymer Sleeve
  • Page 17 – accommodate Carrier’s industry standard PTAC units.; Standard and Extended Metal Wall Sleeve
  • Page 18 – OUTDOOR GRILLES; Architectural Grille in
  • Page 19 – Outdoor Grille Selection; The louver should be attached to the wall sleeve in a; Hardwire Kit; Sample Calculations; Louver Dimensional Reference
  • Page 20 – SUBBASE; ance is 5; Non-electrical subbase; Non-Electrical Subbase Assembly
  • Page 21 – Subbase Fuse Kit; Power Disconnect Switch Assembly
  • Page 22 – Non-Programmable Thermostat
  • Page 23 – Thermostat Locking Cover; Wall Thermostat Interface Retrofit Kit
  • Page 24 – Lateral Duct Kit
  • Page 25 – Security Door Kit
  • Page 26 – Easily Replaceable Filters
  • Page 27 – 2P and 52C Dimension Drawing
  • Page 28 – Standard Polymer Non-Insulated Wall Sleeve
  • Page 29 – TYPICAL WALL INSTALLATION; Typical Wall Sleeve Installation
  • Page 30 – 2P and 52C Indoor and Outdoor Discharge Air Circulation
  • Page 31 – TYPICAL LATERAL DUCT INSTALLATION
  • Page 33 – WALL THERMOSTAT CONNECTIONS; Control Box Wire Terminal for
  • Page 42 – COOLING PERFORMANCE
  • Page 43 – COOLING SENSIBLE HEAT FACTORS (SHF) AT 80 F INDOOR DB
  • Page 49 – Typical Wiring Schematic for Energy Management Kit
  • Page 51 – Part 1 — General; SYSTEM DESCRIPTION; QUALITY ASSURANCE; Part 2 — Products; GUIDE SPECIFICATIONS
  • Page 54 – TYPICAL WARRANTY; Carrier
  • Page 56 – ACCESSORY LIST
Loading the manual

ARCHITECTS AND ENGINEERS’ MANUAL

December 2004

Copyright

Carrier Corporation

Cat. No. 592-085

CONTENTS

Page

APPLICATIONS

. . . . . . . . . . . . . . . . . . . . . . . . . . . . 3,4

New Construction . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 3
Retrofit/Replacement . . . . . . . . . . . . . . . . . . . . . . . . . . . 3
Carrier Warranty . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 3
Application Considerations . . . . . . . . . . . . . . . . . . . . . . 4

PRODUCT OVERVIEW

. . . . . . . . . . . . . . . . . . . . . . . 5

PRODUCT FEATURES AND BENEFITS

. . . . 6-13

Quiet Operation . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 6
Most Efficient Performance . . . . . . . . . . . . . . . . . . . . . . 6
Efficient Fan Motor . . . . . . . . . . . . . . . . . . . . . . . . . . . . 6
No-Rust Weather Last™ Wall Sleeve and

Front Panel . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 7

Removable Front Panel . . . . . . . . . . . . . . . . . . . . . . . . . 7
Anti-Theft Knobs . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 7
Two-Piece Lifetime Indoor Filter . . . . . . . . . . . . . . . . . . 8
Washable Vent Air Filter . . . . . . . . . . . . . . . . . . . . . . . . 8
Bi-Directional Discharge Grille . . . . . . . . . . . . . . . . . . . 8
Power Cord for 265-V Units . . . . . . . . . . . . . . . . . . . . . 9
Power Cord Protection for 230/208-V Units . . . . . . . . . 9
Bi-Molded Condenser Shroud . . . . . . . . . . . . . . . . . . . . 9
Snow Baffle . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 9
Easy Access to Chassis. . . . . . . . . . . . . . . . . . . . . . . . . 10
Hidden Controls . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 10
Enhanced Copper Tubing . . . . . . . . . . . . . . . . . . . . . . . 11

Page

Seamless Basepan . . . . . . . . . . . . . . . . . . . . . . . . . . . . 11
Condensate Drain Valve . . . . . . . . . . . . . . . . . . . . . . . . 11
Condensate Removal System . . . . . . . . . . . . . . . . . . . . 11
Heat Pumps Pay Their Own Way. . . . . . . . . . . . . . . . . 12
Heat Pump Energy Savings . . . . . . . . . . . . . . . . . . . . . 13

ORDERING DATA

. . . . . . . . . . . . . . . . . . . . . . . . . . . 14

Product Catalog Number . . . . . . . . . . . . . . . . . . . . . . . 14

FACTORY-INSTALLED OPTIONS

. . . . . . . . . . . 15

FIELD-INSTALLED ACCESSORIES

. . . . . . 16-26

DIMENSION DRAWINGS AND
INSTALLATION DATA — NEW
CONSTRUCTION

. . . . . . . . . . . . . . . . . . . . . . . . . 27-33

PRODUCT DATA

. . . . . . . . . . . . . . . . . . . . . . . . . 34-41

EXPANDED RATINGS DATA

. . . . . . . . . . . . . . .42,43

SOUND DATA

. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 44

WIRING DIAGRAMS

. . . . . . . . . . . . . . . . . . . . . 45-50

52PQ and 52CQ . . . . . . . . . . . . . . . . . . . . . . . . . . . .45,46
52PE and 52CE . . . . . . . . . . . . . . . . . . . . . . . . . . . .47,48
Energy Management/Front Desk Control . . . . . . . . . . 49
Single Thermostat/Multiple PTAC Units . . . . . . . . . . . 50

GUIDE SPECIFICATIONS

. . . . . . . . . . . . . . . . 51-53

TYPICAL WARRANTY

. . . . . . . . . . . . . . . . . . . .54,55

ACCESSORY LIST

. . . . . . . . . . . . . . . . . . . . . . . . . . 56

For more information available on the internet, see the

www.carrier.com

or

www.lodgingAC.com

web sites.

PREMIER SERIES 52P

COMFORT SERIES 52C

PACKAGED TERMINAL

AIR CONDITIONERS

AND HEAT PUMPS

"Loading the manual" means you need to wait until the file loads and becomes available for online reading. Some manuals are very large, and the time they take to appear depends on your internet speed.

Summary

Page 3 - NEW CONSTRUCTION; Initial Cost Savings For The Building Owner; CARRIER WARRANTY; APPLICATIONS

3 Whether you are designing a new structure or replac-ing packaged terminal air conditioning units in anexisting building, Carrier will meet your needs.• Hotels and motels• Nursing homes and assisted living care centers• Offices• Apartments• Single-family dwellings• Home conversions and residential ...

Page 6 - tors’ sleeves without use of retrofit kit; QUIET OPERATION; The fan motor requires no

6 The 52P and 52C models are a single-package,through-the-wall unit for heating and cooling hotelrooms, offices, apartments, condominiums, and resi-dential additions. Features include:• Improved sound quality for quiet operation• Exceeds ARI (Air Conditioning and Refrigeration Institute) efficiency ...

Page 7 - REMOVABLE FRONT PANEL; If desired, the front panel can be; Removable Front Panel

7 NO-RUST WEATHER LAST™WALL SLEEVE AND FRONTPANEL The indoor front panel and polymer wall sleeve usenonmetallic compounds that never rust or corrode, donot support combustion, and do not give off toxicfumes. The weather-resistant feature exceeds require-ments of Underwriters’ Laboratories and resist...

Other Carrier Models