Page 4 - TABLE OF CONTENTS; SECTION; Dealer
SBB00104-3-0309 Page 4 TABLE OF CONTENTS Congratulations! You have chosen the finest grill for your outdoor cooking pleasure. Please take time to read this entire manual before assembling your Superb by Broilmaster ® Gas Grill. Hardware Package ..........................................................
Page 5 - HARDWARE PACKAGE
Page 6 - PARTS VIEW
SBB00104-3-0309 Page 6 PARTS VIEW All repair part orders should be placed through your local Broilmaster ® dealer. To locate a dealer in your area, contact Broilmaster Cus- tomer Service at 800-851-3153 or www.broilmaster.com. To ensure prompt and accurate service, please provide the following infor...
Page 7 - PARTS LIST
SBB00104-3-0309 Page 7 PARTS LIST INDEX NO. PART NUMBER DESCRIPTION 1 SBB00014 THERMOMETER 2 SBB00108 LID 3 SBB00013 NUT AND LID BOLT 4 SBB00078 WARMING RACK 5 SBB00064 ROTISSERIE MOTOR 6 SBB00065 ROTISSERIE MOTOR BRACKET 7 SBB00067 ROTISSERIE ROD 8 SBB00068 ROTISSERIE FORKS 9 SBB00069 ROTISSERIE RO...
Page 8 - GRILL ASSEMBLY
SBB00104-3-0309 Page 8 GRILL ASSEMBLY Before You Begin This grill requires some assembly and installation. Follow all instructions.If you purchased an accessory with your Superb by Broilmaster ® Gas Grill, follow the instructions provided with the accessory for assembly and installation. If an instr...
Page 9 - Surround Kit Location; Connection Requirements; SURROUND LOCATION, CONNECTIONS, AND SAFETY
SBB00104-3-0309 Page 9 Surround Kit Location Built-In Kits are designed for outdoor use ONLY. This Built-In Kit is designed for use with SBB2804 Broilmaster ® gas grills and cannot be used with any other grill or in any other capacity.Never install or operate your Built-In Kit in any building, garag...
Page 10 - ENCLOSURE CONSTRUCTION GUIDELINES
SBB00104-3-0309 Page 10 Enclosure must be construction from non-combustible material. If tile is used on the top surface of your enclosure, it may be necessary to enlarge openings at the top edges to allow the frame pieces of the SBB and BSA to mount flush against the enclosure. Screws for enclosure...
Page 11 - SURROUND ASSEMBLY
SBB00104-3-0309 Page 11 1. The grill is shipped with the surround and the grill head at- tached by four screws as shown in the drawing below. Please remove the four screws to seperate the surround from the grill head. See Figure 1. 2. Place the SBB surround into position in the constructed enclosure...
Page 12 - SURROUND AND GRILL ASSEMBLY
SBB00104-3-0309 Page 12 6. Place flame tamers over burners. Pins on burner box fit through holes on flame tamer. See Figure 7. 7. Place cooking grids into grill. See Figure 7. 8. Place warming rack on top of grill body side walls. See Figure 7. 9. Remove ignitor button, insert AA battery (provided) ...
Page 13 - ROTISSERIE INSTALLATION
SBB00104-3-0309 Page 13 ROTISSERIE INSTALLATION The Infrared burner (Rotisserie burner) is for rotisserie cooking only. Warning: Never use the main burners while using the Infrared Back Burner, as this could result in igniting the drip- pings, or overheating your grill. Remove warming rack and cooki...
Page 14 - ALTERNATE MATCH LIGHTING
SBB00104-3-0309 Page 14 1. Turn the burner control knobs clockwise to the OFF position. 2. Turn ON gas at the source. 3. Open the grill lid. 4. Locate the Ignitor Rod, which is permanently attached to the inside of the right surround side. 5. Insert an unlit match into the coiled end of the ignitor ...
Page 15 - ROTISSERIE OPERATION
SBB00104-3-0309 Page 15 ROTISSERIE OPERATION Using the IgnitorCaution: If burner fails to light after 5 seconds, turn the burner OFF for 5 minutes, to allow the gas to clear, then try again.Attention: You must use the control knob that is second from the left side of grill to ignite the rotisserie.1...
Page 16 - PROPANE GAS GRILLS
SBB00104-3-0309 Page 16 PROPANE GAS GRILLS Grill Location When choosing the ideal location for your Superb by Broilmaster ® Gas Grill, remember this grill is designed for outdoor use ONLY.You should never install or operate your grill in any building, garage, or other enclosed area.For your safety, ...
Page 18 - GAS CONVERSION TO LIQUID PROPANE GAS
SBB00104-3-0309 Page 18 GAS CONVERSION TO LIQUID PROPANE GAS A conversion kit to liquid propane (LP) gas is included with your grill. 1. Remove cooking grids and flame tamer from grill. 2. Use allen wrench supplied in conversion kit to remove control knobs. 3. Remove control panel (4 Phillips screws...
Page 19 - OPERATION
SBB00104-3-0309 Page 19 OPERATION Checking for Gas Leaks Check for gas leaks every time you connect your Superb by Broilmaster ® propane gas grill to a Propane gas cylinder, when a connected cylinder has not been used recently, or when either a natural or propane grill is being used for the first ti...
Page 21 - MAINTENANCE
SBB00104-3-0309 Page 21 MAINTENANCE Cleaning the Grill Caution: To prevent injury, do not clean a hot grill.Note: Do not use a commercial cleaner on the cooking grids. Do not brush grids while they are hot. Do not scrape grids. For baked on residue use a BRASS (NOT STEEL) brush on the cooking grids ...
Page 22 - TROUBLESHOOTING
SBB00104-3-0309 Page 22 TROUBLESHOOTING Although the manufacturer has attempted to ensure that your grill will operate properly and satisfactorily, sometimes problems do arise. The following troubleshooting guide lists several possible problems and their probable cause and solution. Problem Cause So...
Page 23 - WARRANTY TERMS
SBB00104-3-0309 Page 23 WARRANTY TERMS Limited Lifetime Warranty • SBB2804 Stainless Steel Grill Lid, Body, and Cooking grids, Stainless Steel Built-In Sur - round 5 Years Against Rust-Through • Stainless steel burners • Infrared rotisserie burners • Stainless steel warming rack • Stainless steel fl...
Page 24 - BROILMASTER; osT
SBB00104-3-0309 Page 24 BROILMASTER ® A Division of Empire Comfort Systems, Inc. 918 Freeburg Ave. Belleville, Illinois 62220 Phone: 1-800-851-3153 FAX: 1-800-443-8648 V isit our web site at www . broilmaster.com T he M osT D urable G rill K nown T o M an
