Weil-McLain GOLD CGs - Manuals

Page 2 - Hazard definitions; Please read this page first; Boiler service and

GOLD CGs — User’s Information Manual 2 Part No. 550-110-261/0999 The following defined terms are used throughout this manual to bring attention to the pres-ence of hazards of various risk levels or to important information concerning the life of theproduct. Hazard definitions Please read this page f...

Page 3 - Boiler service and maintenance —

GOLD CGs — User’s Information Manual 3 Part No. 550-110-261/0999 Failure to adhere to the guidelines on this page can result in se-vere personal injury, death or substantial property damage. Boiler service and maintenance — • To avoid electric shock, disconnect electrical supply before per- forming ...

Page 4 - Air contamination; Prevent combustion air contamination

GOLD CGs — User’s Information Manual 4 Part No. 550-110-261/0999 Air contamination Common household and hobby products often con-tain fluorine or chlorine compounds. When thesechemicals pass through the boiler, they can form strongacids in the vent system or boiler. The acid can eatthrough the vent ...

Page 5 - Maintain boiler using schedule below; Service technician; Owner maintenance; NN

GOLD CGs — User’s Information Manual 5 Part No. 550-110-261/0999 Maintain boiler using schedule below Service technician (covered in CGs Boiler Manual — for use only by a qualified service technician ) Owner maintenance (see following pages for instructions) A NN N U AL START - UP Inspect: • Reporte...

Page 6 - User maintenance procedures; Boiler must be serviced & maintained

GOLD CGs — User’s Information Manual 6 Part No. 550-110-261/0999 User maintenance procedures Check boiler area Check boiler area Check boiler area Check boiler area Check boiler area The boiler should be inspected and started annually, at the beginning ofthe heating season, only by a qualified servi...

Page 7 - continued; Check boiler interior piping; Check boiler relief valve; Check condensate drain system

GOLD CGs — User’s Information Manual 7 Part No. 550-110-261/0999 User maintenance procedures continued Check boiler interior piping 1. Remove boiler jacket top. 2. Visually inspect for leaks around internal piping, circulators, relief valve and other fittings. Immedi-ately call a qualified service t...

Page 8 - Operate boiler relief valve; Oil inducer motor

GOLD CGs — User’s Information Manual 8 Part No. 550-110-261/0999 User maintenance procedures Operate boiler relief valve 1. Before proceeding, verify that the relief valve out- let has been piped to a safe place of discharge, avoid-ing any possibility of scalding from hot water. To avoid water damag...

Page 9 - Follow boiler shutdown procedure

GOLD CGs — User’s Information Manual 9 Part No. 550-110-261/0999 User maintenance procedures continued Follow boiler shutdown procedure 1. Follow “ TO TURN OFF GAS TO APPLIANCE ” on the Lighting in- structions on the inside of the jacket top panel. You will also find these instructions on pages 12 a...

Page 11 - GOLD

GOLD CGs — User’s Information Manual 1 1 Part No. 550-110-261/0999 GOLD CGs Gas-Fired Induced-Draft Water Boiler

Page 12 - Lighting instructions

GOLD CGs — User’s Information Manual 1 2 Part No. 550-110-261/0999 Lighting instructions Before attempting to start the boiler, check the boiler pressure temperature gauge. If boiler and system are full of water and properly pres-surized, the gauge should read at least 12 psig on mostsystems. Operat...

Page 13 - FOR YOUR SAFETY READ BEFORE OPERATING

GOLD CGs — User’s Information Manual 1 3 Part No. 550-110-261/0999 FOR YOUR SAFETY READ BEFORE OPERATING OPERATING INSTRUCTIONS TO TURN OFF GAS TO THE APPLIANCE • Do not try to light any appliance. • Do not touch any electric switch; do not useany phone in your building. • Immediately call your gas ...

Page 14 - Common problems and solutions; Symptom

GOLD CGs — User’s Information Manual 1 4 Part No. 550-110-261/0999 Common problems and solutions Symptom Common Causes Possible Corrections Rapid cycling — boiler turns on and off frequently Thermostat installed where drafts or heat affect reading Locate thermostat on inner wall away from heat sourc...