Weider WESY96400 - Manuals - manualsarea.com

Page 2 - TABLE OF CONTENTS; LIMITED WARRANTY

2 TABLE OF CONTENTS LIMITED WARRANTY . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .2IMPORTANT PRECAUTIONS . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . ....

Page 3 - IMPORTANT PRECAUTIONS

3 IMPORTANT PRECAUTIONS WARNING: To reduce the risk of serious injury, read the following important precautions beforeusing the home gym system. WARNING: Before beginning this or any exercise program, consult your physician. This is especiallyimportant for persons over the age of 35 or persons with ...

Page 4 - BEFORE YOU BEGIN

4 BEFORE YOU BEGIN ASSEMBLED DIMENSIONS: Height: 76 in.Width: 89 in. Length: 64 in. Foot Plate Low PulleyStation High Pulley Station Lat Bar Leg Lever Butterfly Arms Military Press Arm Press Arm Weight Stacks Backrests VKR Arms Leg Press Plate Thank you for selecting the versatile WEIDER ® PRO 9640 ...

Page 5 - ASSEMBLY; FRAME ASSEMBL

5 ASSEMBLY 1 8 11 51 27 1 4 3 1 51 5 1. Before beginning assembly, be sure thatyou have read and understand the infor-mation in the box above. Locate and open the parts bag labeled“FRAME ASSEMBLY.” Press two 2” Square Outer Caps (51) ontothe indicated locations on the Stabilizer (5).Press a 2” Squar...

Page 10 - ARM ASSEMBL

10 12. Press a 1” Round Inner Cap (49) into one of the Press Arms (46). Press a 1 3/4” SquareInner Cap (44) into the Press Arm. Attach the Press Arm (46) to one side of thePress Frame (17) with two 5/16” x 2 1/2” Bolts(22) and two 5/16” Nylon Locknuts (3). Assemble the other Press Arm (46) in thesam...

Page 12 - CABLE ASSEMBL

12 18. Wrap the High Cable (58) around a “V”-Pulley (50). Attach the “V”-Pulley and a Long CableTrap (31) to the indicated bracket on the FrontUpright (42) with a 3/8” x 2 1/2” Bolt (86) anda 3/8” Nylon Locknut (21). Be sure that theLong Cable Trap is positioned to hold theCable in place. 19. Route ...

Page 19 - SEA

19 39. Attach the Front Backrest (41) to the Front Upright (42) with two 1/4” x 2 1/2” Screws(43) and two 1/4” Flat Washers (10). TheBackrest must be oriented as shown. 40. Press a 1 1/2” Square Inner Cap (32) into the Front Seat Frame (36). Insert a 1/4” x 2” Carriage Bolt (38) throughthe center ho...

Page 22 - HOW TO USE THE HOME GYM SYSTEM

22 HOW TO USE THE HOME GYM SYSTEM The instructions below describe how each part of the home gym system can be adjusted. Refer to the exerciseposter accompanying this manual to see how the home gym system should be set up for each exercise.IMPORTANT: When attaching the lat bar or nylon strap, make su...

Page 24 - WEIGHT RESISTANCE CHART

24 WEIGHT RESISTANCE CHART This chart shows the approximate weight resistance at each weight station. “Top” refers to the 6.5 lb. top weight.The other numbers refer to the 12.5 lb. weight plates. The butterfly arm resistance listed is the resistance foreach butterfly arm. WEIGHT PRESS BUTTERFLY LEG ...

Page 25 - TROUBLE-SHOOTING AND MAINTENANCE

TROUBLE-SHOOTING AND MAINTENANCE Inspect and tighten all parts each time you use the home gym system. Replace any worn parts immediately. Thehome gym system can be cleaned using a damp cloth and mild non-abrasive detergent. Do not use solvents. TIGHTENING THE CABLES Woven cable, the type of cable us...

Page 26 - CABLE DIAGRAMS

26 CABLE DIAGRAMS The cable diagrams on these pages show the proper routing of the High Cable (58), the Low Cable (23), theMilitary Press Cable (72), and the Leg Press Cable (99). Use the diagrams to be sure that the four cables andthe cable traps have been assembled correctly. If the cables have no...

Page 28 - ORDERING REPLACEMENT PARTS

ORDERING REPLACEMENT PARTS To order replacement parts, simply call our Customer Service Department toll-free at 1-800-999-3756, Mondaythrough Friday, 6 a.m. until 6 p.m. Mountain Time (excluding holidays). To help us assist you, please be pre-pared to give the following information: 1. The MODEL NUM...

Page 34 - EXPLODED DRAWING—Model No. WESY96400

60 27 21 15 55 12 11 8 15 12 44 88 15 58 21 44 21 3 61 62 24 3 58 71 2 65 63 64 25 26 19 21 9 3 3 49 6 22 46 46 16 3 9 15 21 59 23 21 17 27 1 4 10 43 41 42 21 3 50 31 86 70 69 69 70 21 47 44 45 44 45 48 50 31 86 13 40 38 37 18 32 34 30 28 3 49 83 33 10 2 36 14 88 15 29 35 30 34 34 30 28 3 8 32 30 34...