Weider WESY85104 - Manuals - manualsarea.com

Page 2 - TABLE OF CONTENTS

2 TABLE OF CONTENTS IMPORTANT PRECAUTIONS . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .3BEFORE YOU BEGIN . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . ....

Page 4 - BEFORE YOU BEGIN

4 BEFORE YOU BEGIN ASSEMBLED DIMENSIONS: Height: 76 in.Width: 38 in. Length: 53 in. Foot Plate Low Pulley Station High Pulley Station Lat Bar Leg Lever Butterfly Arms Press Arm Weight Stack Seat Backrest Weight Pin Thank you for selecting the versatile WEIDER ® 8510 home gym system. The WEIDER ® 851...

Page 5 - ASSEMBLY; FRAME ASSEMBL

5 ASSEMBLY 1 56 High Side of Bracket 3 5 51 51 14 1 27 4 Before beginning assembly, carefully read thefollowing information and instructions: • Place all parts of the home gym system in a cleared area and remove the packing materials;do not dispose of the packing materials untilassembly is completed...

Page 8 - ARM ASSEMBL

8 ARM ASSEMBL Y 8. Press a 1 3/4” Square Inner Cap (44) into thetop of a Press Arm (46). Press a 1” RoundInner Cap (49) into each end of the handle onthe Press Arm. Attach the Press Arm to oneside of the Press Frame (17) with two 5/16” x2 1/2” Bolts (22) and two 5/16” NylonLocknuts (3). Assemble the...

Page 9 - CABLE ASSEMBL

9 CABLE ASSEMBL Y 11. During steps 11 through 25, refer to the CABLE DIAGRAM on page 20 of this manualto verify proper cable routing. Before begin-ning this section, identify the Long Cable (23)and the Short Cable (58) by comparing thelengths and ends of the cables. IMPORTANT: While assembling the c...

Page 17 - ADJUSTMENT

17 ADJUSTMENT The instructions below describe how each part of the home gym system can be adjusted. Refer to the exerciseposter accompanying this manual to see how the home gym system should be set up for each exercise.IMPORTANT: When attaching the lat bar or nylon strap, make sure that the attachme...

Page 19 - TROUBLESHOOTING AND MAINTENANCE

19 TROUBLESHOOTING AND MAINTENANCE Inspect and tighten all parts each time you use the home gym system. Replace any worn parts immediately. Thehome gym system can be cleaned using a damp cloth and mild non-abrasive detergent. Do not use solvents. TIGHTENING THE CABLES Woven cable, the type of cable ...

Page 20 - CABLE DIAGRAM

20 CABLE DIAGRAM The cable diagram below shows the proper routing of the Short Cable (58) and the Long Cable (23). Use thediagram to be sure that the two cables and the cable traps have been assembled correctly. If the cables havenot been correctly routed, the home gym system will not function prope...

Page 21 - NOTES

Page 23 - EXPLODED DRAWING—Model No. WESY85104

23 11 11 8 8 55 27 12 15 44 15 71 23 27 21 44 21 3 61 60 3 56 15 12 2 57 58 21 3 5 51 14 19 26 51 25 64 63 76 9 21 3 3 4 1 27 65 15 71 41 10 43 3 21 6 50 7 42 7 50 6 21 69 70 69 70 47 48 44 45 44 45 13 40 38 37 18 32 28 30 34 10 2 24 36 30 34 14 33 3 29 34 30 28 9 21 49 49 46 32 30 34 35 49 49 46 22...

Page 24 - PART IDENTIFICATION CHART—Model No. WESY85104

5/16" Nylon Locknut (3) 1/4" Flat Washer (10) 5/16" Flat Washer (8) 3/8" Flat Washer (9) 1/4" x 2 1/2" Screw (43) 5/16" x 1 3/4" Bolt (72) 3/8" Nylon Locknut (21) 1/4" x 2" Screw (24) 5/16" x 2 1/2" Carriage Bolt (1) 5/16" x 2 3/4" Carriage...