Weed Eater S165H42A - Manuals

5 UNASSEMBLED PARTS Steering Wheel Steering Wheel Insert (1) Large Flat Washer (1) Locknut 5/16-18 (1) Hex Bolt 5/16-18 x 1-1/4 (1) Hex Bolt 3/8-16 x 1 (1) Lockwasher 3/8 Steering Boot SteeringExtensionShaft Steering Wheel Adapter (1) Bolt (1) Washer 17/32 x 1-3/16 x 12 Gauge Seat (2) Keys Slope She...

6 ASSEMBLY TOOLS REQUIRED FOR ASSEMBLY A socket wrench set will make assembly easier. Standardwrench sizes are listed.(1) 9/16" wrench Pliers (2) 1/2" wrenches Tire pressure gaugeUtility knife When right or left hand is mentioned in this manual, it meanswhen you are in the operating position...

8 3 CHECKLIST BEFORE YOU OPERATE AND ENJOY YOUR NEW TRAC-TOR, WE WISH TO ASSURE THAT YOU RECEIVE THEBEST PERFORMANCE AND SATISFACTION FROM THISQUALITY PRODUCT. PLEASE REVIEW THE FOLLOWING CHECKLIST: ✓ All assembly instructions have been completed. ✓ No remaining loose parts in carton. ✓ Battery is p...

9 OPERATION These symbols may appear on your tractor or in literature supplied with the product. Learn and understand their meaning. BATTERY CAUTION OR WARNING REVERSE FORWARD FAST SLOW ENGINE ON ENGINE OFF OIL PRESSURE LIGHTS ON FUEL CHOKE MOWER HEIGHT PARKING BRAKE LOCKED UNLOCKED REVERSE NEUTRAL ...

10 OPERATION KNOW YOUR TRACTOR READ THIS OWNER'S MANUAL AND SAFETY RULES BEFORE OPERATING YOUR TRACTOR Compare the illustrations with your tractor to familiarize yourself with the locations of various controls and adjustments. Savethis manual for future reference. Our tractors conform to the safety ...

11 OPERATION The operation of any tractor can result in foreign objects thrown into the eyes, which canresult in severe eye damage. Always wear safety glasses or eye shields while operatingyour tractor or performing any adjustments or repairs. We recommend a wide visionsafety mask over spectacles or...

12 OPERATION TO OPERATE ON HILLS CAUTION: Do not drive up or down hillswith slopes greater than 15° and do notdrive across any slope. • Choose the slowest speed before starting up or downhills. • Avoid stopping or changing speed on hills. • If slowing is necessary, move throttle control lever toslow...

13 PURGE TRANSMISSION CAUTION: Never engage or disengagefreewheel lever while the engine is run-ning. To ensure proper operation and performance, it is recom-mended that the transmission be purged before operatingtractor for the first time. This procedure will remove anytrapped air inside the transm...

14 FIG. 9 MOWING TIPS • Mower should be properly leveled for best mowingperformance. See “TO LEVEL MOWER HOUSING” inthe Service and Adjustments section of this manual. • The left hand side of mower should be used for trimming. • Drive so that clippings are discharged onto the area thathas been cut. ...

15 CUSTOMER RESPONSIBILITIES BEFORE EACH USE T RAC T 0 R Adjust Motion Drive Belt(s) Tension Inspect Muffler/Spark Arrester Lubrication Chart Check Brake Operation Clean Air Filter Change Engine Oil Replace Air Filter Paper Cartridge Replace Spark Plug Check Battery Level Check Tire Pressure Clean B...

16 CUSTOMER RESPONSIBILITIES BLADE REMOVAL (See Fig. 10) • Raise mower to highest position to allow access toblades. • Remove hex bolt, lock washer and flat washer securingblade. • Install new or resharpened blade with trailing edge uptowards deck as shown. IMPORTANT: TO ENSURE PROPER ASSEMBLY, CENT...

17 CUSTOMER RESPONSIBILITIES V-BELTS Check V-belts for deterioration and wear after 100 hours ofoperation and replace if necessary. The belts are notadjustable. Replace belts if they begin to slip from wear. TRANSAXLE COOLING The transmission fan and cooling fins should be kept cleanto assure proper...

18 CUSTOMER RESPONSIBILITIES MUFFLER Inspect and replace corroded muffler and spark arrester (ifequipped) as it could create a fire hazard and/or damage. SPARK PLUGS Replace spark plugs at the beginning of each mowingseason or after every 100 hours of operation, whicheveroccurs first. Spark plug typ...

19 SERVICE AND ADJUSTMENTS FIG. 16 CAUTION: BEFORE PERFORMING ANY SERVICE OR ADJUSTMENTS:• Depress clutch/brake pedal fully and set parking brake. • Place motion control lever in neutral (N) position. • Place attachment clutch in “DISENGAGED” position. • Turn ignition key “OFF” and remove key. • Mak...

21 SERVICE AND ADJUSTMENTS FIG. 23 ENGINEPULLEY CLUTCHINGIDLER STATIONARYIDLER TRANSMISSIONINPUT PULLEY 1-9/16" WITH PARKING BRAKE “ENGAGED” JAM NUT DO NOT TOUCH THIS NUT. IF FURTHER BRAKEADJUSTMENT IS NECESSARY CONTACT YOURNEAREST AUTHORIZED SERVICE CENTER/DEPARTMENT OPERATINGARM NUT “A” FIG. 2...

23 SERVICE AND ADJUSTMENTS FIG. 28 KEPS NUT HEXB O L T POSITIVE(RED)CABLE NEGATIVE(BLACK)CABLE TO REMOVE HOOD AND GRILL ASSEMBLY(See Fig. 29) • Raise hood. • Unsnap headlight wire connector. • Stand in front of tractor. Grasp hood at sides, tilt towardengine and lift off of tractor. • To replace, re...

24 STORAGE Immediately prepare your tractor for storage at the end of theseason or if the tractor will not be used for 30 days or more. CAUTION: Never store the tractor withgasoline in the tank inside a buildingwhere fumes may reach an open flameor spark. Allow the engine to coolbefore storing in an...

25 Will not start 1. Out of fuel. 1. Fill fuel tank. 2. Engine not “CHOKED” properly. 2. See “TO START ENGINE” in Operation section. 3. Engine flooded. 3. Wait several minutes before attempting to start. 4. Bad spark plug. 4. Replace spark plug. 5. Dirty air filter. 5. Clean/replace air filter. 6. D...

27 TRACTOR - - MODEL NUMBER S165H42A SCHEMATIC BATTERY FUSE IGNITION SWITCH RED RED RED BLACK IGNITION UNIT HEADLIGHTS REMOVABLE CONNECTIONS BLACK BLACK BLACK WHITE WHITE WHITE RED BLACK ORANGE BLACK BROWN BLACK BLACK BLACK STARTER M SEAT SWITCH (NOT OCCUPIED) GROUNDING CONNECTOR ATT'MENT CLUTCH (CL...

28 28 29 26 24 42 43 27 27 25 41 27 27 40 33 30 8 2 1 27 16 16 52 D.C . A MP ER ES 45 22 21 REPAIR PARTS TRACTOR - - MODEL NUMBER S165H42A ELECTRICAL

30 REPAIR PARTS TRACTOR - - MODEL NUMBER S165H42A CHASSIS AND ENCLOSURES 37 37 3 2 35 3 26 3 35 26 33 10 34 1 208 11 17 29 28 208 13 207 20 207 23 12 51 57 53 52 54 55 24 26 25 26 25 3 31 24 30 209 8 209 6 16 9 15 209 209 5 5 145 18 3 3 38 38 206 212

32 REPAIR PARTS TRACTOR - - MODEL NUMBER S165H42A DRIVE 51 59 51 42 81 38 61 41 42 40 42 39 89 69 56 64 65 212 63 116 70 57 66 27 51 48 151 202 49 47 50 120 150 156 166 165 82 168 163 14 164 21 8 10 83 159 161 198 158 162 171 169 29 28 32 30 52 32 53 35 55 36 62 35 36 22 34 61 16 1 77 77 30 61 52 96...

34 REPAIR PARTS TRACTOR - - MODEL NUMBER S165H42A STEERING ASSEMBLY 62 44 51 54 5 9 5 7 7 9 4 3 32 43 6 43 8 18 19 22 27 23 40 66 29 25 79 8 10 40 11 8 6 9 46 46 8 6 9 2 47 47 17 26 30 28 1 41 42 37 36 37 38 63 11 39 11 80 68 67 67 67 13 65 85 85 68 15 15 15 29 29 82

36 REPAIR PARTS TRACTOR - - MODEL NUMBER S165H42A ENGINE 2 1 OPTIONAL EQUIPMENT Spark Arrester 29 33 37 33 40 62 13 4 85 78 78 81 3 16 23 45 14 38 44 46 32 31

38 REPAIR PARTS TRACTOR - - MODEL NUMBER S165H42A SEAT ASSEMBLY KEY PART NO. NO. DESCRIPTION KEY PART NO. NO. DESCRIPTION 14 72050412 Bolt Rdhd Sht Nk 1/4-20 x 1-1/2 15 134300 Spacer Split 28 x 96 Yel Zinc 16 121250X Spring Cprsn 1 27 Blk Pnt 17 123976X Nut Lock 1/4 Lge Flg Gr 5 Zinc 21 171852 Bolt ...

39 20 2 3 9 7 4 10 7 11 14 WHEELS & TIRES KEY PART NO. NO. DESCRIPTION 1 59192 Cap Valve Tire 2 65139 Stem Valve 3 106222X Tire F Ts 15 X 6 0 - 6 Service 4 59904 Tube Front (Service Item Only) 5 106732X427 Rim Asm 6"front White Service 6 278H Fitting Grease (Front Wheel Only) 7 9040H Bearing...

40 REPAIR PARTS TRACTOR - - MODEL NUMBER S165H42A MOWER LIFT 15 20 16 17 18 20 20 15 20 4 5 6 2 3 1 6 5 4 7 8 12 11 31 32 31 32 19 19 13 13 13 13

42 REPAIR PARTS TRACTOR - - MODEL NUMBER S165H42A MOWER DECK 15 14 13 11 10 9 8 16 68 37 30 31 32 33 146 148 145 150 45 144 147 147 142 149 142 49 50 51 54 52 53 55 56 34 1 46 44 21 22 24 25 26 27 2 28 29 23 21 21 21 18 18 20 2 48 59 19 4 3 5 6 21 40 143 36 40 37 40 159 152 151 153 154 157 158 67 15...

45 LIMITED WARRANTY The Manufacturer warrants to the original consumer purchaser that this product as manufactured is free from defects inmaterials and workmanship. For a period of two (2) years from date of purchase by the original consumer purchaser, we willrepair or replace, at our option, withou...

46 T E C U M S E H ® Issued January 1980Revised January 1991 T E C U M S E H ® SERVICE POLICY WARRANTY LIMITED WARRANTIES FOR NEW PEERLESS GEAR POWER TRAIN COMPONENTS A. Products Warranted Peerless Gear and Machine Division of Tecumseh Products Company (“Tecumseh”), subject to the limitations contai...

47 15 ° MAX. SIGHT AND HOLD THIS LEVEL WITH SKY LINE OR TREE. CUT OUT ON DOTTED LINES THIS IS A 15 ° SLOPE SIGHTING GUIDE ONLY RIDE UP AND DOWN HILL, NOT ACROSS HILL SUGGESTED GUIDE FOR SIGHTING SLOPES FOR SAFE OPERATION Operate your Tractor up and down the face of slopes (not greater than 15 °), ne...