Weber S-460TM - Manuals

6 WWW.WEBER.COM ® 1 1 2 2 3 1 2 Arrow stickers on Frame Rail (1) and Left Side Panel (2) should point toward each other (shown above). Door Stop Bracket (3) should be positioned as shown (left). ASSEMBLY

10 WWW.WEBER.COM ® CAUTION: Use two people to lift and install the Summit ® Built-In frame assembly. A) Lift the frame assembly into the “island” structure opening. Make sure the frame is resting level on the finished surface of the structure. B) Adjust the Front Vent to rest squarely on ground. 8 C...

12 WWW.WEBER.COM ® BATTERY HOUSING WIRING 1 BLACK WIRE 2 GREEN WIRE 3 RED WIRE 4 RED WIRE WARNING: Make sure that all control knobs are turned to the OFF position before connecting the gas supply and operating the grill. ASSEMBLY F ))#œ S-460™ 11 3 4 1 2 3 - D

15 WWW.WEBER.COM ® 15 S-660™ S-460™ A B C 17 Match Holder ASSEMBLY

22 WWW.WEBER.COM ® TYPICAL BULK PROPANE GAS SUPPLY INSTALLATION BUILT-IN GAS LINE LOCATIONS Note: Leave an access in the “island” structure for gas supply and regulator service that is not inside the grill structure. Note: Area should be kept clear of sharp, jagged, or extremely abrasive surfaces to...

23 WWW.WEBER.COM ® 23 Table 6.2(a) Maximum Capacity of Metallic Pipe in Cubic Feet of Gas per Hour for Gas Pressures of 2 psi or Less and a Pressure Drop of 0.3 Inch Water Column. (Based on a 0.60 Specific Gravity Gas) Nominal Iron Pipe Size (Inches) Actual ID: (Inches) Length of Pipe (Feet) 10 20 3...

24 WWW.WEBER.COM ® TYPICAL 20 LP PROPANE GAS SUPPLY INSTALLATION GAS SUPPLY The remote tank enclosure kit provide with you grill shall be used for installations using a 20 lb LP cylinder, mounted in an “island” structure.The remote tank enclosure shall house the included hose and regulator assembly ...

25 WWW.WEBER.COM ® 25 OPERATING WARNING: Only use the Weber ® Tank Enclosure Kit outdoors in a well-ventilated area. Do not use in a garage, building, breezeway or any other enclosed area. WARNING: Your Weber ® Tank Enclosure Kit shall not be used under an unprotected combustible roof or overhang. W...

26 WWW.WEBER.COM ® LOCATING YOUR LP TANK ENCLOSURE KIT When determining a suitable location for your LP Tank Enclosure Kit installation, give attention to concerns such as proximity to traffic paths, and keeping any gas supply lines as short as possible. Never locate the Summit ® LP Tank Enclosure K...

27 WWW.WEBER.COM ® 27 2 4 8 4 2 4 2 2 PARTS LIST Hose and regulator - 1 Tank stand - 1 Tank stand base - 1 Tank Scale - 1 1/4-20 nut - 6 Nylon washer - 12 1/4-20 x 1/2” bolt - 6 Cylinder glide - 2 1/2” Flare Gasket - 2 3/8” Flare Gasket - 2 PARTS LIST / ASSEMBLY 1

29 WWW.WEBER.COM ® 29 A B C D E i ii iv v CONNECT GAS SUPPLY A 58 inch (147.32 cm) corrugated gas line is supplied with the grill. This line needs to pass through the gas inlet opening to the main gas supply. 1) Connect the corrugated gas line to the manifold located on the right hand side of grill ...

30 WWW.WEBER.COM ® VENTILATION WARNING: Ventillation holes must be provided in the structure at the top and bottom to provide ventilation in the event of a gas leak. Ventilation holes can be located in a low visibility area and should be protected by screening material to prevent rodents and insects...