Weber 55571 - Manuals

A-5 General Instructions Your Weber ® gas barbecue is a portable outdoor cooking appliance. With the Weber ® gas barbecue you can grill, barbecue, roast and bake with results that are difficult toduplicate with indoor kitchen appliances. The closed lidand Flavorizer ® bars produce that “outdoor” fla...

A-7 Exploded View Genesis ® Gold C NG 092903 5 1 2 3 4 6 7 8 9 11 10 12 13 14 15 17 18 19 20 21 22 23 24 27 28 29 31 32 3334353637 38 39 4041 42 43 50 51 52 16 30 25 26 53 48 49 33 45 46 47 44

A-8 Exploded View List 1. Hinge Pin 2. Left Endcap 3. Shroud 4. Handle 5. Warm-Up ™ Basket 6. Warming Rack 7. Cooking Grates 8. Flavorizer ® Bars 9. Cooking Box 10. 1/4-20 keps nut 11. Slide Out Bottom Tray 12. Work Surface 13. Catch Pan Holder 14. Left Rear Trim Assembly Arm 15. 1/4 - 14 x 5/8 inch...

A-9 Parts List Cooking Box Assembly - 1 Caster Frame - 1 Wheel Frame - 1 Bottom Rack - 1 Left Trim Assembly - 1 Left Swing Up Table - 1 Side Table - 1 Flavorizer ® Bars - 5 Warm-Up ™ Basket - 1 Warming Rack - 1 Hose - 1 Bottom Tray - 1 Catch-Pan Holder - 1 Catch-Pan - 1 Disposable Drip Pans - 2 Ther...

C-1 Gas Instructions Install Gas Supply General Specifications for Piping Note - Contact your local municipality for buildingcodes regulating outdoor gas barbecue installations.In absence of Local Codes, you must confirm to thelatest edition of ANSI Z223.1. WE RECOMMEND THATTHIS INSTALLATION BE DONE...

C-3 Gas Instructions Check for gas leaks  DANGER Do not use an open flame to check for gas leaks. Besure there are no sparks or open flames in the areawhile you check for leaks. Sparks or open flames willresult in a fire or explosion which can cause seriousbodily injury or death and damage to prope...

D-1 Operating Instructions Lighting Summary lighting instructions are on the control panel. DANGER Failure to open the lid while igniting thebarbecue’s burners, or not waiting 5 minutesto allow the gas to clear if the barbecue doesnot light, may result in an explosive flame-upwhich can cause serious...

D-2 Operating Instructions Manual Lighting DANGER Failure to open lid while igniting thebarbecue’s burners, or not waiting 5 minutesto allow the gas to clear if the barbecue doesnot light, may result in an explosive flame-upwhich can cause serious bodily injury ordeath. 1) Open the lid.2) Make sure ...

D-4 Troubleshooting Problem Check Cure Burners burn with a yellow ororange flame, in conjunction withthe smell of gas. Inspect Weber ® Insect/Spider Screens for possible obstructions.(Blockage of holes.) Clean Weber ® Insect/Spider Screens. (See Section “AnnualMaintenance”) Burner does not light, or...

D-5 Problem Check Cure Side Burner does not light. Flame is low in HIGH position. Flame is very yellow inconjunction with the smell of gas, OR Burner makes popping noise inconjunction with the smell of gas. Push button ignition does notwork. Is gas supply off? Turn supply on. Is the fuel hose bent o...

E-1 Maintenance (1) (1) Main Burner Flame Pattern The Weber ® gas barbecue burners have been factory set for the correct air and gas mixture. The correct flamepattern is shown.1) Burner tube2) Tips occasionally flicker yellow3) Light blue4) Dark blue If the flames do not appear to be uniform through...

E-2 Maintenance Replacing Main Burners 1) Your Weber ® gas barbecue must be OFF and cool. 2) Turn gas OFF at source.3) To remove control panel: take off the burner control knobs. Remove the screws holding the control panel inplace. Lift off the control panel. 4) Unhook the manifold bracket(1) and un...