Weber 55024 - Manuals

B-1 Assembly Instructions B053.a (1) (2) (1) Install the slide out bottom tray You will need: the slide out bottom tray(1), catch panholder(2), catch pan and one disposable drip pan. (1) Hook the ends of the catch pan holder into the hole inthe slide out bottom tray. The front of the catch pan holde...

C-1 Check that all burner valves are off You will need: burner control knobs.Valves are shipped in the OFF position, but you shouldcheck to be sure that they are turned OFF. Put theknob on each valve. Check by pushing down andturning clockwise. If they do not turn, they are off.Proceed to the next s...

D-1 Lighting Summary lighting instructions are on the control panel. DANGER Failure to open the lid while igniting thebarbecue’s burners, or not waiting 5 min-utes to allow the gas to clear if the barbe-cue does not light, may result in an explo-sive flame-up which can cause seriousbodily injury or ...

D-3 Lighting the Side Burner The side burner has a separate ignition system fromthe main cooking box. DANGER Failure to open the lid while igniting the sideburner, or not waiting 5 minutes to allow thegas to clear if the side burner does not light,may result in an explosive flame-up whichcan cause s...

D-5 Annual Maintenance After a period of nonuse, we recommend that youperform the following maintenance procedures for yoursafety. WARNING: Check the hose before each use of the barbecue for nicks, cracking, abrasions orcuts. If the hose is found to be damaged in anyway, do not use the barbecue. Rep...

D-6 General Maintenance Weber Spider Stopper™ Guards Your Weber Gas Barbecue, as well as any outdoor gasappliance, is a target for spiders and other insects.They can nest in the venturi section (Venturi(1), airshutter(2), venturi fin(3) ) of the burner tubes. Thisblocks the normal gas flow, and can ...

D-7 (1) (1) (1) (2) (1) Replacing Main Burners 1) Your Weber Gas Barbecue must be OFF and cool.2) Turn gas OFF at source.3) To remove control panel: take off the burner control knobs. Remove the screws holding the controlpanel in place. Lift off the control panel. 4) Unlatch the Spider Stopper™ Guar...

D-8 Crossover® Ignition System Operations If the Crossover Ignition System fails to ignite the Leftburner, light the Left burner with a match. If the Leftburner lights with a match, then check the CrossoverIgnition System. ■ Check that both the white(1) and black(2) ignition wires are attached prope...

D-9 Troubleshooting Problem Check Cure Burners burn with a yellow ororange flame, in conjunction withthe smell of gas. Inspect Weber Spider StopperGuards for possible obstructions.(Blockage of holes.) Clean Weber Spider StopperGuards. (See Section “AnnualMaintenance”) Burner does not light, or flame...

D-10 Side Burner Troubleshooting Problem Check Cure Side Burner does not light. Flame is low in HIGH position. Flame is very yellow inconjunction with the smell of gas, OR Burner makes popping noise inconjunction with the smell of gas. Push button ignition does notwork. Is gas supply off? Turn suppl...