Weber 42371 - Manuals

55 GAS INSTRUCTIONS Fill liquid propane cylinder Note - The liquid propane cylinder manufacturer is respon-sible for the materials, workmanship and performance of the cylinder. If the cylinder has a defect, malfunctions, or you have a question regarding the cylinder, call the cylin-der manufacturer’...

77 GAS INSTRUCTIONS WARNING : The gas connections of your Summit ® gas grill have been factory tested. We do however recommend that you leak check all gas connections before operating your Summit ® gas grill. Remove control panel Part required: Phillips Screwdriver. Remove the burner control knobs (...

88 GAS INSTRUCTIONS WARNING: Do not ignite burners when leak checking. Check for leaks by wetting the connections with the soap and water solution and watching for bubbles. If bubbles form or if a bubble grows, there is a leak.Check: 1) Gas line-to-manifold connections. WARNING: If there is a leak a...

99 GAS INSTRUCTIONS Liquid Propane Cylinder The liquid propane cylinder manufacturer is responsible for the materials, workmanship and performance of the tank. If the tank has a defect malfunctions, or you have a question regarding the tank, call the tank manufacturer’s customer service center. The ...

10 10 GAS INSTRUCTIONS DOT 4BA240 00/02 (1) (2) • Be sure the regulator is mounted with the small vent hole pointed downward so that it will not collect water. This vent should be free of dirt, grease, bugs etc. • The LP cylinder and connections supplied with your Weber ® gas barbecue have been desi...

11 11 OPERATING INSTRUCTIONS The most important thing to know about grilling is which cooking method to use for a specifi c food, Direct or Indi-rect. The difference is simple: place the food directly over the fi re, or arrange the fi re on either side of it. Using the right method is the shortest r...

12 12 OPERATING INSTRUCTIONS Grilling Tips & Helpful Hints • Always preheat the grill before cooking. Set all burners on HIGH heat and close lid; heat for 10 minutes, or until thermometer registers 500˚-550˚F (260˚-288˚C). • Sear meats and cook with the lid down for perfectly grilled food every ...

13 13 OPERATING INSTRUCTIONS *The grill illustrated may have slight differences than the model purchased. To Extinguish Push down and turn each burner control knob clock-wise to the OFF position. Turn gas supply OFF at the source. 1 2 2 3 6 4,5,8 7 cooking grates. You should see a fl ame. WARNING: I...

15 Problem Check Cure Burners burn with a yellow or orange fl ame, in conjunction with the smell of gas. Inspect Spider / Insect Screens for possible obstructions. (Blockage of holes.) Clean Spider / Insect Screens. (See Section “Annual Maintenance”) Burners do not light. -or- Burners have a small f...

16 16 MAINTENANCE WEBER ® SPIDER /INSECT SCREENS Your Weber ® gas barbecue, as well as any outdoor gas appliance, is a target for spiders and other insects. They can nest in the venturi section(1) of the burner tubes. This blocks the normal gas fl ow, and can cause the gas to fl ow back out of the a...

17 17 MAINTENANCE Replacing Main Burners 1. Your Summit ® gas grill must be OFF and cool. 2. Turn gas OFF at source. 3. Disconnect regulator. 4. Remove cooking grates. 5. Remove Smoker box. 6. Remove Flavorizer ® bars. 7. To remove control panel refer to “Remove the control panel” under “Check for G...

19 19 MAINTENANCE Crossover ® Ignition System Operations If the Crossover ® ignition system fails to ignite the LEFT burner in a burner set, light the LEFT burner with a match. If the LEFT burner lights with a match, then check the Crossover ® ignition system. • Check that both ignition wires (1,2) ...