Toro 14AK81RK744 - Manuals

6 GENERAL SERVICE: 1. Never run an engine indoors or in a poorly ventilated area. Engine exhaust contains carbon monoxide, an odorless, and deadly gas. 2. Before cleaning, repairing, or inspecting, make certain the blade(s) and all moving parts have stopped.Remove the key to prevent unintended start...

7 SECTION 2: SAFETY LABELS Safety labels found on your garden tractor are illustrated below (3/4 actual size). Always follow their instructions and head their warnings. The label part number is listed below each. If you discover a safety label is scratched, damaged or missing, order a replacement im...

8 SECTION 3: INSTRUCTIONAL LABELS Instructional labels found on your garden tractor are illustrated below (3/4 actual size). Always follow their instructions and heed their warnings. If you discover a label is scratched, damaged or missing, order a replacement immediately. FAST SLOW

9 SECTION 4: SLOPE GAUGE 3IGHTANDHOLDTHISLEVELWITHAVERTICALTREE ORACORNEROFABUILDING ORAFENCEPOST &OLDALONGDOTTEDLINEREPRESENTSA—SLOPE —

10 SECTION 5: TRACTOR SET-UP Gas and Oil Fill-up Use only clean, fresh (under 30 days old), unleaded gasoline. Fill tank to no more than 1/2 inch below the top of the filler neck to allow space for fuel expansion. WARNING: Use extreme care when handling gasoline. Gasoline is extremelyflammable and t...

11 Shipping Brace Removal WARNING: Make sure the engine is off, set the parking brake and remove the ignition keybefore removing the shipping brace . • Locate the shipping brace, if present, and warning tag found on the right side of the cutting deck. • While holding the discharge chute with your le...

12 SECTION 6: KNOW YOUR GARDEN TRACTOR Figure 4 NOTE: Any reference in this manual to the RIGHT or LEFT side of the tractor is observed from operator’s position. A Systems Indicator Monitor/Hour Meter G Ignition Switch Module B PTO (Blade Engage) Knob H Brake Pedal C Choke Control I Drive Pedal D Pa...

13 Throttle Control The throttle control lever is located on the left side of the tractor’s dash panel. This lever controls the speed of the engine. When set in a given position, the throttle will maintain a uniform engine speed. IMPORTANT: When operating the tractor with the cutting deck engaged, b...

14 Systems Indicator Monitor / Hour Meter LCD Located in the center of the tractor’s console, the systems indicator monitor records, and displays on its LCD, hours of tractor operation whenever the ignition key is rotated out of the STOP position. The Indicator Monitor will also remind the operator ...

15 SECTION 7: OPERATING YOUR GARDEN TRACTOR Safety Interlock System This tractor is equipped with a safety interlock system for the protection of the operator. Before each use, check the safety interlock system for proper operation. If the interlock system should ever malfunction, do not operate the...

16 Starting the Engine WARNING: Do not operate the tractor if the interlock system is malfunctioning. Thissystem was designed for your safety andprotection. NOTE: Refer to the TRACTOR SET-UP on page 10 of this manual for Gasoline and Oil fill-up instructions. • Insert the tractor key into the igniti...

17 Driving On Slopes Refer to the SLOPE GAUGE on page 9 to help determine slopes where you may operate the tractor safely. WARNING: Do not mow on inclines with a slope in excess of 15 degrees (a rise ofapproximately 2-1/2 feet every 10 feet). Thetractor could overturn and cause seriousinjury. • Mow ...

18 Engaging the PTO (Blades) Engaging the PTO transfers power to the cutting deck or other (separately available) attachments. To engage the PTO, proceed as follows: • Move the throttle control lever to the FAST (rabbit) position. • Pull the PTO/Blade Engage knob outward into the engaged (ON) positi...

19 SECTION 8: MAKING ADJUSTMENTS WARNING: Never attempt to make any adjustments while the engine is running, Leveling the Deck NOTE: Check the tractor’s tire pressure before performing any deck leveling adjustments. Refer to Tires on page 26 for information regarding tire pressure. Front To Rear The...

20 Parking Brake Adjustment WARNING: Never attempt to adjust the brakes while the engine is running. Alwaysdisengage PTO, stop engine and remove keyto prevent unintended starting. If the tractor does not come to a complete stop when the brake pedal is completely depressed, or if the tractor’s rear w...

21 SECTION 9: MAINTAINING YOUR GARDEN TRACTOR NOTE: Refer to Maintenance Chart on page 31 for a reference of recommended maintenance intervals. WARNING: Before performing any maintenance or repairs, disengage PTO, setparking brake, stop engine and remove key toprevent unintended starting. Engine Mai...

22 IMPORTANT: The engine may overheat and/or damage may result if the oil level is below the ADD or over the FULL on the dipstick. • Reinstall the oil fill cap/dipstick securely onto the oil fill tube. IMPORTANT: The oil fill cap/dipstick must be installed securely onto the tube at all times when th...

23 IMPORTANT: The oil fill cap/dipstick must be installed securely onto the tube at all times when the engine is operating . Severe engine damage could result from a failure to do so. • Start the tractor engine and allow it to run for thirty seconds, then stop the engine and remove the ignition key....

24 • Check the gap using a feeler gauge and adjust, if necessary, by carefully bending the ground electrode. See Figure 15. Set the spark plug gap to .76 mm (0.030 in.). Figure 15 • Reinstall the spark plug into the cylinder head. Torque the spark plug to 28/32 ft. lb. • Place the spark plug wire bo...

25 Lubrication WARNING: Before lubricating, repairing, or inspecting, always disengage PTO, setparking brake, stop engine and remove key toprevent unintended starting. Engine Refer to Engine on page 21 for instruction regarding all engine-related lubrication. Front Wheels Each of the front wheel axl...

26 SECTION 10: SERVICE WARNING: Before servicing, repairing, or inspecting, always disengage PTO, setparking brake, stop engine and remove key toprevent unintended starting. Tires WARNING: Never exceed the maximum inflation pressure shown on the sidewall of thetire. The recommended operating tire pr...

27 IMPORTANT: When replacing the blade, be sure to install the blade with the side of the blade marked ‘‘Bottom’’ (or with a part number stamped in it) facing the ground when the mower is in the operating position. IMPORTANT: Use a torque wrench to tighten the blade spindle hex flange nut to between...

28 • Gently slide the cutting deck toward the front of the tractor allowing the hooks on the deck to release themselves from the deck stabilizer rod. • Gently slide the cutting deck (from the right side) out from underneath the tractor. Changing the Deck Belt WARNING: Be sure to shut the engine off,...

30 SECTION 11: OFF-SEASON STORAGE Clean and lubricate the tractor as instructed in Section 7: MAINTAINING YOUR GARDEN TRACTOR on page 21 of this manual before storing for an extended period. Engine If the engine will be out of service for two months or more, use the following storage procedure: • Cl...

31 SECTION 12: MAINTENANCE CHART * Model GT2200 Before Each Use After Initial 24 Hours Every 10 Hours Every 25 Hours Every 100 Hours Every Season Prior to Storing Clean Hood/Dash Louvers Check Engine Oil Level Clean and Re-oil AirFilter’s Foam Precleaner Replace Air Filter Element Change Engine Oil ...

32 SECTION 13: TROUBLESHOOTING Trouble Possible Cause(s) Corrective Action Engine fails to start PTO (Blade Engage) knob engaged. Parking brake not engaged.Spark plug wire(s) disconnected.Cchoke control not in correct starting position.Choke not activatedFuel tank empty, or stale fuel.Blocked fuel l...

36 IMPORTANT: To obtain warranty coverage owner must present an original proof of purchase and applicable maintenance records to the servicing dealer. Please see the operator’s manual for information on required maintenance and service intervals. The limited warranty set forth below is given by The ...