Superior VF6000-CMP-2 - Manuals

Page 2 - Inventory; TABLE OF CONTENTS; UNVENTED GAS ROOM HEATER SPECIFICATIONS AND TECHNICAL DETAILS

NOTE: DIAGRAMS & ILLUSTRATION NOT TO SCALE. 2 These heaters are manually controlled. A spark ignition system (piezo) allows the heaterpilot gas to be lit without the use of matches orbatteries and permits operation of the heaterduring a power outage. These heaters are fitted with a specially de-...

Page 4 - Figure 1; LOCATION OF FIREPLACE

NOTE: DIAGRAMS & ILLUSTRATION NOT TO SCALE. 4 Figure 1 To ensure even heat distribution, it is best toposition the heater centrally against the long-est wall of the room. Make sure there is ad-equate ventilation where the heater is installed.The gas appliance will shut off if the oxygenlevel fal...

Page 5 - PREINSTALLATION; Check Gas Type; Figure 3; Clearances

NOTE: DIAGRAMS & ILLUSTRATION NOT TO SCALE. 5 PREINSTALLATION Check that all listed parts have been received. Carefully inspect the heater case and contentsfor shipping damage and immediately informthe dealer from whom you purchased the gasfireplace if any damage is found. The appliance is shipp...

Page 6 - Frame VF5000 appliance enclosures

NOTE: DIAGRAMS & ILLUSTRATION NOT TO SCALE. 6 Note: Framing dimensions in Figures 4 - 9 are calculated for a nailing flange depth of ¹⁄₂ " (13 mm). Figure 4 Figure 5 Figure 6 Figure 7 Figure 8 Figure 9 The header may be in direct contact with the topmetal spacers, but must not rest on them o...

Page 7 - Step 5. Connecting Gas Line –

NOTE: DIAGRAMS & ILLUSTRATION NOT TO SCALE. 7 Figure 11 Control Valve Lower Control Compartment Door Step 3. Ensure the hood is properly positioned in the open area above the appliance door. Ifrequired insert the tabs, on each end of thehood, into the bracket at each end. Bend thetwo tabs over t...

Page 8 - Surround Installations; The appliance must; Finished Wall Details; The header may rest on the top spacers

NOTE: DIAGRAMS & ILLUSTRATION NOT TO SCALE. 8 Surround Installations Note: The VF5000/VF6000 series appliances must be installed giving full consideration tothe clearance and height requirements identi-fied in this manual. Figure 15 White(Supply) Black(Supply) BipolarTerminalScrew Blower(Lower)O...

Page 10 - Replace logs if removed for pilot inspection.; Installing the Optional Glass Door; OPTIONAL EQUIPMENT; Rear Burner Flame Characteristics –; The; Main Burner –; The flames at the front burner; Appliance Operation; With gas line

NOTE: DIAGRAMS & ILLUSTRATION NOT TO SCALE. 10 The pilot flame should be steady, not lifting orfloating. Flame should be blue in color withtraces of orange at the outer edge. The top 3/8" (10 mm) at the pilot generator(thermopile) should be engulfed in the pilotflame (NG only). Replace logs ...

Page 11 - and Step 6 for detailed installation instructions.

NOTE: DIAGRAMS & ILLUSTRATION NOT TO SCALE. 11 Figure 23 Remote Control Kit The Model RCL adds the convenience of re-mote control for your appliance. The kit in-cludes a wireless, hand held transmitter and areceiver that replaces the wall switch. Thisspecial receiver permits either manual or re-...

Page 13 - ACCESSORIES AND COMPONENTS

NOTE: DIAGRAMS & ILLUSTRATION NOT TO SCALE. 13 VF5GDK Glass Door Panel VF6GDK Gas Flex Line Kit FFGC VF5RLK Refractory Liner Kit VF6RLK DecorativeVolcanic Stone FDVS VF5-PBH Brass Hood Kit VF6-PBH VF5-BRLK Brass Louver Kits VF6-BRLK DAT-5-1 2-Piece Decorative DAT-5-4 Arch Frame Kits DAT-6-1 BSK-...

Page 14 - Front View; Left Side View

NOTE: DIAGRAMS & ILLUSTRATION NOT TO SCALE. 14 VF6000 SPECIFICATIONS Figure 25 VF5000 SPECIFICATIONS Figure 24 37" (940 mm) 36" (914 mm) 30" (762 mm) 31-1/2" (800 mm) 15" (381 mm) Front View Top View 27" (686 mm) 36" (914 mm) 15-1/2" (394 mm) Left Side View (Right...

Page 15 - TROUBLESHOOTING GUIDE FOR UNVENTED GAS PRODUCTS

NOTE: DIAGRAMS & ILLUSTRATION NOT TO SCALE. 15 1. When igniter button ispressed, there is no sparkat ODS/pilot. 2. Heater produces unwantedodors. 3. Heater shuts off in use(ODS operates). 4. Gas odor even when controlknob is in “OFF” position. 5. When igniter button ispressed, there is spark atO...

Page 16 - LIGHTING INSTRUCTIONS – MILLIVOLT; FOR YOUR SAFETY READ BEFORE LIGHTING; WHAT TO DO IF YOU SMELL GAS; TO TURN OFF GAS TO APPLIANCE

NOTE: DIAGRAMS & ILLUSTRATION NOT TO SCALE. 16 LIGHTING INSTRUCTIONS – MILLIVOLT FOR YOUR SAFETY READ BEFORE LIGHTING • Do not use any phone in your building. • Immediately call your gas supplier from a neighbor’s phone. • If your gas supplier cannot be reached, call the fire department. C. Use ...

Page 18 - REPLACEMENT PARTS LIST; Description

NOTE: DIAGRAMS & ILLUSTRATION NOT TO SCALE. 18 REPLACEMENT PARTS LIST VF5000-CMN VF6000-CMN VF5000-CMP VF6000-CMP No. Description Part No. Qty. Part No. Qty. 1. SIT Valve - Millivolt (Natural) H4173 1 H4173 1 Honeywell Valve - Millivolt (Natural) 24M13 1 24M13 1 SIT Valve - Millivolt (Propane, L...

Page 19 - REPLACEMENT PARTS

NOTE: DIAGRAMS & ILLUSTRATION NOT TO SCALE. 19 REPLACEMENT PARTS 9 10 3 15 14 4 7 6 5 16 13 1 12 (SIT Valve Shown) 14 2 8 11

Page 20 - LHP

NOTE: DIAGRAMS & ILLUSTRATION NOT TO SCALE. 20 Printed in U.S.A. © 1997 by Lennox Hearth Products P/N 903302 REV. N 04 /20 1 0 LHP reserves the right to make changes at any time, without notice, in design, materials, specifications, and prices, and also to discontinue colors, styles and products...