Superior CFST-CMN - Manuals

Page 2 - GENERAL INFORMATION; TABLE OF CONTENTS; Electrical Wiring – Optional Blower . page 10; UNVENTED GAS ROOM HEATER SPECIFICATIONS AND TECHNICAL DETAILS

NOTE: DIAGRAMS & ILLUSTRATION NOT TO SCALE. 2 GENERAL INFORMATION The CFST and CFPF Series Unvented RoomHeaters covered in this manual feature ceramicfiber split logs which glow realistically when theheater is operating. These heaters have a standing pilot and aremanually controlled through the ...

Page 5 - PREINSTALLATION; DO NOT; ASSEMBLY STEPS

NOTE: DIAGRAMS & ILLUSTRATION NOT TO SCALE. 5 Minimum clearance to combustibles are: Appliance: side and back - 0"floor - 0"adjacent wall - 6"ceiling - 41 ⁵⁄₈ ” (1210 mm) Figure 1 A hearth extension is not required with thisappliance. If a hearth extension is used, do notblock the lo...

Page 6 - Framing Dimensions; Figure 3; Gas; drywall finish.; Front View

NOTE: DIAGRAMS & ILLUSTRATION NOT TO SCALE. 6 CFST FRAMING SPECIFICATIONS CFST APPLIANCE SPECIFICATIONS A 22 ³⁄₄ " (578 mm)* B 43" (1092 mm) Min. C 43" (1092 mm) Min. Framing Dimensions Figure 3 Figure 4 Figure 5 C A B Gas Line 2 x 4 Wall Framing Top View * ¹⁄₂ " (13mm) Required ...

Page 7 - CFPF FRAMING SPECIFICATIONS; End View

NOTE: DIAGRAMS & ILLUSTRATION NOT TO SCALE. 7 Figure 6 Figure 7 Figure 8 C A B Gas Line CFPF FRAMING SPECIFICATIONS CFPF APPLIANCE SPECIFICATIONS Gas Line Energy Wall 2 x 4 Outside Wall Drywall Drywall * Bracket Bracket Framing Top View * ¹⁄₂ " (13mm) Required Air Space Clearance A 22 ³⁄₄ &#...

Page 8 - Gas Stub; Figure 9

NOTE: DIAGRAMS & ILLUSTRATION NOT TO SCALE. 8 Step 2 . Route a ¹⁄₂ " (13 mm) gas line along the left or right side framing ( Figure 9 ). All appliances have a 3" long ³⁄₈ " NPT nipple installed at the valve. To quickly and easilycomplete the gas line routing, use the gas flexline kit...

Page 10 - Assembling the Logs; The heater includes a set of ceramic; The

NOTE: DIAGRAMS & ILLUSTRATION NOT TO SCALE. 10 Assembling the Logs WARNING: DO NOT ADD EXTRA LOGSOR ORNAMENTS SUCH AS PINE CONES,VERMICULITE OR ROCK WOOL. USINGT H E S E A D D E D I T E M S C A N C A U S ESOOTING. Figure 15 Step 9. The heater includes a set of ceramic fiber logs. The logs are as...

Page 11 - Flame Appearance; Middle Ember Bed Flame Characteristics –

NOTE: DIAGRAMS & ILLUSTRATION NOT TO SCALE. 11 The installation of the logs and twigs, should becomplete and resemble Figures 15, 16 and 19. After setting the logs and rockwool into posi-tion as described above, ensure the logs areproperly and firmly situated. The heater will notfunction as inte...

Page 12 - and Step 6 for detailed installation instructions.; Step 11. Installing the Glass Door –

NOTE: DIAGRAMS & ILLUSTRATION NOT TO SCALE. 12 The appliances covered in this manual areheater rated and produce a great deal of heat.Decorative brass trim pieces and hoods maytarnish because of their proximity to the heateropening and front face. Tarnishing of thesepieces is normal, unavoidable...

Page 14 - ACCESSORIES AND COMPONENTS

NOTE: DIAGRAMS & ILLUSTRATION NOT TO SCALE. 14 ACCESSORIES AND COMPONENTS Forced Air Kit FAB-1100 Remote Control Kit RCK Rocker Switch Kit RS Wall Switch Kit WSK Gas Flex Line Kit GFLV DecorativeVolcanic Stone DVS 4-Piece DecorativeArch Frame Kit-Main Panel DAT-6-4 -End Panel DAET-6-4 1-Piece De...

Page 15 - OPERATING INSTRUCTIONS; FOR YOUR SAFETY READ BEFORE LIGHTING

NOTE: DIAGRAMS & ILLUSTRATION NOT TO SCALE. 15 OPERATING INSTRUCTIONS FOR YOUR SAFETY READ BEFORE LIGHTING LIGHTING INSTRUCTIONS 1. Stop! Read the safety information above. 2. Make sure manual shut-off valve is fully open. 3. Locate gas control knob and piezo. 4. Depress control knob in and turn...

Page 16 - Pilot Location; Turn Control Knob to “ON” Position

NOTE: DIAGRAMS & ILLUSTRATION NOT TO SCALE. 16 Note: Knob cannot be turned from “PILOT” to “OFF” unless the knob is pushed in slightly. Do not force. Figure 23 Pilot Location Figure 24 Figure 25 Turn Control Knob to “OFF” Position Turn Control Knob to “PILOT” Position E A TPTH TP TH PI LO T H I ...

Page 17 - Description

NOTE: DIAGRAMS & ILLUSTRATION NOT TO SCALE. 17 CFST REPLACEMENT PARTS LIST CFST GAS CONTROLS — MILLIVOLT CFST-CMN CFST-CMP No. Description Part No. Qty. Part No. Qty. 1. Gas Fireplace Assembly 123071 1 123072 1 2. Bar, Louver (Black) 104951 8 104951 8 3. Hood (Black), Clean Face 108971 2 108971 ...

Page 18 - REPLACEMENT PARTS – CFST

NOTE: DIAGRAMS & ILLUSTRATION NOT TO SCALE. 18 REPLACEMENT PARTS – CFST 8 20 9 21 22 23 a. b. c. d. f. g. e. 3 2 1 7 6 2 11 4 5 10

Page 20 - REPLACEMENT PARTS – CFPF

NOTE: DIAGRAMS & ILLUSTRATION NOT TO SCALE. 20 REPLACEMENT PARTS – CFPF 11 20 12 21 22 23 13 4 2 1 10 14 7 6 2 5 3 3 9 a. b. c. d. e. 8 f. g.

Page 21 - TROUBLESHOOTING GUIDE FOR UNVENTED GAS PRODUCTS

NOTE: DIAGRAMS & ILLUSTRATION NOT TO SCALE. 21 1. When igniter button ispressed, there is no sparkat ODS/pilot. 2. Heater produces unwantedodors. 3. Heater shuts off in use(ODS operates). 4. Gas odor even when controlknob is in “OFF” position. 5. When igniter button ispressed, there is spark atO...

Page 24 - SFC

NOTE: DIAGRAMS & ILLUSTRATION NOT TO SCALE. 24 Printed in U.S.A. © 1997 by SFC P/N 903589 REV. E 02/2004 Catalytic Gas Fireplace Manufacturer's Limited Warranty 10 Years T H E W A R R A N T Y T h e m a n u f a c t u r e r w a r r a n t s t h e c o m p o n e n t s o f t h i s C a t a l y t i c G ...