Sterling BB122430 - Manuals

Page 2 - ENGINE STARTER; Setup Up

ENSURE ALL NEGS ARE COMMON DOMESTIC BATTERY SYSTEM Battery temperature sensor cable ( supplied ) Remote control and information panel ( optional remote kit ) Full System wiring.(including optional remote kit if used) ENGINE STARTER BATTERY CE 1234 Power Management with AMP Hr Counter Sterling power ...

Page 3 - in; in; in; lic; fig

m a in e n g in e a lt e rn a to r d /c b a tt e ry c h a rg e r d o m e st ic /a u x b a tt e ry b a n k d /c b a tt e ry c h a rg e r B o w t h ru st e r b a tt e ry b a n k e n g in e a lt e rn a to r st a rt e r m o to r d o m e st ic /a u x b a tt e ry b a n k a lr e a d y i n st a lle d s p li...

Page 4 - l p; SC

B a tt e ry -B a tt e ry D ig it a l C h a rg e r St e rl in g p o w e r p ro d u c ts C E o n /o ff 1 2 3 4 li g h t a la rm a la rm A la rm s h u td o w n S y s te m d is e n g a g e d L o w i n p u t v o lt a g e S y s te m o .k . 2 1 3 4 I n B a t v = 1 3 . 7 v C u r r e n t = 3 8 A 2 0 m i n O ...

Page 5 - Advantages of this unit.; installation; Installation see fig 8; , to ensure no alarms or damage to the

Why do I need the d/c battery charger? What does it do? Advantages of this unit. installation : no direct connections to the standard engine alternator ensures the engine battery if maintained and well looked after ensures there is no voltage rise on the engine management system no vehicle warrantee...

Page 6 - go to the battery type program dip switches on the unit and set; battery supplier

Program the battery type into the unit, Non sealed lead acid Gel / Exide spec. Gel U.S.A. spec. Sealed lead acid/ A.G.M. My advise is where possible use the open lead acid batteries, which are also by far the lowest cost . Due to their slow recharge rate, avoid gel batteries for fast charging cycles...

Page 7 - then; The LED meanings and functions fig8; hen continue your journey and have the alternator repaired.

If on start up nothing happens, Auto pause switch off. WHAT CABLE TO USE IN mm sqA charger or inverter up to cable run distance 0-1.5 mtr 1.5 4 mtr 0-25 amps 6 mm sq 10 mm sq 25-45 amps 16 mm sq 25 mm sq 45-85 amps 25 mm sq 35 mm sq 85-125 amps 35 mm sq 50 mm sq 125- 180 amps 50 mm sq 70 mm sq 180-3...

Page 8 - BATTERY OUTPUT OVER TEMPERATURE:; Red : This shows that the battery temperature sensor has picked up; Alarm; Other application ideas see fig 1-4

BATTERY OUTPUT OVER TEMPERATURE: Red : This shows that the battery temperature sensor has picked up a temperature in excess of 50 deg C at its source ( where ever you have fitted it ) this will trip the unit until it has been reset. Please find the fault before resetting HEAT-SINK OVER TEMP . yellow...

Page 9 - All voltages refer to a default temperature of 20 deg c

this displays the output voltage and current of the battery you are charging. ( a less current but higher voltage ) ( this is the setup information screen ) This screen gives different information depending on the system cycle, it is informing you., WET OPEN= wet open lead acid cell batteries, this ...