Page 2 - TABLE OF CONTENTS; SAVE THESE INSTRUCTIONS; TECHNICAL SPECIFICATIONS
2 2 Safety Guidelines..................................................................................................................... 3 Key Parts Diagram.................................................................................................................... 5 Assembly Instructions.....
Page 3 - SAFETY GUIDELINES; Important Safety Information
3 Hot Surface Flying Objects Warning Electrical Shock Toxic Fumes Operator's Manual Bursting Fire SAFETY GUIDELINES Important Safety Information Safety Symbols and Meanings The manufacturer cannot possibly anticipate every possible circumstance that might involve a hazard. The warnings in this manua...
Page 4 - SAFETY INFORMATION
4 . WARNING This product can expose you to chemicals including lead, which is known to the State of Californiato cause cancer, birth defects or other reproductive harm. For more information go to www.P65Warnings.ca.gov. WARNING: SAFETY INFORMATION DO NOT OPERATE THIS UNIT UNTIL YOU READ AND UNDERSTA...
Page 5 - K. Power Cord; KEY PARTS DIAGRAM
5 K. Power Cord E. Air Pressure Regulator G. Outlet Pressure Gauge F. Tank Pressure Gauge D. ON/OFF Switch H. Quick Coupler B. Air Compressor Pump A. Electrical Motor J. Air Tank I. Drain Valve C. Safety Valve C B I G K H E A F J D KEY PARTS DIAGRAM
Page 6 - PARTS DESCRIPTION
6 A B C I J E K D F G H Figure 1 DANGER Grounded outlet Grounding Pin Plug PARTS DESCRIPTION Electric MotorThe motor is used to power the pump. It is equipped with a thermal overload protector. If the motor overheats for any reason, the thermal overload protector will shut it down in order to preven...
Page 7 - ASSEMBLY INSTRUCTIONS; The carton should contain:
7 Fig B 1 3 2 ASSEMBLY INSTRUCTIONS 1 Fig A 12 / 31 cm 2 3 Unpack the air compressor unit. Inspect the unit for damaged. If the unit has been damaged, contact the retailer immediately.Check the air compressor’s identification label to ensure that you have purchased the intended model and that it has...
Page 8 - OPERATING INSTRUCTIONS; Break in the pump
8 OPERATING INSTRUCTIONS Fig E 1 Fig C OFF 1 Fig D 1 OFF ON Fig F ON 1 Break in the pump 1.Set the ON/OFF switch (1) to the OFF position (Fig C). 2.Open tank drain valve (1) by turning it counter-clockwise to permit the air to escape 3.Turn the air pressure regulator knob (1) clockwise until it stop...
Page 9 - Fig K; Fig L
9 OPERATING INSTRUCTIONS Fig J Fig K 2 1 OFF ON Fig L 1 3 2 Before each start-up 1.Set the ON/OFF switch (1) to the OFF position (Fig H). 2.Turn the air pressure regulator knob (1) counter-clockwise until it stops (Fig I). 3.Attach hose and accessories (Fig J).(Hose and accessories need to be purcha...
Page 10 - MAINTENANCE; Check Safety Valve
10 DESCRIPTION / REASON SERVICE INTERVAL ITEM Daily Daily Monthly Prior to storing MAINTENANCE Weekly Through normal operation of your air compressor, condensation of water will accumulate in the tank. To prevent corrosion of the tank from the inside, condensation must be drained at the end of every...
Page 11 - TROUBLESHOOTING
11 TROUBLESHOOTING The motor will not run or start. POSSIBLE CAUSE PROBLEM SOLUTIONS The motor runs continuously when the ON/OFF switchis in the ON position. The regulator does not regulate the pressure. The power cord is not plugged in.The on/off switch is in the O (OFF) position.The extension cord...
Page 13 - EXPLODED VIEW
Page 14 - PARTS LIST
14 PARTS LIST Description Qty. No. 0102030405060708091011121314 17 16 15 Capacitor ShroudClamp Ring550 Mute MachineElbow Fitting Crimp Cap Quick Coupler Check Valve Screw M4x12 Transfer Tube HandgripPressure RegulatorControl Panel Crimping Board CLT-1 Rubber Hose Pressure Regulator Knob 121 2 11 12 ...
Page 15 - STEALTH WARRANTY; LIMITED LIFETIME WARRANTY; ONLY THE PUMP AND MOTOR ARE COVERED IN THE; SAVE YOUR RECEIPTS - THIS WARRANTY IS
STEALTH WARRANTY LIMITED LIFETIME WARRANTY 15 Warranty covers any defects in materials or workmanship of the enclosed product. Alton Industry Ltd. Group will repair or replace any defective materials due to craftsmanship of the product. THIS WARRANTY DOES NOT COVER ANY PROBLEM CAUSED BY MISUSE, ABUS...
