State Water Heaters SSE-5 - Manuals

Page 3 - TABLE OF CONTENTS; APPROVALS MODEL & RATING PLATE; ASME; FOREWORD

3 TABLE OF CONTENTS PAGE ROUGH-IN-DIMENSIONS ...................................... 2 RECOVERY CAPACITY ....................................... 2 FOREWORD ......................................................... 3 TABLE OF CONTENTS ......................................... 3 APPROVALS & MODEL &...

Page 4 - GETTING TO KNOW YOUR WATER HEATER

4 GETTING TO KNOW YOUR WATER HEATER Below is an illustration of the water heater with its features calledout. The text of this manual will refer to the items shown. FIGURE 1 NOTE:• 3/4” NPT SSE 5 THRU 50 MODELS• 1 1/4” NPT SSE 65 THRU 120 MODELS• A LOW WATER CUTOFF SWITCH IS AVAILABLE AS AN OPTIONAL...

Page 5 - INSTALLATION

5 GENERAL SAFETY INFORMATION INSULATION BLANKETS Insulation blankets available to the general public for externaluse on electric water heaters are not approved for use on yourState water heater. The purpose of an insulation blanket is toreduce the standby heat loss encountered with storage tankwater...

Page 6 - RELIEF DEVICES; TEMPERATURE LIMITING CONTROL; CAUTION

6 RELIEF DEVICES An unplugged 3/4” NPT relief valve opening is provided forinstalling temperature and pressure relief valve. CAUTION: TO REDUCE THE RISK OF EXCESSIVE PRESSURES AND TEMPERATURE IN THIS WATER HEATER INSTALLTEMPERATURE AND PRESSURE PROTECTIVE EQUIPMENTREQUIRED BY LOCAL CODES but not les...

Page 7 - PIPING DIAGRAM; ONE OR TWO TEMPERATURE - ONE HEATER; DANGER

7 PIPING DIAGRAM ONE OR TWO TEMPERATURE - ONE HEATER ONE OR TWO TEMPERATURE - TWO HEATER DANGER : TEMPERATURE SETTING SHOULD NOTEXCEED SAFE USE TEMPERATURE ATFIXTURES. SEE WATER TEMPERATURECONTROL WARNING ON PAGES 17 & 18. IFHIGHER PREHEAT TEMPERATURES AREN E C E S S A RY TO O B TAIN ADEQUAT EBO...

Page 13 - ELECTRICAL; GENERAL; BRANCH CIRCUIT

13 60°C 75°C 85°C 90°C 60°C 75°C 85°C 90°C (140°F) (167°F) (185°F) (194°F) (140°F) (167°F) (185°F) (194°F) TYPES TYPES TYPES TYPES TYPES TYPES TYPES TYPES RUW, T FEPW V, MI TA, TBS RUW, T RH, RHW V, MI TA, TBS, AWG TW, UF RH,RHW SA, AVB TW, UF RUH SA, AVB RUH, SIS, =FEP, THW, SIS, AWG THW, =FEPB, TH...

Page 16 - -1 PHASE CONVERSIONS; -1 PHASE CONTACTOR JUMPER CONFIGURATION

16 3-1 PHASE CONVERSIONS In the case where the unit is phase convertible and it has only one contactor, jumper wires (provided) must be added according tothe phase of the supply voltage. See the diagram below. For single-phase connection, jumpers A-C and B-D must be added. Forthree-phase connection,...

Page 18 - OPERATION

18 DANGER THIS WATER HEATER IS EQUIPPED WITH AN ADJUSTABLETHERMOSTAT TO CONTROL WATER TEMPERATURE. HOTWATER TEMPERATURES REQUIRED FOR AUTOMATICDISHWASHER AND LAUNDRY USE CAN CAUSE SCALDBURNS RESULTING IN SERIOUS PERSONAL INJURY AND/OR DEATH. THE TEMPERATURE AT WHICH INJURY OCCURSVARIES WITH THE PERS...

Page 19 - MAINTENANCE; DRAINING; FLUSHING

19 MAINTENANCE Always close the front access door after making a temperatureadjustment. Turn on electricity. DRAINING The water heater must be drained if it is to be shut down andexposed to freezing temperatures. Maintenance and serviceprocedures may also require draining the heater. 1. Turn off the...

Page 20 - CHECKLIST

20 6. Remove the elements from the openings. • Use a twisting, pulling action to remove elementsscaled beyond size of the tank openings. • Brush loose scale from elements. 7. Lime scale removal. • Place limed ends of heating elements into UN•LIMEdelimer and allow scale to dissolve. Do not permitdeli...

Page 21 - ANODE MAINTENANCE; REPLACEMENT PARTS

21 When such a condition is encountered, local codes or inspectionagency should be consulted to determine which system isacceptable in your area. These may consist of: • Installation of a second relief valve set to lowerthan the primary safety relief valve. • An expansion tank of suitable pressure a...

Page 22 - LEAKAGE CHECKPOINTS

22 LEAKAGE CHECKPOINTS INSTRUCTIONS : USE THIS ILLUSTRATION AS A GUIDE WHEN CHECKING FOR SOURCES OF WATER LEAKAGE. YOU OR YOUR DEALER MAY BE ABLE TO CORRECT WHAT APPEARS TO BE A PROBLEM. Water on side of the tank may be condensation due to thepanel or insulation not being in place. Relief valve oper...

Page 23 - MODEL SSE LIMITED WARRANTY

23 MODEL SSE LIMITED WARRANTY State Water Heaters, the warrantor, extends the following LIMITED WARRANTY to the owner of this water heater: 1. THE TANK If the glass-lined tank in this water heater shall prove upon examination by the warrantor to have leaked due to natural corrosion from potablewater...